2008 CHEVROLET HHR Complaints

Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600

The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.

The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.

The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.

The contact owns a 2008 Chevrolet HHR. The contact stated while warming up the vehicle, the rear window exploded without warning or impact. There was smoke coming from the front of the vehicle. There was an abnormal burning odor detected. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000. The VIN was not available.

vehicle ecm keeps reporting an error code p2138 that refers to a correlation issue between sensors on the throttle/pedal system, causing the vehicle to enter into reduced power and eventually disables engine. Problem persists even after replacing pedal component. Apparently water enters the compartment where the part is located and corrodes wiring between the ecm and the pedal system. GM is apparently aware but so far has done nothing. Problem is especially hazardous because engine power is reduced during acceleration and happens without warning. Vehicle could be in high density traffic and then suddenly experiences lack of power or total disability, and driver must try to navigate to the side of the road--not always possible or safe to do.

The contact owns a 2008 Chevrolet HHR. The contact stated that on one occasion after her friend parked the vehicle, the contact observed condensation underneath the rear of the vehicle. The vehicle was inspected by the friend's nephew, and it was determined that the fuel line had a hole and was leaking fuel. The vehicle was then taken to a dealer where it was diagnosed and determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2008 Chevrolet HHR. The contact stated that while parking the vehicle, the contact detected an abnormally strong fuel odor. Upon inspection, the contact noticed a leak coming from underneath the rear driver's side door. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The failure mileage was 184,025.

The contact owns a 2008 Chevrolet HHR. The contact stated that after starting the vehicle, the contact became aware of a fuel leak nearby the rear driver’s side wheel. There were no warning lights illuminated. The contact towed the vehicle to an independent mechanic who diagnosed that the fuel line had completely rusted due to being wrapped in heat-reliant tape. The contact was informed that the fuel lines needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and was informed that there was a recall related to the rust failure of the fuel line of another make and model vehicle however, the VIN was not included. The approximate failure mileage was 199,000.

FUEL LINE LEAKING IN TWO PLACES, IN THE REAR AND IN THE FRONT. COMPLETELY RUSTED OUT. MY CAR ONLY HAS 60,800 MILES ON IT. TYPE OF CAR IS A 2008 CHEVY HHR LT 2.4. GAS IS LEAKING ON THE GROUND AND A STRONG SMELL OF GAS IS EMITTED FROM THE CAR. THIS IS VERY DANGEROUS BECAUSE THE CAR COULD CATCH FIRE. I DID NOT THINK THIS WOULD HAPPEN TO MY CAR WITH SO FEW MILES ON THE CAR. I DID NOT KNOW THERE WAS A PROBLEM AND DROVE THE CAR 130 MILES AWAY FROM HOME TO MY DAD'S FUNERAL. THEN I HAD TO DRIVE IT BACK BECAUSE TH E TOW WOULD HAVE BEEN $700. THE MECHANIC WHO INSPECTED THE CAR. BUDDY LLOYD'S LAKEVIEW AUTOMOTIVE AT 4757 SANG RUN ROAD IN MCENRY, MD 21541, SAID IT WOULD COST ABOUT $2,000 TO FIX BECAUSE OF THE EXTENT OF THE CORROSION AND THE CHAEP MATERIALS USED. IN ADDITION, THE FUEL LINES ARE LOCATED UNDERNEATH OTHER MAJOR PARTS AND WOULD HAVE TO BE TAKEN OFF TO GET TO THE FUEL LINES. THE MECHANIC SAID AT ANY MOMENT IF I HIT A BUMP THAT THE GAS COULD EMPTY THE TANK AND POSSIBLY CATCH FIRE!