2004 CHEVROLET EXPRESS Complaints

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE FUEL TANK PIPE WAS SEVERELY RUSTED AND WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 39,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. THE CONTACT STATED THAT AFTER REFUELING, FUEL SPEW BACK OUT OF THE FILLER NECK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: FILLER PIPE AND CAP). THE FAILURE AND CURRENT MILEAGE WAS 114,000. UPDATED 10/16/12*LJ THE CONSUMER STATED THE FUEL FILLER NECK CORRODED UPDATED 10/19/2012 *JS

GASOLINE AND GASOLINE VAPOR WAS ESCAPING FROM THE FUEL FILLER PIPE LEADING TO THE FUEL TANK ON A 2004 CHEVY EXPRESS VAN 3500 SERIES. THE FILER PIPE WAS RUSTED THROUGH. THERE WAS A SEAM ON THE PIPE WHERE THE RUST THROUGH OCCURRED. GASOLINE WAS DRIPPING FROM THIS HOLE DURING GASOLINE FILL UP AND VAPORS WERE ENTERING THE PASSENGER COMPARTMENT. WE HAD IT REPLACED BY A CERTIFIED MECHANIC BECAUSE IT WAS A POTENTIALLY EXPLOSIVE SITUATION, ACCORDING TO THE MECHANIC. THIS WAS REPORTED TO GM. THERE WAS NO RECALL ON THIS PART, SO GM REFUSED TO PAY FOR THE COST OF THE REPLACEMENT PART AND LABOR. THE REPLACEMENT PART IS NOW PLASTIC. SO GM MUST HAVE RECOGNIZED THE PROBLEM (BUT FAILED TO RECALL) AND CHANGED THE PIPE TO A RUST-PROOF MATERIAL. *JS

VEHICLE HAS CONTINUED TO EVIDENCE PROBLEMS SIMILAR TO WHAT'S DESCRIBED BY NHTSA CAMPAIGN ID NO. 04V452000. POWER STEERING PUMP AND BELTS HAVE BEEN REPLACED AND GM DEALER PERFORMED HYDRO BOOST INSPECTION TEST AND IT PASSED; SAID NO FURTHER ACTION REQUIRED. BUS HAS AGAIN LOST POWER STEERING AND BRAKES TO CAUSE A DANGEROUS CONDITION. DEALER SAYS IT IS NOT A VEHICLE THAT RECALL APPLIES TO. *JS

DANGEROUS AS GAS TANK RUSTED THROUGH ON TOP AND LEFT SIDE AFTER ONLY ROUGLY 100,000 MILES. *TR

AS I ATTEMPTED TO SPEED UP IN TRAFFIC, I HEARD A NOISE AND THE VEHICLE SUDDENLY SLOWED DOWN. I WAS ABLE TO GET IT OFF THE HIGHWAY ON TO A SIDE ROAD. ONCE THERE, IT WOULD NOT START. ON CLOSER INSPECTION, I SAW THAT THE BELT HAD COME APART AND OFF THE PULLEY'S. I HAD THE VAN TOWED TO MY HOME AND SUBSEQUENTLY, FIXED/REPLACED THE BELT. SINCE THAT TIME, I BEGAN TO HEAR A LOW KNOCKING, MORE SO WHEN I TURNED ON THE AIR CONDITIONING. WHEN IT BECAME LOUDER ON ALL GEARS AND WHILE PARKED, I TOOK IT TO HOLLER DRIVERS MART, IN WINTER PARK, FL. ON 01/19/2012, I WAS TOLD THAT THE FLYWHEEL HAD SHEARED AROUND THE AREA WHERE IT WAS BOLTED ONTO THE TRANSMISSION AND CONNECTED TO THE ENGINE. IT ALSO HAD FRACTURES IN AND AROUND THE SAME AREA OF THE SHEARING. TECH INFORMED ME THAT I HAD CAUGHT THE PROBLEM BEFORE A SERIOUS INCIDENT MAY HAVE OCCURRED. I HAVE THE FLY WHEEL AND WILL SEND PHOTOS. CONSUMER SENT IN PHOTOS. 02/07/12 UPDATED 02/07/12 *BF STATUS UPDATE 02/23/12

WHILE TRAVELING DOWN A STEEP GRADE WHILE APPLYING THE BRAKES, A SEVERE SHAKING OF THE STEERING WHEEL AND WHEELS OCCURRED. IT WAS SO SEVERE THE STEERING WHEEL SHOOK OUT OF MY HANDS. ONCE BACK ON LEVEL GRADE FOR A MILE OR SO, APPLYING THE BRAKES DIDN'T RESULT IN THE SEVERE SHAKING. FROM THAT POINT ON WHILE DRIVING ON ANY STEEP HILL OR MOUNTAIN, THE SAME THING OCCURS. THE BRAKE PADS AND ROTORS WERE REPLACED LAST YEAR, BUT THAT HAS NOT FIXED THE ISSUE.

WE PURCHASED A COMPLETE SET OF GENERAL GRABBER HTS 235/75R16 FOR OUR CHEVY EXPRESS VAN AT DUNN TIRE ON 11/15/08. THEY WERE SUPPOSED TO HAVE A 60K WARRANTY. WE WENT IN FOR THE REQUIRED ROTATIONS AND NOTED THAT THE TREAD DIDN'T SEEM TO BE WEARING WELL. AT THE 20K MILE ROTATION IN JANUARY OF 2011, DUNN TIRE ACKNOWLEDGED THAT THE TIRES WERE NOT PERFORMING AS ADVERTISED AND TOLD US THAT THEY WOULD LIKELY NEED TO ADJUST THE TIRES ON A PRO-RATA BASIS AT THE NEXT ROTATION AT 25K MILES. IT IS OUR BELIEF THAT THE TIRES ARE DEFECTIVE IN SOME WAY. THE ORIGINAL TIRES ON OUR VAN LIVED UP TO THEIR 40K WARRANTY AND WE REPLACED WITH THESE GRABBER HTS TIRES AT 39747 MILES. OUR DRIVING HABITS ARE CONSERVATIVE AND WE HAVE NEVER HAD TO REPLACE TIRES AHEAD OF THE WARRANTY PERIOD. THE TREAD WAS SO BAD ON THESE GRABBER HTS TIRES THAT WE WERE UNABLE TO DRIVE OUR VAN ON SNOWY ROADS DURING THIS PAST WINTER. WE ALSO WERE CONCERNED ABOUT HYDROPLANING ON THE EXPRESSWAY WHEN WE DROVE THE VAN THROUGH HEAVY RAINS THIS PAST WEEKEND WHEN WE DROPPED OFF OUR DAUGHTER AT COLLEGE. WE BELIEVE THESE TIRES ARE HAZARDOUS AND THAT AN INVESTIGATION SHOULD BE INITIATED. IT'S INCONCEIVABLE THAT WE WOULD ONLY GET 25K MILES OUT OF A 60K TIRES. WE FEEL CHEATED AND REALLY DO NOT WANT ANOTHER SET OF GENERAL TIRES ON A PRO-RATA BASIS. *TR

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYWHEEL WAS REPLACED AT 103K (3K OUTSIDE OF EXTENDED WARRANTY). 2ND FLYWHEEL REPLACED AT 143K. VAN IS KEPT IN MINT CONDITION, OIL CHANGED EVERY 3K W/O FAIL. VEHICLE SEEMS TO BE IN OTHERWISE TERRIFIC CONDITION. 1ST AND ONLY OWNER. DATE REFERRED TO IS DATE OF 2ND FLYWHEEL CRACK. *TR

REPEATED CRACKED FLYWHEEL. ORIGINAL CRACKED JUST OVER 100K MILES. REPLACEMENT NOW CRACKED 40K MILES LATER. *TR