2020 CHEVROLET SILVERADO 1500 Complaints

The contact owns a 2020 Chevrolet Silverado 1500. While driving at an undisclosed speed, the brakes failed to engage while the brake pedal was depressed. The message "Service Brake Assist" was displayed on the instrument panel. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The vehicle was taken to a dealer where it was diagnosed and determined that the brake master cylinder was leaking and needed to be replaced. The vehicle was repaired; however, the message "Service Brake Assist" was displayed on the instrument panel again. The manufacturer was notified of the failure. The failure mileage was approximately 101,593.

Vehicle was brought to Payne Chevrolet(Weslaco,Tx)for Recall N242454440. After the software update, the vehicle entered 'Limp Mode' and threw a Permanent Fault Code P2817 (Solenoid 8 Stuck Off). The dealership and GM Executive Resolution (Case #86918646) have confirmed this is a mechanical failure of the valve body, but are refusing/delaying the remedy due to a branded title. The vehicle is currently grounded and unsafe to drive as it risks rear-wheel lockup. GM has failed to provide a timely remedy or alternative safe transportation.

While driving home from work the truck displayed numerous trouble codes including ebc failure, braking failure, traction control failure and trailer brake failure as well as vehicle governed to 42 mph. I took it to the dealership and they checked all of the braking system and could not find any issues. They reset the codes, and changed all 4 pads and rotors as all 4 wheels were 1/32 out of true as a precaution. I drove it home about 5 miles with no issues. The next morning I was on my way to work and the codes reappeared with me being governed to 62 mph. At the stop sign I had no braking at all. Pumping the brakes resulted in no braking or pressure in the pedal. Luckily there was no traffic and I was able to use a hill to stop. I turned around and went the mile back to my house and was unable to stop again ending up with the front end in my neighbors yard. I had the vehicle towed back to the dealership where they still have not found a cause or a solution to the issue

I pulled up to a traffic light at a busy intersection in Lubbock, TX, and the engine just shut down on approach to a red light. The vehicle still had power (radio, headlights, AC/heater, etc.) but the engine would not start or even turn over and try to start. The vehicle was towed to a Chevy dealership in Lubbock, TX, and they said they believed it was an internal engine failure but wouldn’t be able to look at it for several weeks. I had it transported to my hometown in Taylor, TX, and my certified mechanic replaced the starter and battery solenoid but the engine still wouldn’t start. They drained the oil and found metal shavings in the oil. They too believe that the engine suffered a catastrophic failure and needs to be replaced.

The Timing Chain failed. It is at the Dealership available for inspection. Vehicle was unable to accelerate correctly while driving. If it had blown a valve or locked up the engine we would have been stuck on the highway with my kids in the vehicle. Problem has been confirmed with the dealer. It is a known defect with this vehicle but my VIN was not one that was recalled. No issues had came up before it failed. Just went to accelerate and you could feel it slipping and the truck stuttering forward.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving approximately 40 MPH, the contact stopped for a traffic signal, and the accelerator pedal was depressed when the light changed; however, the vehicle failed to respond. The contact stated that the engine was still running; however, the vehicle failed to respond while the accelerator pedal was depressed or the gear shift lever was moved. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a local dealer, where it was diagnosed, and determined that the Transmission Control Module needed to be re-flashed. The vehicle was repaired; however, the failure reoccurred. The contact had taken the vehicle back to the same dealer two more times for the same failure, however the vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.

The contact owns a 2020 Chevrolet Silverado. The contact stated that while the vehicle was parked, turned off, and unoccupied, the rear of the vehicle caught fire. The fire was initially extinguished by a maintenance worker, and the fire department later applied water to the area to prevent the fire from reigniting. The fire department was unable to determine the cause of the fire, and a fire report was not provided. The contact was unaware whether a police report was filed. The vehicle was not destroyed or towed. The vehicle was taken to a dealer, where it was diagnosed that the rear wiring harness had failed and needed to be replaced. The dealer also informed the contact that the rear bumper and tailgate were damaged as a result of the failure and would need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was not available.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle unexpectedly sputtered. There were no warning lights illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 73,000.

The component that failed was the wiring harness installed in the engine area. the harness was installed right next to a dip stick. The dip stick has a sharp metal piece welded to it and it punctured the harness cutting wires on the inside. This could have been a potential fire hazard. The problem was able to be reproduced, inspected and confirmed by a certified chevy mechanic at Philips Chevy in Frankfort, IL. The mechanic also showed me the failure point on the vehicle upon a visit. The dashboard lights were flashing randomly, headlights were very dim which it very difficult to see, android auto stopped working and not able to use hands free, so that became a safety issue, cruise control stopped working, and was receiving errors for a failed fuel pump.

What happened: In mid-December 2025, my 2020 Silverado 1500 (VIN: [XXX] ) suffered a catastrophic failure of the DEF Tank Assembly (P/N 84914535) at 29,354 miles—less than 30% of its warranted life. This is a latent design defect involving undersized terminal pins that suffer thermal degradation and melt the connector during high-amperage heater operation in arctic conditions (Ref: GM TSB 21-NA-006). Component Availability: The failed assembly is held at the dealership. I have submitted a "Part Preservation Request" to ensure it is available for forensic inspection by federal regulators. Safety Risk: The failure triggers an EPA-mandated "Limp Mode," initiating a software-forced reduction in speed. Unexpectedly losing speed on high-speed, icy Alaskan highways—where roadside snowbanks prevent safe egress—creates an extreme risk of rear-end collisions. Furthermore, a vehicle restricted to 5 MPH or rendered inoperable in temperatures of -30°F to -50°F poses a direct, life-threatening risk of cold-weather exposure in remote areas. Confirmation: Failure was confirmed by Lithia Chevrolet GMC of Fairbanks on Jan 7, 2026. GDS2 diagnostic verified DTCs P20B9, P20C1, P205D, and P204C. Data was reviewed by the GM District Manager of Aftersales (DMA) and GM Customer Assistance (Case #[XXX]). Warning Symptoms: Check Engine lamp and "Service Emission System" message appeared in mid-Dec 2025, followed by a "Speed Limited" countdown. The electrical disconnect was abrupt due to terminal pin melting, as documented in my forensic engineering report. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)