2005 CHEVROLET CORVETTE Complaints

ACTIVE HANDLING SYSTEM ON A 2005 6-SPEED CHEVY CORVETTE ACTIVATED WHILE DRIVING ~10MPH THROUGH A PARKING LOT AND MAKING A GENTLE RIGHT TURN, SEIZING FRONT LEFT CALIPER UNTIL THE CAR WAS BROUGHT TO A COMPLETE STOP. DISABLING AHS ELIMINATES ISSUE, BUT SYSTEM REACTIVATES EVERY START. HAPPENED AGAIN EXITING A HIGHWAY JUST MINUTES LATER. CAR HAS ~30K MILES, WITH NO ACCIDENTS OR PROBLEMS IN THE PAST. *TR

2005 CHEVROLET CORVETTE Z51 WITH 1SB PACKAGE. SERVICE ACTIVE HANDLING CAME ON WHILE DRIVING, CAR SWERVED AND ALMOST HIT A CURB. INTERMITTENTLY IT COMES ON AND OFF ON START UP. CAR IS OUT OF WARRANTY, AND IT IS HARD TO REPRODUCE THIS ISSUE SINCE IT IS INTERMITTENT. CURRENT INVESTIGATION NUMBER EA09-002. *TR

THE "SERVICE ACTIVE HANDLING SYSTEM" WARNING KEEPING COMING UP WHILE DRIVING THE CAR. *TR

MY CAR SUDDENLY JERKED TO THE LEFT AND THE SERVICE ACTIVE HANDLING LIGHT CAME ON. I WILL ALSO RECEIVE SERVICE ACTIVE HANDLING ERRORS EVERY ONCE IN A WHILE THAT GO AWAY AFTER RE-START. *TR

MY ACTIVE HANDLING ACTIVATES ALMOST WEEKLY AT LOWER SPEEDS WHILE TURNING, EVEN WITH THE TRACTION CONTROL OFF. THE PROBLEM IS IT LOCKS UP THE FRONT BRAKES AND I CAN NOT TURN OR MOVE THE VEHICLE!! WHILE THIS MAY NOT SOUND TOO SERIOUS AT LOW SPEEDS, IMAGINE PULLING OUT INTO TRAFFIC AND THE BRAKES LOCK UP ON YOUR CAR. IT OCCURS PULLING ONTO GRASS OR LOOSE GRAVEL ALSO, ESPECIALLY IN TURNS. I HAVE TO TURN THE CAR OFF AND RESTART IT FOR IT TO MOVE AGAIN. THE ACTIVE HANDLING LIGHT COMES ON BUT WILL GO AWAY WHEN RESTARTED. THE PROBLEM FIRST OCCURRED LAST FALL AND I FINALLY ADDRESSED IT WITH THE LOCAL GM SHOP WITH TSB 06-02-35-0002B ON 1/2/09 ($88.15 SERVICE), WHICH ADDED A CLIP TO THE SWPC CONNECTOR. IT DID NOT CORRECT THE PROBLEM LONG TERM. I DO HAVE STOCK SIZE STREET TIRES ON MY CAR ALSO. *TR

A RECALL EXISTS FOR ALL 05-07 C6 OEM CORVETTE REMOVABLE TARGA TOPS. THE GLUE BOND HOLDING THE REMOVABLE TOP TO ITS FRAME BREAKS WITH TEMPERATURE CHANGES, AND THE TOPS BREAK AWAY AND FLY OFF THE CAR. OVER TIME, AIR AT HIGHWAY SPEEDS AIR EVENTUALLY BLOWS UNDER THE TOP AND PULLS IT OFF THE FRAME. AS PART OF THE RECALL REPAIR, GM INJECTED FOAM UNDER THE THIN PLASTIC TOP INTO THE ROOF FRAME TO PREVENT THE AIR FROM ENTERING AND RIPPING THE TOP OFF. THEY DID NOT ADDRESS THE REAL PROBLEM WITH THE GLUE NOT HOLDING THE TOP ON. THEY ONLY ADDRESSED A SYMPTOM OF THE REAL PROBLEM TO AVOID THE COST OF REPLACEMENT. MY TOP HAD MONTHS OF AIR LEAKING UNDER IT, A LOT OF NOISE OVER THAT PERIOD, AND THE FOAM INJECT RECALL HAD BEEN PERFORMED WITH A PREVIOUS OWNER. GM DENIED MY SAFETY RECALL CLAIM STATING THEY INJECTED THE FOAM, BUT IN REALITY THEY ONLY TREATED A SYMPTOM. GM USED A LEGAL RUN-AROUND TO AVOID HAVING TO REPLACE THE TOP, SAYING THEY CORRECTED THE PROBLEM AND MET THE NHTSA RECALL. ALL THEY DID WAS INJECT SOME FOAM. THEY DID NOT CORRECT THE GLUE PROBLEM AND MEET THE BURDEN OF CORRECTION ACCORDING TO THE RECALL. I WAS ABLE TO GRAB ONTO THE TOP THROUGH MY DRIVERS WINDOW TO HOLD IT DOWN WHEN IT UNEXPECTEDLY STARTED TO RIP OFF, OR IT WOULD HAVE HIT TRAFFIC BEHIND ME, AND CAUSED WRECK(S). THANKS YOU FOR YOUR HELP AND CONSIDERATION IN ADDRESSING GMS RELUCTANCE TO CORRECT THEIR RECALL PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ELECTRIC STABILITY CONTROL WAS DEFECTIVE AND THE ACTIVE HANDLING ENGAGES AUTOMATICALLY AT DIFFERENT SPEEDS. WHEN MANUALLY DISENGAGED, IT WILL AUTOMATICALLY RE-ENGAGE IF IT SENSES A CRASH. WHEN A CRASH IS DETECTED, THE BRAKES LOCK AND THE STEERING TURNS. PRIOR TO THE FAILURE, A WARNING LIGHT ILLUMINATES FOR THE MANUAL ACTIVE CONTROL. THE FAILURE OCCURS AT VARIOUS SPEEDS. THE DEALER COULD NOT DUPLICATE THE FAILURE; HOWEVER, THEY REPLACED THE SENSORS AND STATED THAT MORE COULD BE DONE. NO WORK WAS PERFORMED ON THE VEHICLE PRIOR TO THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 55,000 AND CURRENT MILEAGE WAS 70,000.

ACTIVE HANDLING SYSTEM PRODUCED ERRATIC HANDLING AND NOW I JUST HAD A WARNING THAT THE ACTIVE HANDLING IS RECALIBRATING ITSELF. I DON'T TRUST THE CAR. *TR

I FILED MY FIRST COMPLAINT 8/1/08 WITH NHTSA AND NOTHING HAS CHANGED. MY NUMBER IS 10236693. MY AIR BAG WARNING LIGHT GOES OFF AND ON. I TOOK IT TO THE DEALER AND OF COURSE THE LIGHT WAS OFF. THEY SAID TO BRING IT BACK WHEN THE LIGHT IS ON. I'VE HAD THE CAR OVER FOUR YEARS AND IT'S NEVER ON LONG ENOUGH TO TAKE IT IN. HOW LONG DO I HAVE TO DRIVE IT NOT KNOWING IF I'M PROTECTED? *TR

AFTER ABOUT 2.5 YEARS THE CONVERTIBLE TOP MECHANISM STARTED GETTING NOISY AND THEN REFUSED TO CLOSE ALL THE WAY. THE DEALER REPAIRED IT UNDER WARRANTY WITH A NEW ELECTRIC MOTOR AND A PUMP REPAIR KIT. ABOUT A YEAR LATER THE EXACT SAME THING HAPPENED BUT THE DEALER REFUSED TO REPAIR IT UNDER THE ORIGINAL WARRANTY SAYING THAT IT WAS A DIFFERENT PROBLEM. THIS TIME HE REPLACED ALL THE HYDRAULIC HOSES ON THE LEFT SIDE AND CHARGED ME ABOUT $900.00. I FEEL THAT THE PROBLEM WASN'T PROPERLY REPAIRED THE FIRST TIME. *TR