2006 CHEVROLET SILVERADO 1500 Complaints

FRAME AND SUSPENSION COMPONENTS EXCESSIVE RUSTING TO THE POINT OF FAILURE. LEAF SPRING SHACKLE FAILED LAST YEAR, CAUSING LEAF SPRING TO PUT A HOLE IN TRUCK BED WHILE DRIVING. BRAKES LINES RUSTED TO FAILURE LAST WEEK AND CAUSED NEAR BRAKE LOSS WHILE OPERATING. HAD TO USE E-BRAKE TO AVOID HITTING MY GARAGE. CROSS MEMBERS SUPPORTING SHOCK FAILED. GAS TANK ABOUT TO FALL OFF DUE TO RUST FAILURE. CANNOT DRIVE TRUCK. BRAKES NO LONGER FUNCTION AND TRUCK IS UNSAFE DUE TO FRAME BEING COMPROMISED.

DRIVING MY CHEVY SILVERADO DOWN THE ROAD. HIT THE BRAKES FOR A DEER AND THE BRAKE PEDAL WENT TO THE FLOOR. SMOKE STARTED COMING OUT FROM UNDER THE HOOD. FLUID WAS ALL OVER THE ENGINE AND ON THE ROAD. FOUND THAT THE METAL BRAKE LINE BLEW OUT. TALKED TO 3 COMPANIES ABOUT REPAIRS. ALL THE LINES ARE ROTTEN. MINIMUM COST IS $500. ALL PLACES SAID THIS IS A COMMON PROBLEM WITH GM TRUCKS-EVEN THE DEALER SAID OH BRAKE LINES GO BAD ALL THE TIME ON VEHICLES OVER 10 YEARS OLD. I HAVE BEEN DRIVING FOR ALMOST 50 YEARS; OWNED AT LEAST 20 VEHICLES AND NEVER HEARD OF THIS HAPPENING. IN CASE YOU DON'T KNOW IT-BRAKES ARE PRETTY IMPORTANT! I WAS LUCKY. NO ONE WAS HURT. I WAS ON A BACK ROAD. I READ THAT GM USED LOW QUALITY MATERIAL FOR THEIR LINES. IF SO, IT SHOULD BE EASY TO BREAK IT DOWN AND VERIFY. WAS THIS METAL SUSCEPTIBLE TO CORROSION? THEY KNOW ALL THE CONDITIONS THAT THEIR TRUCKS WILL BE IN. HOW MANY MORE OF UNREPORTED ISSUES ARE THERE? SOONER OR LATER IT WILL BE PEOPLE'S LIVES THAT WILL BE LOST. THANK YOU FOR YOUR TIME.

WHILE DRIVING OR SITTING STILL HEADLIGHTS GO OFF FROM SECONDS TO MINUTES THEN GO ON OR UNTIL I PUSH THE DIMMER SWITCH SIDEWAYS NOT UP AND DOWN,THE DASHBOARD LIGHTS AND CLOCK GO OFF FROM SECONDS OR UNTIL I PUSH THE DIMMER LIGHT SWITCH SIDEWAYS NOT UP AND DOWN,THE ENGINE SUDDENLY QUITS WHETHER SITTING STILL OR DRIVING.

AT 45,000 MI. ABS BEGAN ACTIVATING, AT SLOW SPEED, WHEN STOPPING. ABS LIGHT WAS NOT LITE AND BRAKES WERE EFFECTIVE. BASED ON THE C0040 DIAGNOSTIC CODE, REPLACED RT FRONT HUB/ABS SENSOR ASSY. AT A COST OF $400. EVENTUALLY, ALL HUB SENSORS BEGAN GIVING FALSE INDICATIONS. WAS TOLD BY DEALER IT WAS ATTRIBUTED TO A DEFECTIVE DESIGN, BUT THERE WAS NO BULLETIN OR RECALL TO REMEDY THE PROBLEM. CANNOT AFFORD TO REPLACE ALL HUBS IF IT IS ONLY GOING TO HAPPEN AGAIN. GM SHOULD MAKE GOOD ON THESE REPAIRS.

MOVING BOAT IN MY YARD WHEN BRAKE PEDAL WENT TO THE FLOOR, USED EMERGENCY BRAKE TO STOP. BRAKE LINE TO LEFT FRONT WAS COMPLETELY SPLIT OPEN . LINE IS SEVERELY RUSTED IN SPOTS.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT IT NEEDED TO BE COMPLETELY REPROGRAMMED AND THE IGNITION CONTROL MODULE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO THE DEALER THREE OTHER TIMES, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 118,000.

LOSS OF BREAKS,RUSTED OUT BREAKLINES.PEDAL WENT TO THE FLOOR,NO BREAKS AT ALL! (SOMEONES GOING TO DIE)

BRAKE LINES ROTTED/RUSTED OUT ,FRONT TO BACK. FLUID LEAKED OUT EVERYWHERE. HAD TO DRIVE TEN MILES PER HOUR ,BUT MADE IT HOME FROM WORK SAFELY! ($950 REPAIR BILL). THANK YOU GENERAL MOTORS. MY NEXT TRUCK WILL BE A FORD. *TR

WAS DRIVING VEHICLE ON US 131 IN HOLLAND MI. I WAS TRAVELING AT APPROX 50MPH WHEN I HAD TO BRAKE FOR STOPPED TRAFFIC AHEAD. VEHICLE BEGAN TO SLOW WHEN SUDDENLY BRAKE PEDAL FELL AND I LOST MUCH OF MY BRAKING. HAD TO VEER OFF TO THE SHOULDER OF THE ROAD TO AVOID POSSIBLE COLLISION WITH STOPPED TRAFFIC. WHEN I PULLED OVER TO INSPECT MY TRUCK, I NOTICED FLUID DRIPPING FROM THE FRAME RAIL NEAR THE FUEL TANK. IT WAS BRAKE FLUID. THE BRAKE LINE THAT GOES FROM THE ABS UNIT TO THE REAR BRAKE HOSE WAS RUSTED THROUGH AND LEAKING. THIS IS A 10YR OLD TRUCK WITH ONLY 122000 MILES ON IT. I DON'T BELIEVE THIS TYPE OF FAILURE IS ACCEPTABLE FOR A VEHICLE OF THIS AGE AND MILEAGE. I WAS ABLE TO CAREFULLY DRIVE THE TRUCK HOME AND PARKED IT. I CONTACTED MY LOCAL DEALER SERVICE MANAGER, WHO COULD ONLY REPAIR IT AT MY EXPENSE. I GOT GENERAL MOTOR CUSTOMER ASSISTANCE # FROM HER AND CONTACTED THEM. THEY OPENED A CASE, #8-2572108769, AND SAID THEY ALSO WOULD DO NOTHING TO ASSIST IN THE REPAIR OF THIS CONDITION. THEY ARE LUCKY NOT TO HAVE A DEATH OR INJURY LAWSUIT ON THEIR HANDS. I'VE SEEN SEVERAL OTHER COMPLAINTS ONLINE FROM OTHER OWNERS OF THIS MODEL. THESE NEED TO BE RECALLED BEFORE SOMEBODY GETS KILLED. *TR

THE BRAKES FAILED WHILE IN MOTION. THE CAUSE WAS THE STEEL HYDRAULIC BRAKE LINE TO THE REAR WHEELS RUSTED AND BECAME TOO WEAK TO HOLD BRAKING PRESSURE. UPON FURTHER INSPECTION, ALL STEEL BRAKE LINES WERE VERY RUSTY.