2008 CHEVROLET HHR Complaints

The contact owns a 2008 Chevrolet HHR. The contact stated that her father noticed that the vehicle was leaking fuel. Upon inspection, the contact became aware that the fuel lines had rusted and had started leaking. The vehicle was not taken to a dealer to be inspected. The manufacturer was not informed of the failure. The failure mileage was 141,802. Consumer stated mechanic had to take off the fiberglass mat heat barrier because it was soaked in fuel, and was rubbing the exhaust, so we could see the damage.

The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked, she noticed there was a puddle on the ground located on the rear driver's side. Upon inspection, the contact detected a fuel odor and noticed there was a fuel leak coming from the fuel lines. The dealer was made aware of the failure and scheduled an upcoming appointment for diagnosis. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other). The failure mileage was approximately 113,000.

My Fuel line is pouring gas out . The gas fumes are filling the cabin of the car waiting for a repair.

Around 6 months ago I started to notice a fuel smell and upon inspection at the local shop it was diagnosed that my fuel line had rusted through and they informed me there are other cases of this exact issue on the Chevrolet hhr and cobalt vehicles with this engine and fuel setup it has started to leak into the exhaust but has not caught fire.

I noticed a strong odor of gasoline and took the HHR to my local mechanic. He diagnosed it as a rusted fuel line caused by the proximity of a heat shield that traps water.. He was able to repir it by splicing in a section of the line. A bout a yer later the line was leaking again and this time there is not enough line left to splice that isn;t rusted. Obviously this is a danger ranging from leaking gasoline hitting a hot exhaust to a passerby discarding a lit cigarette near the leak and blowing themselves and my car to Kingdome Come. A Check engine light comes on periodically, but is only partially indicative of the gas leak as a possibility. This is a safety issue for both the owner and anyone who might happen by with a lit object

Fuel lines leaking in front of drivers side rear tire. Lines run inside of a channel that has a protective wrap over them, but is very close to part of the exhaust pipe. Fuel line had corroded inside of protective wrap. Only leaks when the engine is running and fuel system under pressure. Fuel could have hit hot exhaust pipe and caused a fire or explosion. Apparently this is a common problem with the Chevy HHR with multiple cases having already been reported. Had the car repair at our local Chevy dealer. Cost of removing and replacing the fuel lines was $1,307.00. The only indications of the problem was the smell of fuel near the rear tire and a puddle of fuel under the car when engine was shut off. Frame cross member was also wet from fuel shooting out of end of protective wrap.

While driving down the interstate the power steering light flashed and locked the power steering to the point I was unable to steer in any direction. It has done this on multiple occasions to the point it has almost caused several accidents. This is a serious issue!

Power steering went out completely causing me to swerve on the highway to side of road. The steering locked up and it was raining and I would of crashed had anyone else been on the highway. I was going about 55 mph at the time. I then proceeded to CAREFULLY at about 30 mph force my car to drive another half mile to nearest exit ramp. The entire time I was driving in the middle of the lanes and a huge liability as far as safety is concerned. Thankfully I made it with no harm to myself vehicle or anyone else. I pulled over to side of road and slept in car till the rain stopped. Prior to this I backed into a fence when the steering failed backing into a carport resulting in body damage to front end under left headlight. Months before I had asked the Chevy dealership to diagnose issue and they found nothing wrong as in the beginning the car would still steer at its own leisure. The light didn't come on when they looked at it. After the night in the rain I have taken the fuse outta the power steering part and just manually steer. This should be replaced as it is a common issue to ALL HHR. Mine isn't covered as it is an SS but clearly it should be covered by a recall. Hopefully I don't die before this is taken care of.

Fuel lines leaking under left rear of 2008 HHR. According to Google internet investigations this seems to be a problem in the design and placement of insulation material over the fuel line. I almost had a explosive concern, not knowing where the smell of fuel was coming from, a alert gentleman smoking a cigarette counseled me on a dripping fuel on the parking lot. He said smokers will throw their cigarette down and unintentionally possibly causing a fire/explosion.

The contact owns a 2008 Chevrolet HHR. The contact stated while driving 30 mph, he started to smell gasoline fumes inside the vehicle. The contact stated that there was no warning light illuminated. The contact stated after parking his vehicle, a bystander informed him that the vehicle had a fuel leak. The contact took the vehicle to the local dealer to be diagnosed. The contact was informed that the fuel line needed to be replaced. The vehicle was not yet repaired but was pending repairs. The manufacturer had not been informed of the failure. The failure mileage was approximately 147,240.