2008 CHEVROLET HHR Complaints

THE GAS LINE IN LEAKING ON THE DRIVERS SIDE NEAR THE REAR WHEEL WELL. THE AREA IS WRAPPED IN A HEAT SHEILDING WRAP WHICH HOLDS MOISTURE. IM ASSUMING THIS IS WHY IT CAUSED THE GAS LINE TO RUST THROUGH.

FUEL LINE RUSTED OUT AND FUEL LEAKS ONTO EXHAUST PIPE AND SURROUNDING AREAS INCLUDING THE GROUND.

HELLO, HOW ARE YOU? THE TRACTION CONTROL WARNING LIGHT STAYS ON AND THE BUTTON CANNOT TURN IT OFF. THE ENGINE LIGHT STAYS ON AND THERE IS A SERVICE PROMPT ON THE INFORMATION SCROLL LCD SCREEN. THE CRUISE CONTROL SWITCH LIGHTS UP BUT THE CRUISE DOES NOT ENGAGE WHEN THE SET BUTTON IS PRESSED AT ANY SPEED, IE, 30MPH, 50MPH, 55MPH ETC. THE RESEARCH I READ RECOMMENDS TO CONTACT YOU TO HELP GET THIS VEHICLE INCLUDED IN AN EXISTING RECALL FOR THE SAME ISSUES IN OTHER GM VEHICLES WITH THE SAME EQUIPMENT. IN OTHER WORDS, THIS VEHICLE HAS THE SAME DEFECTIVE EQUIPMENT AS OTHER GM VEHICLES THAT HAVE BEEN RECALLED FOR REPAIR. DUE TO THE FACT THAT THIS VEHICLE HAS THE SAME DEFECTIVE EQUIPMENT THAT WAS RECALLED IN OTHER GM VEHICLES I REQUEST THIS VEHICLE BE COVERED UNDER THE SAME RECALL AND ABLE TO BE REPAIRED AS SOON AS POSSIBLE.

POWER STEERING WENT OUT WHILE DRIVING, SERVICE ESC CODE CAME ON. CAR HAS DONE THIS NUMEROUS TIMES OVER THE PAST YEAR, I HAVE REPLACED THE STEERING COLUMN, THE POWER STEERING MOTOR, THE CAR RAN FINE FOR WEEKS AND TODAY WHILE DRIVING DOWN THE ROAD THE SERVICE ESC CODE CAME ON AND I LOST POWER STEERING

I READ AN ARTICLE TODAY FROM THE DETROIT FREE PRESS ABOUT NHTSA'S INVESTIGATION OF FUEL LEAKS IN OLDER CHEVROLET HHR'S, SO I WANTED TO SEND YOU AN EMAIL ABOUT MY HHR'S ISSUE. I TOOK MY 2008 HHR IN FOR A NORMAL OIL CHANGE AND THEY TOLD ME ABOUT A FUEL LINE LEAK TOWARDS THE LEFT REAR WHEEL WELL OF MY CAR. I ALSO HAVE A 'CHECK ENGINE LIGHT' THAT WONT GO AWAY, AND GET A MESSAGE RANDOMLY TO CHECK MY FUEL CAP. I'VE REPLACED MY FUEL CAP TWICE, AND THE GARAGE I TAKE MY CAR TWO SAYS THE ENGINE LIGHT IS TIED INTO THE LEAKY FUEL LINE. I HAVE NOT REPLACED THE LINE DUE TO THE QUOTED $1,000 FOR REPAIR, BUT HAVE ATTACHED THE PHOTO BELOW. I BELIEVE THIS IS DIRECTLY RELATED TO NHTSA'S INVESTIGATION, AND WOULD LIKE TO KNOW HOW TO MOVE FORWARD NEXT. I ALSO THINK THIS LEAK HAS AFFECTED MY LEFT REAR TIRE SENSOR SINCE IT IS NEAR THE ROOT OF THE LEAK AND WOULD STOP AFTER 15-30 MINUTES. THANK YOU FOR YOUR TIME TODAY.

MY FUEL LINE HAS BECOME CORRODED AND IS LEAKING GAS FROM AROUND THE REAR DRIVER'S SIDE WHEEL.

TL* THE CONTACT OWNS A 2008 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE, THERE WAS AN ABNORMAL FUEL ODOR PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. FUEL WAS ALSO DISCOVERED LEAKING UNTO THE GROUND COMING FROM THE REAR WHEEL WELL. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER ARBOGAST CHEVROLET LOCATED AT 3540 SOUTH COUNTY RD, TROY OH 45373, WHO DIAGNOSED THAT THE FUEL LINES WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE FUEL LINES WERE REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 178,000.

I RECENTLY HEARD ON THE NEWS THAT THERE WAS A FUEL LINE LEAK PROBLEM REPORTED BY NHTSA, ON CHEVY COBALTS AND HHRS. I PRINTED A COPY OF THE NEWS REPORT, PROVIDED IT TO MY MECHANIC AND ASKED THE SHOP TO CHECK IT. THEY FOUND THE FUEL LINES READY TO CRUMBLE, WHICH THEY DID WHEN THE LINES WERE REMOVED. I WAS LUCKY THEY HAD NOT CRUMBLED--THE CAR COULD'VE CAUGHT FIRE. THE REPAIR WAS COSTLY AND LABOR INTENSIVE. THE BACK PART OF THE EXHAUST SYSTEM HAD TO BE REMOVED AND REPLACE DUE TO THE AGE OF THE CAR AND THINNESS OF THE EXHAUST PIPE AT THE CONVERTER.. THE MECHANICS STATED THAT THE CAUSE OF THE CORRODED FUEL LINES WAS POOR DESIGN, USING STEEL PIPES AND THE PIPES SITUATED SUCH THAT WATER (AND ROAD DE-ICER) GETS TRAPPED ABOVE A SHIELD PROMOTING CORROSION. I LOOKED UP THIS PROBLEM ON THE INTERNET AND FOUND MANY ENTRIES FOR HHRS WITH CORRODED FUEL LINES. I'M FORTUNATE THAT I HEARD THE NEWS ITEM OR MY CAR COULD'VE GONE UP IN FLAMES. I'M SURPRISED THERE HAS NOT BEEN A RECALL--THERE SHOULD BE.

I'VE HAD MY CAR RECALLED FOR IGNITION SWITCH, THEN ANOTHER RECALL FOR THE POWER STEERING MODULE AND NOW MY POWER STEERING COLUMN IS BAD. ALL THESE PARTS ARE IN THE SAME AREA AND I'VE HEARD MANY HHR OWNERS ARE HAVING THE SAME PROBLEM WITH THEIR STEERING COLUMN, IS THERE GOING TO BE A RECALL ON THIS AS WELL? I HAVEN'T EVEN HAD THIS CAR ALL THAT LONG! ANYTIME I DRIVE ON THE HIGHWAY IT FEELS SHAKY AND WHEN TURNING LEFT THE THE CAR JERKS TO THE LEFT. I'VE REPLACED EVERYTHING IN THE SUSPENSION. REPLACES SWAY BAR, BUSHINGS, BALL JOINTS, CONTROL ARMS, BRAKES, ROATERS, SPRINGS, STRUTS...FIXED IT ALL! I DO NOT FEEL SAVE ON THIS CAR

THE FUEL LINE ON MY VEHICLE DEVELOPED A LEAK AT THE LEFT REAR TIRE. I HAD TO BUY AND INSTALL AN AFTERMARKET FUEL LINE KIT. I FOUND THAT THE METAL FUEL LINE HAS RUSTED THROUGH. WHEN REMOVING THE OLD FUEL LINE THE PURGE LINE BROKE OPEN AT A RUSTY AREA. THESE TWO LINES AND A BRAKE LINE RUN THROUGH A TUBULAR KNITTED HEAT SHIELD IN THIS AREA. THE HEAT SHIELD HAD COLLECTED DIRT AND SALT AND WAS DAMP ON A DRY DAY WHEN I WAS WORKING ON THE LINE REPLACEMENT. POOR DESIGN.