2006 CHEVROLET MALIBU Complaints

BRAKE LIGHTS ILLUMINATE WHEN BRAKE PEDAL IS APPLIED. WILL GO OFF WHEN FOOT IS TAKEN OFF OF PEDAL, BUT WILL GO BACK ON AND STAY ON WHEN PEDAL IS NOT APPLIED. THIS HAPPENS BOTH WHEN IN NEUTRAL AND IN PARK AND THE CAR IS STATIONARY. I BELIEVE THE PROBLEM IS WHERE INCREASED RESISTANCE IN THE BODY CONTROL MODULE (BCM) CONNECTION SYSTEM CAN RESULT IN VOLTAGE FLUCTUATIONS OR INTERMITTENCY IN THE BRAKE APPLY SENSOR (BAS) CIRCUIT THAT CAN CAUSE BRAKE LAMP MALFUNCTION. THE BRAKE LAMPS ILLUMINATE WITHOUT THE BRAKE PEDAL APPLIED. RECALL ON THIS PROBLEM DATED MARCH 2017, # 13036. THIS RECALL PROBLEM AND NUMBER DOES NOT SHOW UP IN THE NHTSA DATABASE.

HEATED SEAT MALFUNCTION: TURNED HEATED SEAT ON LOWEST NUMBER AS WE LEFT HOME AND WITHIN ABOUT 1/4 OF A MILE THE SEAT BECAME EXTREMELY HOT ON MY SONS BOTTOM AND WE STARTED SMELLING A SCENT OF BURNING. MY SON IMMEDIATELY TURNED OFF THE HEATED SEAT AND RAISED UP OFF THE SEAT UNTIL I COULD GET THE CAR PULLED OVER. WHEN HE GOT OUT WE SAW A HOLE HAD BURNED INTO THE SEAT. IT ALSO BURNED A SMALL HOLE IN HIS PANTS. HE COULD HAVE BEEN SEVERELY INJURED IF WE HAD OF NOT BEEN ABLE TO PULL OVER QUICKLY.

POWER STEERING MOTOR STOPPED WORKING WHILE DRIVING, CAR HAS ONLY 79K MILES. DEALERSHIP DIAGNOSED THE POWER STEERING MOTOR WENT BAD, BUT THERE IS NO RECALL ON MY VEHICLE?.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE; THE "POWER STEERING" WARNING MESSAGE DISPLAYED AND THE STEERING WHEEL WOULD JERK AND VIBRATE. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 140,000.

WHILE DRIVING THE STEERING WHEEL WILL LOCK AND LOSS POWER CAUSING THE DRIVER MORE OF AN EFFORT TO STEER THE CAR IN THE DIRECTION THAT THE CAR IS GOING SHOULD AS CURVES IF THE STEERING WHEEL LOCKS ON A CURVE THE CAR WILL CONTINUE TO GO STRAIGHT INSTEAD OF AROUND THE CURVE

WARNING COMES ON RADIO WITH WARNING BEEPS AND ALL POWER STEERING IS LOST UNTIL YOU TURN OFF CAR AND RESTART. IT CAN HAPPEN DURING ANY DRIVING SITUATION AT ANY SPEED. THE CAR HAS ALREADY HAD THE INITIAL RECALL TAKEN CARE OF FOR THIS SAME PROBLEM EVEN THO WE NEVER EXPERIENCED A PROBLEM WITH IT THEN. NOW EVEN THO ANOTHER RECALL WAS ISSUED THEY SAY MY CAR ISN'T IN THAT GROUP. MAKES NO SENSE.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE VEHICLE SUDDENLY LOSS THE POWER STEERING ABILITY. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS DRIVEN TO OURISMAN CHEVROLET OF BALTIMORE (6633 SECURITY BLVD, WOODLAWN, MD 21207) AND THE CONTACT WAS INFORMED THAT SHE WOULD HAVE TO PAY TO HAVE IT DIAGNOSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN 2014, THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE FAILURE MILEAGE WAS 105,181.

OUR CAR JUST RECENTLY STARTING HAVING THE POWER STEERING GO OUT. SOMETIMES WHEN WE FIRST START UP THE WARNING BELL SOUNDS AND THERE IS NO STEERING. OTHER TIMES WE CAN BE DRIVING DOWN THE ROAD AND THE WARNING BUZZER SOUNDS AND THERE IS NO POWER STEERING. IT IS A LOT SCARY WHEN YOU ARE DRIVING THE INTERSTATE, RUNNING 75 MPH AND THAT BUZZER GOES OFF. WE WERE TOLD BY THE GARAGE THAT THERE WAS A RECALL FOR THIS PROBLEM BUT IT WAS ONLY GOOD FOR 10 YEARS OR 150,000 MILES. NEEDLESS TO SAY, WE ARE OVER THE 10 YEARS BUT OUR MILEAGE IS AT 103,000 MILES. I WOULD THINK THAT WITH THIS BEING A SAFETY ISSUE, THE RECALL WOULD STILL BE OPEN. WE WERE TOLD BY A MECHANIC THAT IT'S A SENSOR IN THE STEERING COLUMN BUT CAN ONLY BE REPAIRED BY CHEVY.

I FILLED MY GAS TANK AND WHEN I STARTED MY CAR, THE FUEL LIGHT LEVEL WENT FROM FULL TO EMPTY WITH THE WARNING LIGHT "LOW FUEL" LIT UP. THEN THE SERVICE ENGINE LIGHT CAME ON. AFTER ABOUT 3 TO 4 TIMES OF DRIVING THE VEHICLE, IT SEEMED TO GO BACK TO NORMAL, THAT IS UNTIL THE NEXT TIME AND THE NEXT TIME AND SO ON THAT I FILLED MY GAS TANK. IT IS CURRENTLY DOING THE SAME THING. I DO NOT EVER KNOW HOW MUCH GAS I HAVE IN THE CAR BECAUSE THE NEEDLE GOES UP AND DOWN CONSTANTLY.

RECALL 14116, STEERING SHAFT TORQUE SENSOR WAS PERFORMED 1 APRIL 2016 AT 37560 MILES. ON APPROX. 1-05-18, AT APPROX. 76000 MILES, THE STEERING FAILED COMPLETELY RESULTING IN EXTREMELY DIFFICULT CONTROL OF THE VEHICLE. THIS WAS LESS THAN 2 YEARS AFTER THE RECALL REPLACEMENT. UPON DIAGNOSIS TECHNICIANS FOUND THAT THE STEERING SHAFT TORQUE SENSOR AND THE ELECTRONIC POWER STEERING MOTOR CONTROL MODULE HAD FAILED. THE MOTOR CONTROL MODULE PROBABLY FAILED DUE TO INCREASED STRESS ON THE SYSTEM DUE TO THE TORQUE SENSOR HAVING FAILED. THE REPAIR SHOP HAD TWO ORIGINAL EQUIPMENT REPLACEMENTS FOR THE MOTOR CONTROL MODULE FAIL OUT OF THE BOX BEFORE A GOOD ONE WAS PROVIDED, AND BOTH UNITS HAD TO BE REPEATEDLY TESTED AND ADJUSTED BEFORE ACCEPTABLE PERFORMANCE WAS REACHED. BASED ON THE HISTORY OF THESE TYPE FAILURES IT IS APPARENT THAT GM HAS NOT CORRECTED THE PROBLEMS WITH THESE SYSTEM COMPONENTS. IT COST $747.36 FOR PARTS, AND $234.00 LABOR FOR THE REPAIR, NOT INCLUDING TAX. IT IS NOT ACCEPTABLE THAT GM IS NOT ACTUALLY CORRECTING THE APPARENT DESIGN ISSUES WITH THESE SYSTEMS, BUT IS CONTINUING TO USE THEM IN VEHICLES EVEN WITH THEIR HISTORY OF FAILURE. GM CUSTOMER SERVICE OFFERED NO HELP AT ALL FOR THE COST OF THIS REPAIR EVEN THOUGH THEIR PARTS APPEAR TO BE DEFECTIVE IN DESIGN. THEIR ONLY RESPONSE WAS THAT THEY HAD MADE THE RECALL CORRECTIONS AT NO COST ONCE AND WOULD NOT DO IT AGAIN. YET THE OEM REPLACEMENT PARTS FAILED REPEATEDLY OUT OF THE BOX. IT SEEMS THAT GM SHOULD HAVE SOME RESPONSIBILITY AS THEY CONTINUE TO PRODUCE DEFECTIVE PRODUCTS THAT APPEARS TO FAIL REPEATEDLY..