2008 CHEVROLET HHR Complaints

THIS VEHICLE RECENTLY DEVELOPED A VISIBLE FUEL LEAK TOWARD THE REAR OF THE CAR. WHEN THE VEHICLE IS RUNNING OR THE FUEL SYSTEM IS PRESSURIZED FUEL LEAKS UNDERNEATH CAR DUE TO DEFECTIVE FUEL LINES. THE LOCATION OF THE LEAK IS NEAR THE EXHAUST PIPE WHICH CAN BE A FIRE HAZARD AND CAN CAUSE PERFORMANCE ISSUES WITH THE VEHICLE. NEVER HAD THIS ISSUE ON ANY OTHER VEHICLES OF THIS AGE OR NEWER. FURTHER INVESTIGATION SHOWS THAT THIS ENOUGH OF A PROBLEM THAT THERE IS A LOT OF INFORMATION AND VIDEOS SHOWING THAT IS A DESIGN/MATERIAL FLAW ON GENERAL MOTOR'S PART.

STORED CAR IN GARAGE FROM OCTOBER 2020 TO MARCH 1 2021. WHEN PARKED THERE WAS A FUEL LEAK OF 3-5 DRIPS PER SECOND AT LH REAR WHEEL. WHEN STARTED AND MOVED OUT OF GARAGE ON MARCH 1 THERE WAS A STEADY STREAM OF FUEL. THE ENCLOSED PICTURE SHOWS PUDDLE OF FUEL UNDER CAR AFTER KEYING-OFF AFTER THE 40 FOOT MOVE. PRIOR TO GARAGING THE CAR I CONTACTED CHEVROLET ABOUT THE "VERY COMMON" LEAK AND WAS TOLD TO CALL MY LOCAL DEALER, ALL TO NO AVAIL. I'VE BEEN WAITING TO HEAR IF THE JULY 2020 NHTSA INVESTIGATION WILL TURN INTO A RECALL. WHEN WILL A RULING BE AVAILABLE? I'M AT THE POINT WHERE I WILL BE DOING A SHADE-TREE-MECHANIC REPAIR IN LIEU OF WAITING ON NHTSA. GM (CHEVROLET) HAVE BEEN BUILDING CARS FOR 100 YEARS. THE COMPANY KNOWS MANY VEHICLES ARE DRIVEN IN RUST BELT STATES. THERE IS NO EXCUSE FOR FITTING CHEAP UN-COATED MILD STEEL FUEL AND PURGE LINES TO VEHICLES THAT OPERATE IN THIS ENVIRONMENT. NOTE THAT THIS VEHICLE CURRENTLY HAS A CHECK ENGINE LIGHT ON. THE CODE IS FOR A PURGE SYSTEM LEAK. I HAVE FOUND THAT THE PURGE LINE RUNNING PARALLEL TO THE FUEL LINE IS JUST AS CORRODED AS THE FUEL LINE. THIS IS LIKELY WHERE THE PURGE SYSTEM LEAK RESIDED. SO THIS VEHICLE FAILS TO KEEP LIQUID FUEL IN IT'S FUEL LINE AND FAILS TO KEEP EVAPORATIVE FUEL IN THE PURGE SYSTEM. PLEASE LET ME KNOW WHEN THE RECALL WILL BE ENACTED SO I CAN STOP NEEDLESSLY POLLUTING THE EARTH WITH HYDROCARBONS. I'D RATHER HAVE CHEVROLET FOOT THE BILL FOR THE REPAIR RATHER THAN ME. THANK YOU!

I TOOK MY HHR IN ON 10/04/2019 FOR BASIC WORK, AND WAS INFORMED ON THE LEAK IN MY FUEL LINE. I DIDN'T HAVE IT FIXED AT THAT TIME DUE TO HIGH PRICE. I SAW THE NEW REPORT FROM THE DETROIT FREE PRESS ON 7/7/2020 ABOUT THE NHTSA INVESTIGATING COMPLAINTS OF FUEL LEAKS IN OLDER CHEVROLET HHR. I BELIEVE MY HHR FALLS UNDER THIS. I WAS QUOTED ROUGHLY $800-$1000 TO HAVE THE LINE REPLACED. I FEEL THIS IS SOMETHING CHEVY SHOULD RECALL AND PAY TO HAVE FIXED AS A LEAKING FUEL LINE IS VERY DANGEROUS. I ALSO THINK THIS LEAK HAS AFFECTED MY LEFT REAR TIRE SENSOR SINCE IT IS NEAR THE ROOT OF THE LEAK AND WOULD STOP AFTER 15-30 MINUTES.

FUEL LINE LEAK ABOVE EXHAUST DRIVERS SIDE REAR TIRE. WAS PARKED IN GARAGE COULD SMELL GAS IN HOME. MOVE TO OUT SIDE LEFT LARGE PUDDLE IN GARAGE. BROUGHT TO DEALER NEXT DAY WAS TOLD FUEL LINES NEEDED TO BE REPLACED. THEY REPLACED PURGE AND FUEL FEED LINES. AT A DISCOUNTED PRICE OF $1517.36

VEHICLE LEAKS GAS, THE FUEL LINE LEAKES, BELOW THE DRIVER SIDE REAR DOOR. I'VE OWNED TWO HHR'S AND BOTH HAVE HAD THIS PROBLEM, SAME EXACT SPOT. THE LINE ROTTED OUT AND IS LEAKING FUEL ON THE GROUND. I CAN SEE AND SMELL IT.

IF MY BATTERY RUNS DOWN THE TPMS SYSTEM LOSES PROGRAMMING AND HAS TO BE TAKEN TO A DEALER TO BE REFLASHED COSTING OVER $100. IF SOMEONE DRIVING THE CAR DOES NOT NOTICE A LOW TIRE IT COULD LEAD TO AN ACCIDENT.

SEVERE FUEL LEAK WHICH CAUSED A SMALL FIRE. LUCKILY WE HAD A FIRE EXTINGUISHER HANDY. THIS IS APPARENTLY VERY COMMON WITH HHRS AND THANK GOD I WASN'T AT A GAS STATION WHEN THE FIRE STARTED.

UPON RETURN HOME I DETECTED THE SMELL OF GASOLINE FROM DRIVER'S SIDE REAR WHEEL AREA. JACKED VEHICLE UP FOR VISUAL INSPECTION, WHICH REVEALED RUSTED FUEL LINE AND EVAP LINE FROM MIDPOINT OF VEHICLE TO REAR CONNECTION TERMINALS. BOTH FUEL LINES BEHIND SILVER PROTECTIVE WRAP WERE RUSTED THROUGH IN BOTH WRAP LOCATIONS ALTHOUGH THE BRAKE LINES IN SAME WRAP WERE NOT AFFECTED.

I WENT TO START THE CAR IN MY DRIVEWAY, SMELLED GAS FROM THE REAR DRIVER'S SIDE TIRE. I THEN SHUT OFF MY CAR AND LOOKED. I HAVE A LEAK IN THE FUEL LINE, AFTER RESEARCHING SEEMS THAT THIS HAS HAPPENED BEFORE IN THIS MAKE AND MODEL. I DO NOT WANT TO MOVE THE CAR OR PAY FOR A REPAIR THAT IS A DESIGN FLAW.

TL* THE CONTACT OWNS A 2008 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL FUEL ODOR INSIDE THE CABIN OF THE VEHICLE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE FUEL LINE CONNECTED TO THE FUEL TANK WAS RUSTED AND NEEDED TO BE REPLACED. THE FUEL LINE WAS REPLACED WITH A TEMPORARY REPLACEMENT PART UNTIL THE PERMANENT PART FOR THE REPAIR WAS AVAILABLE. IG BURTON CHEVROLET LOCATED AT 793 BAY ROAD, MILFORD, DE 19963 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.