2005 CHEVROLET CORVETTE Complaints

I OWN A 2005 CHEVROLET CORVETTE THAT I PURCHASED FROM A GMC DEALERSHIP AS A CERTIFIED PRE-OWNED VEHICLE. THE CAR WAS PURCHASED ON 05/22/2010. APPROXIMATELY 2 WEEKS LATER I SAW A WARNING ON THE DASHBOARD INDICATING "SERVICE ACTIVE HANDLING SYSTEM". I CONTACTED THE DEALERSHIP CLOSEST TO WHERE I WORK AND MADE AN APPOINTMENT TO BRING THE VEHICLE IN FOR A RECALL THAT WAS SUPPOSED TO ADDRESS THE ISSUE. THE WORK WAS COMPLETED ON 06/15/2010. ON 07/09/2010, AND 07/11/2010, THE WARNING REAPPEARED. I BROUGHT THE VEHICLE IN FOR SERVICE ON 07/12/2010 BUT THE SERVICE DEPARTMENT WAS UNABLE TO REPAIR IT AT THAT TIME BECAUSE NO "CODES" WERE BEING FOUND INDICATING A PROBLEM. I UNDERSTAND, THROUGH RESEARCHING THE PROBLEM ON THE INTERNET THAT THERE IS A POSSIBILITY OF BRAKES LOCKING UP DUE TO THIS PROBLEM, AND THIS CAUSES ME CONCERN. THEY ARE STILL GOING TO TRY TO RECTIFY THE PROBLEM AND ARE VERY COOPERATIVE AT THIS TIME. I BELIEVE THERE IS A CURRENT INVESTIGATION UNDER INVESTIGATION NUMBER EA09-002. I ALSO UNDERSTAND THAT THE RECALL IS NOT CORRECTING THE PROBLEM, AS IT DID NOT DO SO IN MY CAR, NOR HAS IT BEEN EFFECTIVE IN OTHERS THAT I HAVE FOUND THROUGH THE INTERNET. AT THIS TIME I HAVE NOT HAD AN ISSUE WITH BRAKES LOCKING, IT IS ONLY THE DASHBOARD WARNING AT THIS TIME. *TR

2005 CORVETTE--SERVICE ACTIVE HANDLING SYSTEM LIGHT CAME ON ,WARNING ME OF A PROBLEM. BEFORE ANY SERVICE COULD BE DONE THE VEHICLES RIGHT FRONT WHEEL LOCKED UP CAUSING ME TO BE OUT OF CONTROL AND VEERING TO THE RIGHT. I HAD IT REPAIRED BY THE DEALER AND SEVERAL WEEKS LATER RECEIVED A SAFETY RECALL FOR THE IDENTICAL PROBLEM. THE DEALER CHECKED THE VEHICLE IN ACCORDANCE WITH THE RECALL AND INDICATED THAT I HAD THE REPAIRS DONE AT MY EXPENSE PRIOR TO THE RECALL. I FILED FOR REIMBURSEMENT AND WAS DENIED BECAUSE THE REPAIR WAS NOT FOR A CLIP,BUT FOR THE SENSOR. HOWEVER, THE SYMPTOMS ARE IDENTICAL TO THE RECALL. FURTHERMORE NO CLIP WAS REPLACED BY THE DEALER. THEY INDICATED ONLY THAT THE RECALL SITUATION WAS TAKEN CARE OF PREVIOUSLY AT THE OWNERS EXPENSE. *TR

RECEIVED A SAFETY RECALL NOTICE FROM CHEVY FOR MY 2005 CORVETTE. SAFETY RECALL 10118. GENERAL MOTORS HAS DECIDED THAT A DEFECT, WHICH RELATES TO MOTOR VEHICLE SAFETY, EXISTS IN CERTAIN 2005 CHEVROLET CORVETTES EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN. AS A RESULT GM IS CONDUCTING A SAFETY RECALL. IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR, AND ONE OR MORE OF THE BRAKES MAY APPLY , POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT. IF THE DRIVER DOES NOT RESPOND TO THE CHANGE IN VEHICLE MOVEMENT, A CRASH COULD OCCUR. CHEVROLET WILL INSPECT THE WIRE CONNECTION IN THE STEERING COLUMN, AND IF NECESSARY, INSTALL AN ADDITIONAL CLIP. *TR

CORVETTE 2005, C-6 = SERVICE ACTIVE HANDLING SYSTEM LIGHT KEEPS COMING ON, NO BODY SEEMS TO FIGURE THIS OUT WHY IT DOES IT. *TR

I WAS ON THE TRIMBLE ROAD ON RAMP IN SAN JOSE, CA MERGING ONTO FREEWAY 101 AT APPROXIMATELY 1235 PM PST AND 793 FEET FROM THE DE LA CRUZ/TRIMBLE ROAD TRAFFIC LIGHT. TRAFFIC CONDITIONS WERE LIGHT, WEATHER WAS DRY AND ROAD CONDITIONS WERE EXCELLENT. THE ON RAMP IS APPROXIMATELY AN 1/4TH OF A MILE LONG. I PULLED INTO THE COMMUTER LANE TO PASS 2 VEHICLES THAT WERE TRAVELING AT APPROXIMATELY 40-45 MPH. I PASSED THE FIRST VEHICLE AND WAS ABOUT TO PASS THE SECOND WHEN MY 2005 CORVETTE STEERED TO THE RIGHT CAUSING THE RIGHT FRONT OF MY CAR TO IMPACT A 1984 4 DOOR SEDAN TOYOTA ON THE LEFT REAR QUARTER PANEL/BUMPER, BEHIND THE LEFT REAR WHEEL. THE TOYOTA STARTED TO SLIDE RIGHT AND WHEN THE WHEELS WENT FROM ASPHALT TO DIRT CAUSED THE TOYOTA TO ROLL OVER COMING TO REST ON ITS' WHEELS IN THE MEDIAN ON THE LEFT SIDE OF THE ON RAMP. MY CAR CAME TO REST IN THE DIRT ON THE RIGHT SIDE OF THE ROAD APPROXIMATELY HALF WAY ON THE ON RAMP. THE DRIVER OF THE TOYOTA HAD A CUT ON ONE OF HER FINGERS AND WAS EXTREMELY EMOTIONAL. I WAS NOT INJURED. MY CAR IS EQUIPPED WITH ON-STAR WHICH DID NOT ACTIVATE DUE TO THE CRASH. NONE OF THE AIR BAGS DEPLOYED IN MY CAR. ON OCTOBER 4TH, 2007 I TOOK MY CAR TO COURTESY CHEVROLET IN SAN JOSE, CA; I TOLD THE SERVICE REP THAT I HAD RECEIVED 2 NOTICES IN THE DRIVER INFORMATION CENTER DISPLAY TO SERVICE THE "ACTIVE HANDLING SYSTEM SOON" AND THAT I HAD IMPACTED A CURB. THE SERVICE REP ASKED ME IF THE MESSAGE RECURRED AFTER TURNING THE CAR OFF AND BACK ON AND I TOLD THEM NO BUT IT DID DISPLAY TWO DIFFERENT TIMES ABOUT A WEEK APART. I WAS TOLD THAT TURNING THE CAR OFF AND BACK ON CLEARED THE ERROR CODE SO THERE WAS NOTHING TO WORRY ABOUT. I HAD THE CAR ALIGNED. I THOUGHT THE RIGHT FRONT A ARM BROKE CAUSING THE ACCIDENT DUE TO HITTING THE CURB IN OCTOBER UNTIL I RECEIVED RECALL NOTICE 10118. I SAVED ALL OF THE MECHANICAL PARTS REPLACED ON THE RIGHT FRONT OF MY CAR AND STILL HAVE THEM. THE STEERING SENSOR WAS REPLACED BY THE DEALER ON 1-30-08. *TR

TIRE PRESSURE SENSORS FAIL WITHOUT INDICATION. THE SENSOR REGISTERS PRESSURE WHEN IT IS ACTUALLY ZERO. WITH RUN FLAT TIRES THIS CAUSES AN UNSAFE CONDITION. *TR

2005 CHEVROLET CORVETTE HAS SERVICE ACTIVE HANDLING SYSTEM ON DIC MULTIPLE TIMES. GM HAS ISSUED TSB 06.02.35.002B TO INSERT A CLIP IN SWPS TO NO AVAIL. THIS IS A STEERING AND ABS RELATED PROBLEM AND SHOULD BE INVESTIGATED. I HAVE HEARD OF INSTANCES WHERE WHEELS CAN LOCK AT HIGH SPEED. GM SHOULD THOROUGHLY INVESTIGATE AND RECALL FOR REPAIR. *TR

OVER THE LAST YEAR MY " SERVICE ACTIVE HANDLING SYSTEM" LIGHT HAS COME ON. AFTER A WHILE IT GOES OFF. TEN DAYS AGO IT CAME ON AGAIN FOR A WHILE, THEN WENT OFF. AFTER THAT I WAS TRAVELING ON AN INTERSTATE HIGHWAY WITH THE CRUISE CONTROL ON. ALL OF A SUDDEN THE CAR SWERVED TO THE RIGHT. LIGHT CAME ON SAYING "DISENGAGE CRUISE CONTROL", WHICH I DID AND GAINED CONTROL OF THE CAR. I WAS IN THE PASSING LANE AND WAS LUCKY NO ONE WAS BESIDE ME WHEN IT SWERVED TO THE RIGHT OR I WOULD HAVE HIT THEM. I WAS ALSO LUCKY IT DIDN'T SWERVE LEFT OR I WOULD HAVE HIT THE GUARD RAIL. TOOK IT TO MY LOCAL DEALER WITH THE BULLETIN #06-02-35-002B. THEY SAID IT WAS COVERED UNDER WARRANTY. THIS NEEDS TO BE FIXED OR SOMEONE WILL GET KILLED. *TR

05 CORVETTE - SERVICE ACTIVE HANDLING MESSAGE CAME ON AFTER GOING OVER A LARGE BUMP. IT COMES ON EVERYTIME I GO OVER A SPEED BUMP OR HIT A POTHOLE THAT IS BIG ENOUGH TO JAR THE CAR. I DID HAVE THE CAR SWERVE EVER SO SLIGHTLY WHILE I WAS TRYING TO DRIVE STRAIGHT. *TR

MY 2005 CORVETTE C-6 COUPE HAS BEEN PERIODICALLY GIVING "ACTIVE HANDLING SYSTEM" WARNINGS. THE DEALER COULDN'T FIND ANY REASON FOR THE PROBLEM BUT DID REPLACE THE "COMPUTER" MODULE JUST PRIOR TO THE WARRANTY EXPIRING. THE PROBLEM SEEMED FIXED FOR A WHILE THEN STARTED AGAIN ABOUT A YEAR AGO. THE WARNING COMES ON ALMOST EVERY TIME I DRIVE THE CAR NOW. READING SOME OF THE OTHER COMPLAINTS ON THIS SUBJECT MAKES ME FEAR DRIVING THE VEHICLE. *TR