2025 CHEVROLET SILVERADO 1500 Complaints

There is a reoccurring issue where vehicle will stop functioning bring up a error to service every component on the vehicle and is completely random when it occurs and dealers have not been able to replicate it after 4 visits

Turn signal sound intermittently fails along with all sound to the radio, phone, warning sounds, all audio feedback fails. GM is aware and does not have a fix.

6 weeks since purchase and only 2000 miles-engine suddenly made a horrible rattling noise and stalled. Towed to dealership and was told engine was dead and needed replacement.

I purchased the vehicle on 8-23-25. On 10-23-25 while driving my daughter to school I received a message on the dashboard that said "reduced acceleration mode drive with care." I immediately drove to the dealership. After a few hours I was told by the dealer that the diagnostic code of PO6DD "Engine Oil Pressure Control Solenoid Valve Stuck Off" had been recorded and a full engine replacement will be required. The vehicle has 3307 miles on it and has been at the dealership since. Engines for this vehicle are on back order and there is no timeframe available on when a new engine will be available.

While driving down IH10 in Boerne, TX on Oct 15, 2025, I saw smoke coming into the vehicle from the A/C vents. I immediately pulled over and put it in park, opened the driver door to get out and turned back to my truck to flames shooting out between the rear passenger side of the cab and in front on the bed of the truck. I had a UHaul trailer in tow and immediately unhooked it to get it away from the truck. I returned to my truck to retrieve my phone and proceeded to watch in desbelief as my truck and belongings went up in flames. It was fully engulfed within 30 seconds with no warnings from inside the truck while driving. Took firefighters over two hours to distinguish the flames fully.

The glass on the driver's side mirror fluctuates when driving at speeds above approximately 35 MPH. It gets more intense the faster the vehicle travels. It's very distracting and also causes the mirror to go out of adjustment. I have had the mirror assembly changed 2 times by the dealer I'm still having the same issue. I filed a complaint with GM. After I filed a complaint the dealer installed ballast on the back side of the glass for counter balance per GM Engineers. That still did not fix the problem. I feel this is a design issue with the mirror. I am not the only owner with this issue.

The vehicle was a service loaner provided to me but it was factory new with the sticker still on the window. The dealer told me they would still sell the vehicle as new. When I started it, I had a display screen that indicated it was in a Demo mode. Taking it out of Demo mode would have required me to confirm that I had purchased the vehicle. The volume control and power control for the audio were not working at all. The volume was probably at 30% where I could hear but not clearly and also just loud enough that I couldn't hear sounds outside the vehicle well. This condition was not affected by the audio source. I could no change the volume in Bluetooth, AM, FM, XM, or Phone modes. I also could not turn off or mute the audio by pressing the Power button. There was a responding fire truck behind me on the road and I went to turn off the audio to hear it clearly and I was not able to. I took a video of this condition happening multiple times as photographs don't help to demonstrate much. I did notify the dealer by sending the Service Manager a text message with the video and said he would notate the condition. This persisted through multiple days and multiple restarts. After approx. 4-5 days, the expected functionality returned with no action or updates that I am aware of.

At 5,750 mi. the 6.2 gas engine seized due to connecting rod bearings. The dealer replaced the engine, cooling system and oil cooling system under warranty with a similar engine. I am of the opinion that it could have been at least partly due to the low viscosity motor oil that the manufacturer insists upon to maintain the factory warranty, 0-W20 synthetic, along with a poorly engineered fuel management system. Also, once the vehicle was stopped and put into park, the electronically controlled transmission refused to change gears, to be put into neutral, in order to be pushed out of traffic and on to a tow vehicle, it had to be dragged. The vehicle is extremely unreliable and a danger to the public.

On the evening of August 27, 25, when exiting the highway ramp, the vehicle's engine suddenly stopped and stalled, the gear automatically shifted to neutral, and the hazard lights could not be turned on. After about 2 minutes, it restarted normally and turned on the hazard lights.

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a black screen and seized. The contact stated that occasionally the instrument cluster failed to activate. The vehicle was taken to the dealer, where it was diagnosed with instrument cluster failure. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were not available to repair the instrument cluster. The contact referenced an undisclosed recall; however, the VIN was not under recall. The contact stated that the failure started immediately after the vehicle was purchased. The contact had been waiting for delivery of the parts for two months. The manufacturer was made aware of the failure, and a case was filed. The contact stated that the manufacturer had been contacted more than twenty times. The failure mileage was approximately 2.