2020 CHEVROLET SILVERADO 1500 Complaints

Vehicle came to abrupt stop with no warning and no reason. There was not a vehicle in front of me, nor behind me when this occurred. If there had been a vehicle coming behind me there would have been a collision.

Complete brake system, master cylinder, pads, rotors. Only 75000+- miles. Morning start and the brakes are locked up. Had to get towed and the entire system needed to be replaced. So after several days and almost $5,000 I started driving home. After about 5 miles something fell off the front brakes and bounced along underneath but I was close to home so I continued and didn't need to apply the brakes until my driveway and then a terrible grinding sound. Called the dealer (Modern Chevrolet) Winston-Salem NC. Turns out the Einsteins who did the work forgot to tighten the bolts holding the rotor and one fell out and the other one was grinding against the wheel. So another extended stay at the dealership to correct this, a new wheel and correction to the brake components.

While stopped at a highway red light, the vehicle jolted forward and numerous dash lights came on, including messages saying “Brake System Failure, Service ESC, Service Trailer Brake, Service Parking Brake, Engine Power Reduced, Power Steering Reduced.” This is the first time any of these messages have ever appeared. This made the vehicle incredibly difficult to steer and the braking ability was almost non-existent. Had this happened one minute earlier or later, a multi-vehicle and potentially fatal accident would likely have occurred. Vehicle was towed to a dealer who confirmed the error messages and severely reduced performance. To me, this seems consistent with GM service bulletins PIT5730 and 20-NA-073. The dealer, however, is quoting me $3,700 to repair the master cylinder and electronic control braking module. Whatever the case, this absolutely needs to be upgraded to a recall before this happens to somebody at the wrong time.

My 2020 high country with a 6.2 l is 6 months away from the recall. Driving on the interstate with my family coming out of devil's Tower lost all power!!. I just replaced my motor at 60000 miles total engine loss catastrophic bearing failure!! This is the exact sameproblem from the 2021-2024 recall on the GMC 6.2liter

Vehicle sent alert on phone saying battery critically low, then the vehicle started having fuel gauge issue and started lurching. Shut the vehicle down saw a P129F in the alerts. Checked battery vehicle was a no start. Luckily near a shop so it wasn't catastrophic and was able to r eplace the fuel pump control module and it instantly started. This part NEEDS to be recalled it is a safety hazard that chevy does not aknowledge

Engine defect,I was driving down Claiborne ave.,and my truck just cut off while I was doing 50 mph with my daughter in the truck with me,an 18 wheeler came real close to running in the back of me,also my fuel door popped out,I brought it to West Bank gmc lagacy and got it fixed,this will be my 2nd time getting this same part fixed.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that the infotainment center intermittently went black, and there was water leaking into the vehicle through the top and lower center of the front windshield and the rear windshield. The vehicle was taken to a dealer, where the rear windshield was replaced without a diagnostic being performed; however, the failures persisted. Additionally, the side view mirrors intermittently failed to unfold when starting the vehicle. The contact stated that while driving approximately 40 MPH, white smoke emitted from the exhaust, the vehicle hesitated, and it lost power. The Check Engine warning light illuminated, along with "Service Electronic Stability Control", "Trailer Brake System", "Steering Assist Reduced", "Service Brake Assist", and "Brake System Failure" messages, and the vehicle failed to exceed 40 MPH. The vehicle was towed to a second dealer, Arcadia Chevrolet Buick (210 S Brevard Ave, Arcadia, FL 34266), where it was diagnosed that the lifter and torque converter had failed. The lifter and torque converter were replaced, and the system was flushed. Approximately 800 miles later, the engine failed again. The vehicle was towed to an independent mechanic, who diagnosed that the torque converter and transmission had fractured. The torque converter and transmission were replaced; however, the warning lights and messages illuminated again, and the vehicle continued to hesitate when driven over 42 MPH. After being parked for a few days, the warning lights were no longer illuminated and the mirrors opened, but the engine hesitation persisted. The vehicle was not further diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 10,000.

On July 22, 2026 took truck to dealership for oil change and reported getting random (trailer brake, power steering) service alarms. Was told it might be a ground strap issue and was sent on my way. After investigating, there is a GM service bulletin (#23-NA-201) on the issue but does not cover my truck. After a week of vacation, began driving truck again and alarms became more frequent, including loss of power steering and jerking of steering wheel while driving. Arranged with dealership to replace the ground strap (at my expense). By the time they could schedule, the alarms were constant and the truck had completely lost power steering. One of the power steering failures nearly resulted in an accident while turning.

Purchased used in 02/2022. Pickup started to shutter when shifting at 35-45 MPH. Took it to Turnpike Chevy who found thrust bearing in reaction carrier broken and damaged planetary gear set. They replaced the reaction carrier ASM and Reconditioned the transmission ASM. Replaced the valve body ASM. Took to John Sauder Chevy numerous times between July 19 2024 and July 7 2025 due to the shutter when shifting having returned. They tried the GM approved fix of flashing the computer to reprogram and kept saying they could not duplicate. On June 18, 2025 while towing a trailer on the highway while going highway speeds in the middle of rush hour traffic the transmission suddenly started making a shrill noise. Transmission disengaged and lost power. John Sauder Chevrolet found a broken oil pump drive and drive gears on the 10L80E transmission. GMC refused to replace the transmission and now it is out of warranty and starting shutter again when it shifts

Vehicle: 2020 Chevrolet Silverado 1500 4x4 LT (5.3L V8 Engine) Component: Engine (Piston Rings, Lifters, and Motor Assembly) / Powertrain Component Availability: Yes, the failed components/vehicle are available for inspection upon request. What Happened and Safety Risk: While operating the vehicle on Prince Street in Clovis, NM, the engine suddenly began knocking violently without any prior warning or symptoms. Immediately following the mechanical failure, dashboard warning lights illuminated (including the Check Engine light, ABS, and Traction Control) and the vehicle dropped into "Reduced Engine Power" mode. This caused an immediate and hazardous loss of acceleration on an active roadway, forcing an emergency maneuver to navigate out of traffic and pull over safely. This sudden powertrain failure poses an unreasonable and severe safety risk to the driver and surrounding traffic. Confirmation and Inspections: The mechanical failure has been confirmed and diagnosed by Hamilton Chevy in Portales, New Mexico, and Sanders Repair Services in Portales, New Mexico. The vehicle and components have not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, messages, or symptoms of any kind prior to the sudden failure.