2022 CHEVROLET SILVERADO 2500 Complaints

Three of four original Goodyear Wrangler TrailRunner AT tires (DOT 0222) on my 2022 GMC Sierra 3500 have experienced catastrophic tread separations under normal use with 28,095 miles. The first two failed under warranty and were replaced at my expense; the third failed at highway speed, causing vehicle damage and a $1,000 insurance deductible plus additional cost to replace the tire. The dealership advised GM sent the failed tires for analysis, but GM denies receiving or reviewing them. Multiple NHTSA complaints describe identical failures on this same tire model (e.g., #11522434, #11482843, #11457647). This pattern indicates a potential widespread safety defect.

These tires are good year wrangler trail runner at size lt275/65 r20. My total mileage on these tires was 40970These were the original tires that were installed when the truck was purchased new. My tires are rotated every 5000 miles. Tire pressure is maintained at the exact pressure. I was driving on an interstate at 70 mph. A vibration started. I checked the tire pressure monitors and all showed normal pressures - I stopped and observed the tires were no longer round but had bulges to one side of the tread surface Both are likely to blowout and have to be replaced Two did this same thing in last 2 weeks

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

Tailgate going up and down on its own when in park. Now it will not open at all. There is a recall #N232426400 but dealership says it is not listed for my truck.

See recall N232426400 or customer satisfaction recall N232426401. My tailgate opens on its own and the button has quit working manually. My truck is apparently not a part of the recall?

After driving truck. Attempt to turn KEYED ignition off, they key will not move the the off position for removal. Must wait several minutes for the key lock mechanism to release then remove the key.

Vehicle was brought to Lone Star Chevrolet in Houston on 6/16/2025 because Tailgate would not open with the button and only would open with the fob. They stated no parts to fix and did not advise of the severity of risk from the recall when picked truck up. Saturday afternoon [XXX] while leaving a parking lot and driving on the feeder road the tailgate opened resulting in the large ice chest that was full of water bottles ice and and storage containers with food to fall on road along with battery power fan and several extra batteries. These items unexpectedly sliding down the feeder resulted in several cars making defensive maneuvers nearly resulting in several crashes and the ice chest bumping 1 vehicle. All lanes of traffic stopped and several people helped to pick up the debris off the road. No information from people who stopped was collected, and no report from driver of truck that hit cooler. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Service trailer brake system fault resulting in battery drain causing failure to strart

While towing our camper, the trailer brakes constantly turn off and on. The camper dealer already checked over the camper wiring, and hooked it to Ford and Ram tow vehicles and could not replicate the problem. The problem is obviously with my Silverado. For the additional details below; - The approximate date is Anytime and Everytime we tow the camper. - There could be a crash anytime the trailer brakes turn off. - A crash due to no trailer brakes Could cause a fire. - An injury or fatality would be highly likely if the trailer brakes "disconnect" at the wrong time causing a crash, with or without fire. - There would most certainly be a police report if any of the above happened.

So the electrical would be when I shut my truck off in park I cannot turn my key completely back to release the key so therefore I’m killing my battery leaving the power on as far as the tires they’re rated for 50 or 55,000 miles I have 37,000 miles and I have no tread left and as far as my drivetrain when accelerating onto a highway pulling my fifth wheel camper that is 16,000 pounds loaded the truck box really bad as far as the crash warning breaking system it does not break