2009 CHEVROLET HHR Complaints

The contact owns a 2009 Chevrolet HHR. The contact stated while starting the vehicle, the rear of the vehicle started burning. The contact was able to stop the fire and the contact noticed that the gasoline was leaking onto the ground under the vehicle. No one was injured and no police report was filed. The vehicle was diagnosed by an independent mechanic and the mechanic stated that the fitting to the gasoline trunk was damaged causing the gasoline to leak. The vehicle was repaired. The manufacturer was contacted, and the manufacturer did not provide any assistance. The failure mileage was 28,000

The contact owns a 2009 Chevrolet HHR. The contact stated that while driving at an undisclosed speed, the Service Air Bag message was displayed. The dealer was made aware of the failure and informed the contact that she needed to pay out of pocket for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to take the vehicle to the dealer to be serviced. The failure mileage was approximately 145,000.

The contact owns a 2009 Chevrolet HHR. The contact stated while the vehicle was parked, he noticed fuel leaking from the rear driver's side of the vehicle. The vehicle was not taken to a dealer or independent mechanic for diagnosis or repairs. A Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. The contact stated that he was able to look under the vehicle and found that the fuel line was corroded. The contact was relating the failure to an unknown recall for a fuel line that was issued for similar Chevrolet HHR vehicle. The manufacturer was not notified of the failure. The approximate failure mileage was 52,000.

Heavily leaking fuel line. Read over 600,00 vehicles affected by this! Why the heck has there not been a recall?!!

The contact owns a 2009 Chevrolet HHR. The contact stated upon parking and exiting the vehicle, she smelled a strong gasoline odor on the driver's side of the vehicle. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the fuel line needed to be replaced. However, the parts were not available. The vehicle was not repaired. The contact referenced NHTSA Action Number: PE20011. The manufacturer was not notified of the failure. The failure mileage was approximately 111,800.

Fuel Smell / Leak. Car developed a gas smell while driving and after getting out of the car a small amount of gas poured out in front of the passenger door on the drivers side. I was told my gas line has rusted through and will need to be replaced.

When driving my 2009 HHR the steering wheel shakes & vibrate at different intervals. Usually while slowing down to a stop & sometimes after during high speeds. Recently the noise it made was frightening. I had to use my emergency flashers & drive 50 mi per hr. on the freeway to arrive home safely. I took my car to Mark Chevrolet & reported it on 08/02/2021. The car's mileage was 133344. The car is not an everyday vehicle that is driven often. I received the car on 08/17/2021 after the steering column & shaft were replaced along with resurfacing front brake rotors & rear brake job. On August 18, 2021 while driving on the freeway I went to blow my horn at a hazardous situation & discovered none of the steering wheels controls were working, horn & etc. I immediately returned my car to Mark Chevrolet & reported their negligence & how they had risk my life to release the car without these functions working. They supposedly corrected the problem. On 07/05/2022 I had to return my car to Mark Chevrolet because I was experiencing the identical problem with my steering wheel vibrating & make noise. My cars mileage was only 137641 less than a year later with just 4,297 miles driven. They claimed to have tightened something up in the column & returned my car on 07/12/2022. As I was driving on 07/16/2022 again the steering wheel started vibrating & making strange loud noises. I felt so unsafe & tried to make it home safely driving at a reduced speed. I plan to return the car this week back to Mark Chevrolet and am asking for support to rectify this situation. I understand there was a recall on Chevrolet HHR 2009 Steering Electric Power Assist System. I don't know if this issue is related to that. I never received communication from General Motors stating that my vehicle was affected but apparently there is a problem. Please Help!

The contact owns a 2009 Chevrolet HHR. The contact stated while driving approximately 40 MPH at night, the low-beam headlights became inoperable. There were no warning lights illuminated. The contact took the vehicle to the local mechanic which replaced the headlight bulbs; however, the failure recurred several times. The manufacturer was not notified of the failure. The approximate failure mileage was 172,087

Leaking fuel lines in front of drivers side rear tire. Fuel lines appear to be rusted. Fuel lines are routed very near exaust pipe.

Something with steering and ESC problem unknown for now. The fuel line leaked and needed replacement. The drivers wiper is in visibility