2003 CHEVROLET MALIBU Complaints

WHEEL HUB BEARINGS - SINCE I BOUGHT THE 2003 MALIBU NEW IN JANUARY 203 I HAD TO REPLACE THE WHEEL HUB BEARING 4 TIMES, ONCE UNDER WARRANTY WITH GM PARTS AT 27,918 ON 4/20/04 RIGHT SIDE), AGAIN RIGHT SIDE WITH AFTER MARKET PARTS AT 47,876, LEFT SIDE WITH AFTER MARKET PARTS AT 48,769 ON 5/3/05, AND RIGHT SIDE WITH AFTER MARKET PARTS AT 83,197 ON 4/17/07. WITH SO MANY FAILURES I BELIEVED THEREWAS EITHER AN INHERIT DESIGN FLAW OR POSSIBLE LATENT DEFECT OF THE FRONT END.*AK

CAR FAILED TO START ON RANDOM OCCASIONS. BECAME MORE FREQUENT. ANTI-THEFT SYSTEM WAS CAUSING IT NOT TO START. WOULD HAVE TO WAIT FOR TEN MINUTES TO START - IN PLACES LIKE AT A GAS PUMP WITH OTHERS WAITING TO USE IT. THEFT SYSTEM LIGHT WOULD OCCASIONALLY STAY ON EVEN WHEN IT STARTED. IT BECAME LIKE PLAYING RUSSIAN ROULETTE HOPING THE CAR WOULD START AND HOPING AGAINST HOPE THAT THE CAR WOULD NEVER STALL IN TRAFFIC AND THEN NOT RE-START. DEALER FINALLY HAD TO REPLACE THE IGNITION SWITCH, IGNITION CYLINDER AND LOCK CYLINDER TO THE TUNE OF $682.00. THIS WAS DONE AT 71,190 MILES. THE IGNITION SWITCH AND IGNITION CYLINDER WERE ALREADY REPLACED AT 46,000 MILES. OTHERS I HAVE SPOKEN TO HAVE HAD THE SAME PROBLEM WITH THIS YEAR'S MODEL OF THE MALIBU BUT THEY NEVER RECALLED IT. THE THEFT SYSTEM IS OBVIOUSLY DEFECTIVE.*AK

CAR FAILS TO START CRANKS AND NO STARTS TOOK IT TO DEALER AND PROMISE NOTHING SPEND ALMOST 1000.00 DOLLARS AND IT DID IT AGAIN TODAY

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING BETWEEN 30-50 MPH, THE ACCELERATOR PEDAL STICKS. THE CONTACT MUST APPLY THE BRAKES AND ATTEMPT TO REACH DOWN AND PULL THE ACCELERATOR PEDAL UP MANUALLY. THE CONTACT STATED THAT THE FAILURE BEGAN ON MAY 30, 2005 AND THERE IS SAFETY RECALL # 04V528000 (VEHICLE SPEED CONTROL:ACCELERATOR PEDAL) ON THE VEHICLE. SHE CALLED A DEALER THAT SOLD GM CARS BUT WAS NOT ACTUALLY A GM DEALER AND INFORMED HER THAT THE RECALL WAS CLOSED. THE CONSUMER HEARD SO MANY NEGATIVE THINGS ABOUT THAT SPECIFIC DEALER THAT REPAIRS WERE DONE AT ANOTHER LOCATION. THE CONTACT STATED THAT HER ACCELERATOR PEDAL HAD BEEN INSPECTED MONTHS EARLIER. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 65,000 AND FAILURE MILEAGE WAS 52,000. THE CONSUMER STATED THE VEHICLE WAS TAKEN TO A CHEVROLET DEALER WHO FIXED THE VEHICLE VIA THE RECALL IMMEDIATELY AT NO CHARGE. UPDATED 07/24/07 *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE VEHICLE HAS FIRESTONE AFFINITY TOURING TIRES, SIZE P215-60R15. THE REAR DRIVER SIDE TIRE HAD A NAIL IN IT AND IT WAS REPAIRED. HE WAS INFORMED THAT THE TIRE HAD TREAD SEPARATION AND COULD NOT BE REPAIRED. THE DOT NUMBER WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 17,800.

NO EVENTS OCCURRED PRIOR TO THIS PROBLEM. THEFT SYSTEM ACTIVATED ON ITS OWN WHILE I WAS DRIVING. SINCE HAVING NO KNOWLEDGE OF THIS PROBLEM I HAD WORK DONE THAT WAS UNNECESSARY. THE THEFT SYSTEM AND KEY CYLINDER WERE SUPPOSEDELY BE REPLACED BACK IN 10/06. I PAID OVER $700.00. IT HAS STARTED TO ACTIVATE AGAIN AS OF MAY 1ST. THE ORGINAL DEALER NOR MANUFACTURER NOR CHEVY DEALER REPAIR CENTER I PAID THE $700.00 TO HAVE ANY HELPFUL OF UNDERLINE KNOWLEDGE OF WHY IT SUDDENLY ACTIVATED BY ITSELF. THIS WAS A RECKELESS SAFETY HAZARD WAITING TO HAPPEN. *AK

WITHOUT WARNING WHILE ON A SHOPPING TRIP (WE ARE IN OUR LATE 70'S), THE CAR WOULD NOT START AND HAD TO BE TOWED. WE WERE TOLD THAT IT WAS THE ANTI-THEFT SECURITY SYSTEM, AND IT WAS RE-SET. WE WERE TOLD THAT IT MAY OR MAY NOT HAPPEN AGAIN. WELL, IT HAPPENED AGAIN ABOUT 6 WEEKS LATER, AND WE HAD TO TAKE A TWO HOUR BUS RIDE JUST TO GET HOME. I BELIEVE THAT THE DEALERS ARE FULLY AWARE OF THIS PROBLEM AND THAT A RECALL NEEDS TO BE ISSUED, OR AT THE VERY LEAST THE COST OF REPAIR SHOULD BE COVERED UNDER WARRANTY. *TR

THE BLINKERS AND HAZARD LIGHTS HAVE SPORADICALLY STOPPED WORKING FOR SHORT PERIODS OF TIME OVER THE PAST COUPLE OF YEARS. NOW THEY HAVE STOPPED WORKING COMPLETELY. THIS IS A MAJOR SAFETY HAZARD WHILE DRIVING. IT ALSO WILL NOT MEET THE STATE INSPECTION REQUIREMENTS. AFTER RESEARCHING THE INTERNET ABOUT THIS PROBLEM, I HAVE FOUND HUNDREDS OF SITES WITH OTHER PEOPLE STATING THEIR CHEVY MALIBU HAS DONE THE SAME THING. GM HAD ONE RECALL ON THIS ISSUE BUT ONLY INCLUDED A SMALL NUMBER OF VIN'S. IT APPEARS THEY HAVE NOT FIXED THE PROBLEM. *JB

WHEN WEATHER IS WARM THE VEHICLE WILL REV UP TO 3000 -3500 RPMS AND WILL NOT RETURN TO IDLE SPEED. THE BRAKES HAVE TO BE APPLIED STRONGLY TO KEEP VEHICLE FROM TAKING OFF, THIS ALSO HAPPENS WHILE IN DRIVE AND THE BRAKES HAVE TO BE APPLIED IN ORDER TO MAINTAIN A SAFE LEGAL SPEED. CHECKED FOR POSSIBLE RECALL AND FOUND ONE THAT MATCHES THE ACTIONS OF THIS VEHICLE EXACTLY HOWEVER THIS ONE IS NOT INCLUDED (VIN). THIS IS HAPPENING WITH INCREASING FREQUENCY AND STARTS SOMETIMES AS SOON AS THE VEHICLE IS TURNED ON. VERY DISSATISFIED WITH GM BEING THE FIRST GM CAR I HAVE OWNED I AM NOT AT ALL IMPRESSED WITH THE RESPONSE RECEIVED WHEN WE CONTACTED THEM ABOUT THE RECALL. *AK

I AM THE OWNER OF A 2003 MALIBU. I HAVE ONLY HAD IT FOR 6 MONTHS. THE CAR HAS CUT OFF ON ME 3 TIMES WITH MY 3 YEAR OLD IN THE CAR. I HAVE READ MANY COMPLAINTS ABOUT THE SAME PROBLEM. I TOOK MY CAR TO THE DEALERSHIP, AND THEY SAID THAT IT WAS THE IGNITION SWITCH, AND IT WAS GOING TO COST ME $400.00 TO FIX IT. I DON'T HAVE THAT KIND OF MONEY TO PUT INTO A CAR WHEN THERE SHOULD BE A RECALL ON IT. I AM HIGHLY UPSET WITH GM BECAUSE THEY WON'T DO ANYTHING ABOUT IT. ALSO, I HAVE HEARD THAT THEY WON'T DO A RECALL ON THIS PROBLEM BECAUSE THEY DON'T CONSIDER IT TO BE A SAFETY ISSUE. I DON'T SEE HOW A COMPANY CAN PUT OFF A RECALL LIKE THIS WHEN SOMEONE CAN GET SERIOUSLY HURT OR EVEN KILLED. I DON'T KNOW WHAT ELSE TO DO, AND ANOTHER OF COURSE THE EXTENDED WARRANTY THAT I BOUGHT DOESN'T COVER IT. WHY DO THEY EVEN HAVE AN EXTENDED WARRANTY WHEN IT DOESN'T COVER A BLASTED THING.*AK