2011 CHEVROLET SILVERADO 1500 Complaints

Complete structural failure of chassis (Frame). Upon inspection on a mechanics lift the frame is cracked in several places and due to the undersized structural components and type of steel resulted in extensive corrosion. All components of vehicle depend on structural integrity of support frame. The frame has been inspected by several mechanics. All suspension components attached to vehicle frame are in serious jeopardy of failure. Several other Chevrolet truck owners have total losses of vehicle value to to undersized structural frame and extensive corrosion. This is a manufacturer's defect, its similar to building a house on a weak foundation.

The contact owns a 2011 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 21V050000 (Air Bags). The dealer was made aware of the issue but denied the recall repair due to the vehicle having a Salvage Title. The manufacturer was made aware of the issue and a case was opened. The contact was informed to have the DMV remove the branded title from the vehicle. The contact had not experienced a failure. Parts distribution disconnect.

FRAME IS SEVERELY RUSTED THROUGH. NEEDS TO REPLACED, TRUCK HAS BEEN GARAGE KEPT. WITH LESS THE 100,000 MILES ON IT.

The frame is completely rusted on this truck it has approximately 133k miles on it. In my research on this year truck there are many complaints for the same issue some through this site and others through forums. There needs to be a frame recall issued on this truck the approximate date below is when it was noticed during an inspection

I WAS DRIVING DOWN THE ROAD AND THE AIRBAG WENT OFF AND CAUSED ME TO CRASH INTO A POLE

Frame of truck rotted. Went to change shocks and it fell right off. Removed the bottom bolt on the shock and the 15 lbs shock fell to the ground with the top bolt still attached to the frame.2 years ago had to replace the the hitch due to rusted out Glad I was not pulling my 6000 lbs camper down the highway. The frame is so badly rotted it is unsafe to drive down the road. Not surface rust holes the inside of frame is rotted both sides. Unsafe to drive. Owned this truck for 9 years.

This vehicle has a frame that is rusted far beyond what you would normally expect. The same problem is listed in other complaints here and elsewhere online. The passenger side running board fell off because the frame it was attached to was so badly rusted.

TOOK VEHICLE TO DEALER TO GET AN ALINGMENT, THE DEALER SAID COULD NOT DO THE ALINGMENT BECAUSE FRAME WAS BROKEN, UNDER CLOSER INSPECTION FOUND OUT THAT FRAME IS RUSTED AND DETERATING IN MANY SPOT INCLUEDING REAR LEFT SECTION AND REAR RIGHT SECTIONS, ON LEFT NEAR FUEL TANK, CROSS RAIL FOR FUEL TANK, THAT ATTACH FUEL TANK TO VEHICLE, ALSO CROSS MEMBER THAT ATTCH SHOCKS ON REAR TO TO FRAME.

My 2011 Silverado has a very clean body, but the frame is completley rusted out. If you Google frame issues on these trucks you will see that many people are having the same issue and GM is doing nothing about it. I think GM should have to buy back these trucks as my truck went from being worth $12000 to being worth nothing

I had my truck in my shop after a lot of clunking started to come from the rear suspension. I had the truck up on the lift to check out the cause, and found very disappointing news. This truck has approximately 107,000 miles on it, and should not have this much compromised structure. The body is in near perfect condition. The vehicle has always been garage kept and clean. The entire rear frame of the truck has rust scale/perforation. Multiple areas are flaking badly and have holes that are 1/2" and larger. The rearmost cross member that attaches the upper shock is rotted out and missing. The other crossmembers are in poor condition. The areas of the frame where the leaf springs attach are thin. The only solution that seems feasible is a complete stripping, reinforcement, and/or replacement of the rear frame section. I own and operate my own shop, and have the ability to do this work for myself but there is no reason I should have to fix a truck that is 12 years old. Sadly, this is not the only GM product I have seen with this type of rot. It's just unfortunate that my personal vehicle has one of the worst frames that I have encountered.