2005 CHEVROLET EXPRESS Complaints

TL* THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 1500. THE CONTACT WAS TRAVELING 25 MPH WHEN THE BRAKES WERE APPLIED AND THEY WOULD NOT RESPOND. THE CONTACT WAS FORCED THROUGH A RED TRAFFIC LIGHT AND ATTEMPTED TO SHIFT INTO A LOWER GEAR. THE VEHICLE DID NOT STOP UNTIL DRIVING OVER A CURVE AND COMING TO A STOP. THE VEHICLE WAS INSPECTED BY A MECHANIC WHERE IT WAS DISCOVERED THAT ONE OF THE HOSES OF THE MASTER CYLINDER FAILED. THE MECHANIC ADVISED THAT THERE WERE TWO HOSES THAT WERE RUNNING TOGETHER ABNORMALLY AND THE FRICTION CAUSED THE HOSE TO COLLAPSE. THE FAILURE AND CURRENT MILEAGE WAS 53,000.

I OWN A 2005 CHEVROLET EXPRESS 1500 V6 AND WHILE DRIVING TO MY HOUSE FROM WORK I LOST ALL BRAKES DUE TO A BRAKE LINE FAILURE, THE TWO HYDRAULIC BRAKE HOSES THAT ARE ATTACHED TO THE MASTER CYLINDER ARE IN CONTACT WITH ANOTHER METALLIC BRAKE HOSE UNDER THEM, BY RUBBING TOGETHER FOR FOUR YEARS CAUSED THE HOSES TO WEAR AND RUPTURE AND NEARLY CAUSED A CRASH. *TR

2005 CHEVY EXPRESS VAN CAUGHT FIRE IN THE ENGINE COMPARTMENT, COMPLETE BURN. *TR

THIS IS A 29' MOTORHOME, WHEN TOWING IN HILLS/MOUNTAINS. GOING DOWN HILL ATTEMPTING TO SLOW DOWN THE VEHICLE, THE MOTORHOME STARTS SHAKING THROUGHOUT AND THE BRAKES BECOME ALMOST INEFFECTIVE. THE DEALERSHIP SERVICE DEPT INFORMED ME THE BRAKES ARE BARELY ADEQUATE TO STOP THE MOTORHOME WITHOUT A TRAILER. THE CHEVORLET G3500 HAS A TOWING RATINGS PER THE CHARTS OF 10000#. I WAS TOWING LESS THAN 5000#. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 2500 VAN. THE CONTACT STATED THAT THE PASSENGERS SIDE CLAM SHELL DOOR HINGES WERE DEFECTIVE AND WERE DIFFICULT TO OPEN. INTERMITTENTLY, THE DOOR WOULD BECOME STUCK. THE DEALER WAS CONTACTED AND ADVISED ALTHOUGH THERE WAS A RECALL FOR THE FAILURE, THE CONTACTS VIN WAS NOT INCLUDED IN THE RECALL (NHTSA CAMPAIGN ID NUMBER 09V307000: EQUIPMENT ADAPTIVE).THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 26,000.

OUR 2005 CHEVY EXPRESS 1 TON PASSENGER VAN BRAKES BY ITS SELF. IT HAS BEEN HAPPENING SINCE JULY 2009. WE TOOK IT TO A LOCAL MECHANIC AND HE REPLACED YAW SENSOR IT DID NOT STOP THE BRAKING. WE TOOK IT TO WHITE'S CHEVROLET DEALERSHIP IN CASPER WY AND THEY REPLACED F- MODULE IT DID NOTHING TO CHANGE THE PROBLEM. THE RIGHT FRONT BRAKE WOULD BRAKE AND THE THE TRACTION SYSTEM WILL KICK IN. WE TOOK IT BACK TO THE CHEVY DEALER AND THEY SAID THEY WOULD FIX IT. THE PERSON WE WERE DEALING WITH, BRIAN PARKS, CALLED AT ONE POINT AND SAID WE HAD A GHOST IN THE VAN. THEY HAD THE VAN FOR A LITTLE OVER A MONTH AND SAID THE TIRES WERE SLIGHTLY UNEVEN AND THAT MIGHT BE WHAT WAS CAUSING THE BRAKES TO ENGAGE BY THEMSELVES. THEY TOLD US THEY WOULD NO LONGER WORK ON IT AND TO COME AND GET IT. WE PICKED IT UP AND NOW THE LEFT FRONT BRAKE ENGAGES BY ITSELF SO HARD AT TIMES IT PULLS THE VAN TO THE LEFT. WE DON'T KNOW WHAT TO DO TO GET THIS PROBLEM SOLVED. THE VAN IS NOT SAFE ON ICEY ROADS OR DRY FOR THAT MATTER. WHEN THE BRAKE STARTS ENGAGING THE TRACTION CONTROL COMES ON AND THE BRAKE WILL NO LONGER ENGAGE.

TL* THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 1500. WHILE DRIVING 65 MPH THE VEHICLE BEGAN TO VIBRATE. NEXT THE ABS LIGHT HAD ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE TRANSFER CASE WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 28000. UPDATED 01/05/10. *LJ THE CONSUMER STATED THE VEHICLE BROKE DOWN 20 MINUTES AWAY FROM HOME. THE BRAKES LOCKED UP AND THE VEHICLE MADE A LOUD NOISE. THE CONSUMER WAS INFORMED THE SEAL FAILED ON THE TRANSFER CASE WHICH CAUSED ALL THE FLUIDS TO INTO THE TRANSMISSION. UPDATED 01/05/10. *JB

TL*THE CONTACT OWNS A 2005 CHEVROLET EXPRESS CUT-AWAY G3500. WHEN THE CONTACT DEPRESSED THE BRAKE PEDAL AT 10 MPH, THE VEHICLE BECAME DIFFICULT TO STOP. UPON FURTHER INSPECTION, HE NOTICED BRAKE FLUID LEAKING FROM THE HOSES. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE BRAKE LINES WERE RUBBING TOGETHER, WHICH CAUSED THE HOSE TO RUPTURE. THE CONTACT IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,000.

1) TOTAL BRAKE FAILURE WHILE DRIVING 2) BOTH BRAKE LINES RUPTURED AT FLEXIBLE SECTION BELOW MASTER CYLINDER. 3) REPLACED ALL BRAKE LINES, REFILLED SYSTEM AND BLED SYSTEM. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE RELEASE BUTTON ON THE PASSENGER SIDE SEAT BELT FAILED. AS A RESULT, THE PASSENGER WAS TRAPPED IN THE SEAT BELT FOR THIRTY MINUTES. SHE HAD TO REMOVE A SCREW FROM THE SEAT IN ORDER TO LIFT THE SEAT BELT OVER HER HEAD. CURRENTLY, THE RELEASE BUTTON FOR THE BUCKLE HAS STILL NOT RELEASED. THE MANUFACTURER SENT A SPECIALIST, WHO STATED THAT THEY WOULD NOT ASSIST IN THE REPAIR; HOWEVER, THERE WAS A PRIOR RECALL FOR THIS FAILURE THAT HAD BEEN PREVIOUSLY REPAIRED. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE BUCKLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 165,000.