2025 CHEVROLET SILVERADO 1500 Complaints

Component Affected: Visibility: Interior Trim / Entertainment Center Bezel Glare Description of Safety Hazard:The interior styling of the 2025 Chevrolet Silverado RST contains a design flaw involving the polished chrome trim strip located directly below the main central entertainment center/infotainment screen. Because of the angle of this specific trim piece relative to the driver's seating position, direct sunlight hits this lower screen border and reflects a concentrated, blinding glare directly into the driver’s eyes.This causes immediate, severe visual impairment and a temporary loss of forward visibility while driving. This distraction and blindness prevent the driver from safely observing the road and traffic, creating an imminent crash hazard. The manufacturer has failed to provide a non-reflective, matte finish for this specific entertainment center trim to prevent this hazard.

After having the original '25 6.2L GM L87 engine experience crankshaft bearing failure at approx. 5,700 mi, (previously reported to the NHTSA), the (brand new) replacement engine failed approx. 14,000 mi. later for the exact same reason, crankshaft bearing failure. In both incidents, the failure came 100% without warning, and the transmission LOCKED itself into park, leaving the vehicle and myself dangerously stranded in the middle of the highway; it had to be dragged on and off of the flat-bed tow truck both times.

On Thursday, July 9, 2026, at approximately 2:30 p.m., I was driving my 2025 Chevrolet Silverado 1500 Duramax on Highway 40 while towing a properly connected trailer. The Multi-Flex tailgate had been fully closed and latched before I began my trip and had not been opened at any point prior to the incident. While traveling on the highway, a California Highway Patrol officer pulled alongside my vehicle and alerted me that my tailgate was down and bouncing on the trailer I was towing. I immediately pulled over to the shoulder and observed that the entire Multi-Flex tailgate had unexpectedly unlatched and was resting on the trailer. I closed and latched the tailgate, which appeared to operate normally, and continued to my destination. At no time before or during the incident did the vehicle display a "Tailgate Open" warning or any other warning message on the instrument cluster. The unexpected opening of the tailgate caused it to strike the trailer, resulting in damage to the Multi-Flex tailgate, the rear bumper, and the trailer. The vehicle has approximately 11,000 miles, was purchased new, and has not been modified. I have opened a case with General Motors, and the vehicle is scheduled to be inspected by an authorized Chevrolet dealership.

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the rear liftgate independently opened while there was cargo loaded inside the bed of the vehicle. There was no warning light illuminated. The contact stated that while the vehicle was parked in the garage, after inspecting the vehicle the rear liftgate had independently opened, causing damages to the garage door. The vehicle was taken to a local dealer, where it was diagnosed; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 6,000.

My truck (2025 Chevy Silverado Trail Boss LZ0 Duramax 3.0l) started to have problems when driving. At a stop light, I started to accelerate at about 2000-3000 RPM. While doing so, there was a loud ticking/grinding noise coming from the transmission/Bell housing area. On June 2nd, I dropped the truck off with the dealership. I didn’t hear back from them until about a month later (July 3rd) and when I did they said the technician confirmed I needed a new ‘axle actuator’. About a week and a half later, they said it did not fix the issue and started to become more of a problem to where they will need an “engine technician” to see if I need a new engine due to the “crank shaft thrust bearing”. The advisor said he will call me on Wednesday, July 15th to update me on what I will need. I requested a Loaner vehicle since I dropped it off and they said no because the dealer does not provide that and would have to get approval from GM to grant me the loaner vehicle bast off the diagnostic.

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle was stalling. The message "Transmission Service" was displayed on the instrument panel. The dealer was contacted and diagnosed the failure as a shifter assembly failure. The vehicle was not repaired because the part was not available. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.

Tailgate unlatched while driving and all my items in the trunk fell out without me, knowing about it.

Leased a 2025 Chevy Silverado in late 2025. On June 13th 2026 driving home my vehicle all of a sudden had very little power, check engine light went on and thankfully I was at my driveway. Pulled into my residence, shut truck off and called the dealer I leased the truck from at 1:00 pm Satuarday, June 13th. They set me up with a loaner vehicle. I called for a tow truck Monday the June 15th and had truck delivered to dealership. Ive been told, they are looking into? Beyond that, nothing more.

My 2025 Chevy Silverado 1500 6.2L V8 experienced an internal engine failure at approximately 16,500 miles, requiring replacement of the entire long block under the factory powertrain warranty. The authorized Chevrolet dealership diagnosed internal cylinder wall scoring, and the engine could not be repaired. The failed engine should still be available for inspection if requested. About 4,000 miles after my last oil change, while the Oil Life Monitor still showed about 50% remaining, the vehicle repeatedly displayed "Engine Oil Level Low" warnings. I checked the oil level with the engine cold, and the dipstick showed the level was normal, so I believed the problem was a faulty oil level sensor. The next day, the warning changed to "Add Engine Oil," and I immediately took the truck to the dealership. The dealership confirmed the issue was not the sensor but internal engine damage caused by cylinder wall scoring, requiring replacement of the entire long block. Fortunately, the engine did not seize while I was driving, and no crash or injury occurred. However, before the failure was diagnosed, the only warning was repeated oil level messages that did not match the actual oil level. There were no abnormal engine noises, knocking, or noticeable loss of power. A driver could reasonably assume it was only a sensor issue and continue driving without realizing the engine had already suffered severe internal damage. If the engine failed while driving, it could create a serious safety hazard. Although GM replaced the engine under warranty, I remain concerned that a vehicle less than 16 months old with only 16,500 miles experienced such a major engine failure. I am also concerned that similar failures could occur after the factory powertrain warranty expires, leaving owners responsible for repairs that other Silverado owners have reported can cost approximately $13,000. I respectfully request that NHTSA investigate whether similar failures may also affect 2025 6.2L V8 model.

Date: June 22, 2026 Time of Incident: Approximately 11:48 a.m. Vehicle: 2025 Chevrolet Silverado High Country 6.2L V8 Current Mileage: Approximately 29,500 miles I am documenting the events surrounding the unexpected engine failure of my 2025 Chevrolet Silverado High Country. On June 22, 2026, at approximately 11:48 a.m., while driving at highway speed, the vehicle was operating normally with no warning lights, messages, or other indications of a problem. I began hearing a metallic clanking or knocking noise from the engine area. The noise progressively increased in volume and severity over approximately ten minutes as I reduced speed and looked for a safe location to pull over. My intention was to reach the dealership if possible; however, as I slowed to approximately 15 mph to make a turn, the noise stopped abruptly, the engine shut off, and the vehicle displayed a message instructing me to press the Start button again. The vehicle came to a complete stop at approximately 11:58 a.m. I attempted to restart the vehicle once, but it did not restart. No additional restart attempts have been made. There were no warning lights displayed prior to the engine shutting down, and there were no visible fluid leaks underneath the vehicle after it came to a stop. The vehicle received a routine oil change on June 16, 2026, approximately three days before this incident. I have retained the service receipt and all related documentation. The vehicle will be transported by flatbed tow truck to an authorized Chevrolet dealership for diagnosis and repair under warranty. This email is intended to document the incident timeline and details while they are fresh in my memory. I have not heard back from the dealer yet.