2003 CHEVROLET MALIBU Complaints

NHTSA ACTION NUMBER (PE05055) WAS INITIALLY ISSUED IN 2004 FOR A DEFECTIVE TURN SIGNAL/HAZARD FLASHERS THAT BECOME INOPERATIVE ON MODEL YEAR 1999-2000 MALIBU, ALERO, GRAND AM, AND 1999 CUTLASS. THIS ACTION NUMBER WAS LATER REVISED IN 2005 TO INCLUDE MODEL YEAR 2001-2002 MALIBU, ALERO, AND GRAND AM VEHICLES. THE RESULTING DOCUMENT FROM GM FOR THE INITIAL MODEL YEAR RANGE WAS: SPECIAL POLICY ADJUSTMENT - TURN SIGNALS/HAZARD WARNING FLASHERS #04098 - (DEC 16, 2004) GM DOCUMENT ID# 1578551 AND WHEN THE MODEL YEAR RANGE WAS EXTENDED: SPECIAL POLICY ADJUSTMENT-TURN SIGNAL/HAZARD WARNING FLASHERS #04098A - (JAN 11, 2006) GM DOCUMENT ID# 1750030 - I OWN (BOUGHT IT NEW) A 2003 CHEVY MALIBU THAT HAS EXPERIENCED THE SAME SYMPTOM OF INTERMITTENT TURN SIGNAL FAILURE. BOTH LEFT AND RIGHT TURN SIGNALS SOMETIME WORK AND SOMETIME DO NOT. YOU CAN NEVER KNOW WHEN IT WILL OR WILL NOT WORK. THIS IS A REAL SAFETY RISK. THE SWITCH TYPE IN THE 2003 MALIBU APPEARS TO BE THE SAME AS IN THE PREVIOUS YEARS FOR WHICH GM ISSUED THE SPECIAL POLICIES (NOTED ABOVE). ON OCTOBER 8TH 2011, I REPLACED THE TURN SIGNAL/HAZARD WARNING FLASHER SWITCH THAT WAS IDENTIFIED IN THE GM DOCUMENT. (REPLACED WITH DORMAN PART 924-601). IT HAS BEEN ALMOST 3 WEEKS SINCE THE REPLACEMENT AND I HAVE NOT EXPERIENCED THE PROBLEM. I WOULD HAVE SEEN THE PROBLEM OCCUR DURING THIS 3 WEEK PERIOD. IN CASE IT HELPS IN YOUR INVESTIGATION, THE NUMBER ON THE DEFECTIVE SWITCH I REMOVED FROM MY 2003 MALIBU IS : 22594146 0843 F I WANTED TO REPORT THIS FAILURE AS THERE IS A POSSIBLY THAT THERE WILL BE OTHERS WITH THE MODEL YEAR 2003 MALIBU''S THAT HAVE EXPERIENCED THIS PROBLEM AND WILL ALSO FILE A CLAIM WITH NHTSA. IF THIS IS THE CASE, GM WILL NEED TO ONCE AGAIN EXTEND THE RANGE OF VEHICLES AFFECTED BY THE DEFECTIVE SWITCH/HAZARD FLASHERS AND INCLUDE THIS EXTENDED RANGE IN THEIR SPECIAL POLICY ADJUSTMENT. *TT

CAR WILL NOT START FUEL PUMP SHUTS DOWN, CAR THINKS IT IS BEING BROKEN INTO. HAVE TO SIT IN CAR FOR 10 MINUTES WITH KEY IN IGNITION TO OVERRIDE SYSTEM. HAS HAPPENED 4 TIMES IN LAST MONTH. ALSO, FUEL PUMP SHUT DOWN WHILE DRIVING ON PARKWAY- LUCKY TO GET TO SIDE OF ROAD WITHOUT AN ACCIDENT. BY THE WAY, NEW FUEL PUMP AND MODULE REPLACED AT 60,000 SO THAT IS NOT THE ISSUE.. HOW MANY PEOPLE NEED TO GET INTO ACCIDENTS OR DIE BEFORE THE NHTSA GETS INVOLVED AND MAKES CHEVY DO THE RIGHT THING AND REPLACE THIS IGNITIONS AND PASSLOCK PARTS THAT ARE DEFECTIVE!!!! OH, AND THEY GOT A BAIL OUT- BUT THE CONSUMERS DON'T GET ANY AND HAVE TO CONTINUE TO PAY THEM FOR REPAIRS THAT THEY CAUSED IN THE FIRST PLACE GM MAKES AN ASTRONOMICAL AMOUNT OF MONEY ON THESE REPAIRS. I HOPE THE NHTSA GETS A SHARE OF THAT MONEY BECAUSE YOU CERTAINLY AREN'T INTERESTED IN CORRECTING THE SITUATION. HOW MANY YEARS AND TENS OF THOUSANDS OF COMPLAINTS DOES IT TAKE??????? *TR

MY 2003 CHEVY MALIBU WOULD NOT START. I LEARNED THAT THE REASON IT WOULD NOT START WAS DUE TO THE THEFT SYSTEM PASS LOCK. SOMEHOW THE THEFT SYSTEM WAS TRIGGERED AND CUT THE FUEL SUPPLY TO THE ENGINE. I DID WHAT THE MANUAL SAID AND WAITED 10 MINUTES WITH THE KEY IN THE ON POSITION. THE CAR STARTED AFTER THAT; HOWEVER TWO WEEKS LATER, THE CAR DOES THE SAME THING. THE PROCESS IS REPEATED TO RESET THE THEFT SYSTEM. BUT NOW I WONDER HOW MANY MORE TIMES THIS PROBLEM WILL OCCUR AND WHY HASN'T ANYTHING BEEN DONE ABOUT A RECALL. OVER 30 INCIDENTS HAVE REPORTED ONLINE AT HTTP://WWW.CARCOMPLAINTS.COM/CHEVROLET/MALIBU/2003/ SO WHY HASN'T THERE BE A RECALL FOR THIS PROBLEM!!!!!!!!!!!!!!!!! I AM SURE THAT MORE PEOPLE HAVE HAD PROBLEMS WITH THIS THEY JUST HAVE NOT REPORTED IT. THIS PROBLEM IS VERY INCONVENIENT AND YOU NEVER KNOW WHEN YOUR CAR IS ACTUALLY GOING TO START. SOMETHING NEEDS TO BE DONE!!!!!!!!!!!!!! *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WOULD NOT RELEASE FROM THE IGNITION. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED TO PLACE THE GEAR IN PARK IN ORDER TO RELEASE THE KEY FROM THE IGNITION. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 17,100.

THE VEHICLE WILL NOT TURN ON EVERY FEW TIMES WHEN TRYING TO TURN IT ON. THE THEFT LIGHT BEGINS TO BLINK. I HAVE TO TURN IT TO THE "ON" POSITION FOR 10 MINUTES FOR IT TO RESTART, THEN IT WILL WORK. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A LOSS OF CONTROL IN THE STEERING. THE CONTACT WAS ABLE TO REGAIN FULL CONTROL OF THE VEHICLE AND CONTINUED TO DRIVE WITH CAUTION. THERE WAS A NEARBY INDEPENDENT MECHANIC WHO INSPECTED THE VEHICLE AND STATED THE SUB FRAME WAS FRACTURED DUE TO CORROSION. IN ADDITION, BOTH FRONT COIL SPRINGS FRACTURED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

PASSLOCK ANTI-THEFT SYSTEM ENGAGING AND NOT ALLOWING CAR TO START. STARTED HAPPENING ABOUT TWO YEARS AGO. RESEARCHED ON THE INTERNET AND ASKED PROFESSIONAL ASE MECHANICS. NO WARRANTY OR TSB AVAILABLE TO FIX PROBLEM, BUT PLENTY OF COMPLAINTS. CAR HAS NOT SHUT OFF WHILE DRIVING. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT WAS DRIVING AT VARIOUS SPEEDS AND THE ACCELERATOR PEDAL BECAME STUCK WHILE DEPRESSED. AFTER SEVERAL ATTEMPTS, THE ACCELERATOR PEDAL RELEASED AND FUNCTIONED NORMALLY. THE FAILURE OCCURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THEY INFORMED THE CONTACT OF THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER 04V528000 (VEHICLE SPEED CONTROL: ACCELERATOR PEDAL). THE VIN WAS NOT INCLUDED IN THE RECALL; HOWEVER THE CONTACT EXPERIENCED A SIMILAR FAILURE AS MENTIONED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. UPDATED 09/27/11 *BF UPDATED 10/11/11

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS WOULD STOP ILLUMINATING ON AN INTERMITTENT BASIS WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE BECAUSE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 113,000. HAZARD SWITCH HAS BEEN REPLACED AND SEEMS TO HAVE TAKEN CARE OF THE PROBLEM. UPDATED 11/16/2011 *LN *TR

TL* THE OWNS A 2003 CHEVROLET MALIBU. THE CONTACT WAS DRIVING 10 MPH WHEN THE FRONT PASSENGER AIR BAGS DEPLOYED WITHOUT WARNING. THE CONTACT SUFFERED MINOR CUTS AND BURNS AS A RESULT AND HAD TO SEEK MEDICAL TREATMENT. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 93,000.