2009 CHEVROLET HHR Complaints

The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, there was an abnormal clicking sound coming from the vehicle. In addition, the contact stated that the passenger’s side air bag warning light illuminated and occasionally flashed on and off. The vehicle was taken to the dealer but was not diagnosed or repaired due to the cost. The contact had previously received notification of NHTSA Campaign Number: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) and the vehicle was repaired; however, the failure persisted. The manufacturer was not made aware of the failure. The failure mileage was approximately 199,000.

The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to NHTSA Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.

last week we noticed gasoline showing up on the ground in front of the rear driver side tire. I looked underneath and found a pipe that seems to be corroded. I looked online and found that many people have the same problem, so I haven't had it checked at a dealership. The pipe continues to leak after you walk away and I'm afraid someone will discard a cigarette near the vehicle, or worse. We are generally home, and can be reached for inspection.

The contact owns a 2009 Chevrolet HHR. The contact stated that while the vehicle was parked, and while driving the vehicle, there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that the vehicle was experiencing excessive fuel consumption. The contact also noticed that fuel had leaked onto the ground. The contact stated that upon inspecting the vehicle, the contact noticed that fuel was leaking from the driver's side rear wheel well, where the fuel tank was located. The contact related the failure NHTSA Action Number: PE20011(Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.

I was driving and I went to roll the sunroof down and it ejected itself and came off the whole glass and frame and broke in many pieces on the bridge if there would of been a car or person walking it would of hit them and caused a major accident its going to cosy over$2000.00 to get it replaced whicj I cant afford to do I feel like the manufacturer should replace the part it wasnt my fault

The gear shift gets stuck when it gets cold outside and does not won't to go in reverse or diver. It takes a little bit when the car has to set and warm up before it will work.

I was backing my car out of the garage and I noticed a line of liquid on the ground, indicating a leak. I immediately stopped the car, got out and took a look. I traced the leak back to the drivers side at the rear, just before the tire. I could see fuel dripping down from under the car. The exhaust pipe right near the dripping was also wet. I could smell gas and I confirmed that was what was dripping by smelling a drop after I let it fall on my finger. Definitely gasoline. After the dripping stopped, I pushed the car back into the garage. I used a QuickJack to raise the car to get a better look at the area where the leak was coming from. There was massive corrosion/rust of the metal lines in the area. The leak was easily found by just looking for where the lines were wet. Even though fuel was no longer dripping (the engine was off so there was no fuel pressure anymore), there was still wetness from the gas leaking through the rusted area. I will not drive the car again until the leak has been repaired. Considering the fact that the exhaust pipe had also gotten wet from the leak, the chance of a fire was VERY LIKELY. I consider myself very lucky to have found the leak when I did, rather than have a fire occur while driving. Even if I were to pull over and shut the engine off immediately, a significant amount of fuel would leak out and feed the fire as the fuel escapes under pressure. This certainly could cause the rest of the car to catch fire. This is clearly unsafe and dangerous. If the leak occurred after the car was put in the garage with the exhaust still hot, a fire could not only consume the vehicle but the garage and the house as well. That could cause injury or even death in a worst case scenario. This is clearly an unsafe design and a clear risk to both people and property. This absolutely should be the basis for a recall where the corroded lines are replaced free with new lines made of a more durable material such as stainless steel.

The contact owns a 2009 Chevrolet HHR. The contact while driving at an undisclosed speed, noticed a strong fuel odor. The contact stated that upon parking and exiting the vehicle, there was fire underneath the rear driver's side, where the fuel tank was located. The contact was able to extinguish the fire with a fire extinguisher. There was no injury sustained. The contact then noticed a trail of fuel on the floor. The contact became aware that fuel had leaked while driving. The vehicle was towed to an independent mechanic, where it was diagnosed that the fuel line was corroded and needed to be replaced due to a wrong design. The contact stated that the fuel line was designed over the muffler, which caused water intrusion and corrosion. The vehicle was then towed to the dealer, where the fuel line was replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 28,000.

The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, the power steering warning light, the ESC service, the ESC off, and the traction control warning lights illuminated, followed by the loss of power steering functionality. The vehicle was taken to the dealer and the dealer stated that the power steering assist motor and the power steering assist module needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer stated that the VIN was not included in a recall or TSB. The failure mileage was 185,000.

Fuel line has rusted and is leaking gas under the left rear wheel, near the tail pipe. First noticed by smell while driving, then witnessed gas leaking upon exiting the vehicle at home. Have not had vehicle serviced as I will have to have it towed due to safety concerns. Please continue the investigation into this issue as it is potentially life threatening and the number of complaints are concerning. The vehicle is available for inspection.