2003 CHEVROLET MALIBU Complaints

DT: THE CONSUMER STATES THAT ON 2003 CHEVROLET MALIBU THE CRUISE CONTROL WAS STILL ACTIVE EVEN WHEN THE DRIVER HAD HIS FOOT ON THE BRAKE. THE SWITCH ON THE STEERING WHEEL WAS TURNED OFF AND THE CRUISE WAS STILL ACTIVATING AND SPEEDING THE CAR UP. THE CONSUMER PUT HIS FOOT ON THE BRAKES SEVERAL TIMES TRYING TO GET THE CAR TO STOP. THE CONSUMER FINALLY WAS ABLE TO GET THE CAR TO STOP, BUT HE HAD TO PUT THE CAR INTO NEUTRAL. THE CAR HAD TO BE TURNED OFF COMPLETELY. IT SET FOR ABOUT 5 MINUTES AND THEN VEHICLE RESTARTED. THE CAR SAT FOR A FEW MINUTES AND THEN THE CAR WAS BACK TO NORMAL. THE CONSUMER CALLED THE DEALERSHIP AND CHECKED TO SEE IF THERE WERE ANY PROBLEMS WITH THE CAR, AND THE DEALERSHIP HAD NOT EVER HEARD OF THIS HAPPENING BEFORE. THE MANUFACTURER HAS NOT BEEN CONTACTED AT THIS POINT. THE SPEED WAS 65 MPH AND THAT WAS WITH THE DRIVER'S FOOT ON THE BRAKE. *AK *JB

2003 CHEVY MALIBU HAS DEFECTIVE IGNITION LOCK CYLINDER. MY CAR HAS 49000 MILES ON IT AND THIS IS THE SECOND TIME THE IGNITION LOCK CYLINDER HAS KEPT ME STRANDED. THIS TIME I WAS IN A SOMEWHAT DANGEROUS AREA, AND HAD NO PHONE OR WAY TO GET TO ONE. WHEN CAR WAS UNDER WARRANTY THE DEALER REPLACED THE CYLINDER AND NOW THEY WANT A COUPLE OF HUNDRED BUCKS TO DO IT AGAIN. *JB

ANTI -LOCK BRAKE LIGHT (ABS) IS ON AND THE ABS SOMETIMES ACTIVATES WHEN THE USING THE BRAKES AT A SLOW SPEED. *JB

FRONT BRAKE/ROTOR/CALIPER FAILURE. I HAVE HAD MY ROTORS, FRONT PADS AND CALIPERS REPLACED NUMEROUS TIMES ROTORS 4 TIMES, CALIPERS 4 TIMES AND FRONT PADS 16 TIMES DUE TO FAULTY DESIGN, THE CALIPERS HANG UP AND DO NOT RELEASE ALL THE WAY CAUSING THE INNER PADS TO WEAR ABNORMALLY. *NM

TWICE NOW, MY CAR HAS NOT STARTED DUE TO THE ANTI-THEFT SYSTEM. I HAVE ONLY HAD THE CAR A YEAR AND HALF AND IT IS ABOUT TO DO IT A THIRD TIME. I KNOW THIS BECAUSE EACH TIME THE THEFT SYSTEM LIGHT COMES ON AND OFF FOR ABOUT THREE WEEKS BEFORE THE CAR WON'T START. I CANNOT GET THE CAR TO A DEALERSHIP RIGHT AWAY, I HAVE TO REMEDY THE SITUATION MYSELF BY RESETTING THE COMPUTER WHICH ERASES ANY CODE THAT WAS STORED, AND THEREFORE THE CAR CANNOT GET FIXED. *JB

BRAKES (ROTORS AND FRONT PADS) KEEP NEEDING TO BE REPLACE. FIRST AT 14,000 MILES AND THEN AGAIN AT 28,000 MILES. THE FIRST TIME THEY WERE REPLACED UNDER THE 36,000 MILE WARRANTY, BUT THE SECOND TIME THE DEALER REFUSED TO DO IT UNDER THE WARRANTY AND WANTED $500 FOR JOB. DEALER FIRST SAID THE REAR BRAKES WERE NOT ADJUSTED BUT WOULDN'T BLAME THE SELF ADJUSTERS THAT SHOULD KEEP THEM ADJUSTED. THEN THEY SAID THAT IT WAS MY DRIVING HABITS, REFUSING TO REFER TO ALL THE OTHER COMPLAINTS ABOUT MALIBU'S BRAKES AND THE FACT THAT NONE OF MY OTHER CARS HAVE EVER HAD BRAKES WERE OUT SO SOON. NOW THEY SAY IT IS "NORMAL" FOR MALIBU BRAKES TO WEAR OUT AFTER 14,000 MILES AND AGAIN THEY WON'T COVER THEM UNDER WARRANTY. BRAKES DO NOT WEAR OUT AFTER 14,000 MILES. *JB

FRONT BRAKE PADS AND ROTORS KEEP NEEDING TO BE REPLACED. CAR WAS PURCHASED NEW IN SEPT OF 2003, NEED NEW PADS/RESURFACED ROTORS AT 13,000 MILES AND AGAIN AT 28,000 MILES. *JB

DT: 2003 CHEVROLET MALIBU. THE ANTI-LOCK BRAKES FAILED. THE CONSUMER STATES WAS DRIVING 40 MPH WHEN THIS OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY STATE THERE WAS NOTHING WRONG WITH THE VEHICLE. THIS PROBLEM HAPPENED TWICE. *AK

VEHICLE SAFETY ISSUE: 2003 CHEVY MALIBU HAS BEEN INTO THE DEALER THREE (3) TIMES FOR BRAKE REPAIRS. FIRST COMPLAINT I WAS TOLD BRAKES NEEDED TO "WEAR IN", CAR ONE (1) WEEK OLD. SECOND COMPLAINT, SOFT AND PULSATING PEDAL WITH POOR STOPPING, ROTORS WERE "REFINISHED", VEHICLE MILEAGE 6,800. THIRD COMPLAINT, VEHICLE UNCONTROLLABLE WHEN STOPPING AT HIGHWAY SPEEDS, DEALER ADVISED THAT ROTORS HAVE "EXCESSIVE RUN-OUT" AND INNER PADS ARE "LOW". COST TO REPAIR THREE HUNDRED AND FIFTY DOLLARS ($350.00), VEHICLE MILEAGE 30,000. DEALER AND GENERAL MOTORS REFUSE TO ADMIT THE BRAKE WEAR IS CAUSED BY A SAFETY DEFECT IN THE BRAKING SYSTEM. NO REPAIRS HAVE BEEN MADE AND VEHICLE WAS RELEASED FROM THE DEALER AND IS NOW UNSAFE TO OPERATE DUE TO UNCONTROLLABLE STEERING WHILE BRAKES ARE APPLIED.

ON 5/24/05 I PURCHASED A 2003 CHEVY MALIBU FROM SUBURBAN CHEVY. FROM THE MOMENT I TEST DROVE IT THERE WERE ISSUES WITH BRAKE NOISE FROM THE CAR'S FRONT TIRES. I ALSO NOTICED THAT THE PEDAL WAS VERY SOFT WHEN THE BRAKES WERE APPLIED. ON MY FIRST VISIT I WAS INFORMED BY THE TECHNICIAN THAT IT WAS BRAKE RUST FROM SITTING IN THE LOT AND THAT IT WOULD BURN OFF IN A COUPLE OF DAYS. A WEEK LATER, I RETURNED WITH THE SAME NOISE AND A PULSATING STEERING WHEEL WHEN THE BRAKES WERE APPLIED. THIS TIME ANOTHER TECHNICIAN INFORMED ME THAT THE ROTORS WERE INCORRECTLY MACHINED AND THAT THEY WOULD FIX THE PROBLEM. HE ALSO INFORMED ME THAT BECAUSE THE BRAKES WERE PARTIALLY METALLIC, I WOULD EXPERIENCE SOME NOISE. WHAT HE DIDN'T TELL ME WAS THAT I WOULD STILL EXPERIENCE THE SOFT PEDAL AND PULSATING STEERING AT SLOWER SPEEDS. TO DATE THE PROBLEM PERSISTS.