2006 CHEVROLET MALIBU Complaints

FUEL LEVEL SENSOR FAILURE. FUEL READS EMPTY EVEN THOUGH THE GAS TANK IS FILLED. IT TOOK 3 HOURS AND 322 DOLLARS TO FIX.. UNREASONABLE IS ALL I CAN SAY... *TR

SEVERAL YEARS AGO VEHICLE STARTED TO EXHIBIT IGNITION MISSES WHEN MAKING SLOW SPEED TURNS 10-20MPH. CONDITION WOULD CORRECT ITSELF WHEN COMING OUT OF TURNS OR ENTRANCE RAMPS MERGING INTO TRAFFIC. IN 2013 AND 2014 OCCURRENCE BECAME MORE FREQUENT (2-3 TIMES WEEKLY). CHEVROLET DEALER ADVISED ME TWO MONTHS AGO THAT IT APPEARS TO BE CAUSED BY DEFECTIVE IGNITION SWITCH AND ADVISED ME TO REMOVE UNNECESSARY WEIGHT FROM IGNITION KEY CHAIN. I IMMEDIATELY DID THIS AND PROBLEM HAS NOT HAPPEN AGAIN. HOWEVER, DEALER ADVISED THAT I COULD ADD MY NAME TO WAIT LIST FOR A NEW IGNITION SWITCH, BUT WOULD HAVE TO PAY FOR THE REPAIR SINCE MY 2006 IS NOT ON THE RECALL LIST. SINCE MANY OTHER GM MODELS HAVE BEEN RECALLED FOR THIS SAME LATENT DEFECT I FEEL MY VEHICLE SHOULD BE ADDED TO THE RECALL LIST FOR THIS PROBLEM. *TR

LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT REGARDING STEERING PROBLEMS ON HER 2006 CHEVROLET MALIBU; PLEASE SEND RESPONSE DIRECTLY TO SENATOR OFFICE AND REFERENCE CONSTITUENT. *SMD THE CONSUMER STATED THE FRONT BRAKE CALIPERS FAILED TO RETRACT CAUSING THE BRAKES TO OVERHEAT AND CATCH FIRE. THE MECHANIC STATED IT MAY HAVE BEEN DUE TO A FACTORY FLAW AS HE HAD NEVER SEEN BOTH CALIPERS FAIL TOGETHER. THE BRAKE CALIPER SEALS WERE MELTED FROM HEAT AND THEY WERE CRACKED/DRY ROTTED LETTING THE CALIPER SLEEVE RUST. A MONTH PRIOR, THE CONSUMER NOTICED THE POWER STEERING SEEMED STIFF AND THE VEHICLE BECAME DIFFICULT TO STEER, THE CONSUMER DID RECEIVE A RECALL NOTICE REGARDING A POTENTIAL PROBLEM WITH THE STEERING. ON DECEMBER 20, 2011 THE CONSUMER EXPERIENCED ANOTHER STEERING FAILURE, SLOW ACCELERATION, AND OVERHEATING OF THE BRAKES. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THE MECHANIC BELIEVED THERE WAS PROBABLY CONTAMINATION IN THE BRAKE FLUID, AS IT WAS MILKY. THE MECHANIC RECOMMENDED THAT ALL THE RUBBER COMPONENTS IN THE BRAKE AND ABS BE REPLACED DUE TO THE CONTAMINATION. *JB

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE WOULD DISPLAY AN INACCURATE READING. THE CONTACT MENTIONED THAT THE LOW FUEL GAUGE AND THE FUEL CAP WARNING LIGHTS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT TWO FUEL LEVEL SENSORS AND THE FUEL LEVEL SENDING UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11E009000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 146,800 AND THE CURRENT MILEAGE WAS 147,414.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING ASSIST WOULD INTERMITTENTLY FAIL WITHOUT WARNING AND THE VEHICLE WOULD BECOME INCREASINGLY DIFFICULT TO CONTROL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 15,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED THEN THE VEHICLE BECAME DIFFICULT TO STEER. THE CONTACT ALSO MENTIONED THAT THE IGNITION WARNING LIGHT SPORADICALLY ILLUMINATED AT VARIOUS SPEEDS AND THERE WAS AN ABNORMAL METAL ODOR IN THE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE STEERING COLUMN AND RACK AND PINION WAS REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE REAR BRAKE CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000. UPDATED 7/7/14*CN UPDATED 07/14/2014 *JS

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING 45 MPH, THE POWER STEERING WARNING LIGHTS ILLUMINATED AS THE VEHICLE BECAME DIFFICULT TO STEER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE WERE NO REPAIRS COMPLETED ON THE VEHICLE. THE FAILURE MILEAGE WAS 179,000 AND THE CURRENT MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE THE DRIVER TRAVELED APPROXIMATELY 50 MPH, THE STEERING WHEEL FAILED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A ROAD BARRIER. THE DRIVER SUFFERED INJURIES TO THE FACE, HEAD, HANDS AND EARS. THE POLICE WERE CALLED TO THE SCENE. THE VEHICLE WAS TOWED BY THE CONTACT'S INSURANCE COMPANY FOR FURTHER INSPECTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000. UPDATED 87/15/14*CN UPDATED 08/25/2014 *JS

I HAD JUST FILLED MY GAS TANK TO FULL. I DROVE DOWN THE STREET FOR A FEW BLOCKS AND THE FUEL GAUGE ALL OF A SUDDEN WENT TO EMPTY. I PULLED OVER TO THE SIDE OF THE ROAD AND TURN THE CAR OFF, THEN TURNED IT BACK ON AGAIN. THE FUEL GAUGE WENT BACK TO FULL. BUT AS I CONTINUED TO DRIVE DOWN THE STREET, IT WENT BACK DOWN TO EMPTY. I TOOK IT TO THE REPAIR SHOP AND WAS TOLD THAT I NEEDED TO REPLACE THE FUEL SENSOR FOR WHICH I DID. HOWEVER, UPON RESEARCHING THE LATEST RECALL OF GM'S THAT ADDRESSES THE STEERING COLUMN ISSUE (I'M HAVING THIS PROBLEM TOO), I DISCOVERED THAT THE FUEL SENSOR ISSUE WAS RECALLED PREVIOUSLY. SO I CALLED CHEVY AND WAS TOLD THAT MY VIN WAS NOT RECALLED. I NEED SOME DIRECTION/GUIDANCE ON HOW TO GET MY VIN INCLUDED IN THE PREVIOUS RECALL, IF AT ALL POSSIBLE SO I MAY BE REIMBURSED. IS THERE ANYTHING I CAN DO SINCE MY MALIBU ALSO EXPERIENCED THE SAME PROBLEM WITH THE FUEL SENSOR AS OTHER MALIBU'S? YOUR ASSISTANCE/GUIDANCE WOULD BE MUCH APPRECIATED. THANK YOU. *TR

WHEN SLOWING TO A STOP, THE STEERING IN THE VEHICLE GAVE OUT AND IT WAS NECESSARY TO SHUT OFF AND TURN THE VEHICLE BACK ON THE GET THE POWER STEERING TO WORK AGAIN. THROUGHOUT THIS PAST WINTER, IT FREQUENTLY LOST STEERING AT STOP SIGNS, STOP LIGHTS, AND WHEN MOVING AT LOW SPEEDS. *TR