2012 CHEVROLET SONIC Complaints

I purchased a 2012 Chevy Sonic with 65k miles on it from Carvibe LLC earlier this month. When I took it into Firestone for a full inspection, they found that the car has severe rusting to the mechanical parts along with the body of the vehicle - the entire structure of the vehicle is compromised. Someone spray painted the rust black but Firestone was still able to see the covered up rust. Firestone has deemed the vehicle unsafe to drive.

The contact owns a 2012 Chevrolet Sonic. The contact stated that on several occasions, while coming to a stop, the vehicle unexpectedly remained in second gear. There were no warning lights illuminated. The contact stated that several attempts were needed for the vehicle to shift into another gear. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for additional assistance. The failure mileage was approximately 77,000.

Transmission shaft malfunction. Doesn't shift out of 1st gear. Transmission does not engage into gear.

Reviving the p2138 code for throttle/accelerator sensor. Still getting code after replacing 3 accelerator peddles. Possible manufacture issue with wiring that water gets into connectors shorting out that system

The contact owns a 2012 Chevrolet Sonic. The contact stated that when the vehicle was turned on, the brakes, ABS, traction control, and braking system warning lights were illuminated. The contact stated while driving the vehicle at an undisclosed speed, the brake pedal was depressed; however, the vehicle took longer than normal to slow down. The contact stated that while the brake pedal was depressed, the vehicle jerked abnormally. The vehicle taken to a dealer where it was it diagnosed and determined that the brake booster pump assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 159,000.

The contact owns a 2012 Chevrolet Sonic. The contact stated while driving 75 MPH, the vehicle lost power. The check engine OBD reader had lost communication with the transmission. The contact merged to the side of the road. The contact then went to auto parts store and attempted to change the speed sensor; however, the parts store had given the contact the incorrect part. The dealer was contacted and informed the contact that the vehicle was already repaired under NHTSA Campaign Number: 14V315000 (POWER TRAIN). The vehicle had lost throttle and power. The contact then took the vehicle to an independent mechanic who diagnosed the vehicle and linked the failure to NHTSA Campaign Number: 14V315000 (POWER TRAIN). The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,000.

I purchased this car 2 years ago and it has caused me absolutely nothing but trouble. We have replaced the fan 4 times (twice due to the resistor thats part of the fan failed), headgasket job, intercooler punctures (once inward, once outward), failed valve cover, intake maniford, turbo seals twice, failing check values, new relays for the fan (twice), another drive belt, and now I go outside and theres a puddle of coolant under my car. I have sunk over $8,000 into this car and it has been the worst financial decision ever. Why do the parts keep failing? Why isnt there a heat gage in the dang car so I know its too hot before the light comes on?

The contact owns a 2012 Chevrolet Sonic. The contact stated that while a friend was driving approximately 35 MPH, the vehicle suddenly veered to the right and struck the curb. Upon inspection, it was discovered that the front passenger’s side suspension had failed. The vehicle was later towed to an independent mechanic who diagnosed that the front driver’s side suspension lower control arm had failed and needed to be replaced, along with the front axle and ball joints. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 111,000.

While driving on the highway late at night, at approximately 60 mph my 2012 Sonic began to lose power and slowed to a dangerously low speed when there was nowhere for me to pull over! I literally had to coast to a spot that I could barely squeeze off the road! Then would not shift into any workable gear but 1st and after that just revved up loudly. Long story short…had to be towed 35 miles home. Then towed to a reputable garage where they concluded the transmission was shot at about 90,000 miles. Would be around $3800. to rebuild. Come to find out these cars are known for this problem! And yet somehow I’m being told by GM that it’s not included in the Turbine Shaft Fracture Recall for that car’s year/make/model!! WHY?! Needless to say….the car will be junked!

We have had to deal with severe overheating issues and failing parts our entire ownership of this vehicle, both of which then cause other parts to fail, as the parts are so poorly made and heat sensitive. We have replaced the turbocharger (twice), intake manifold + valve cover (twice), catalytic converter, the radiator (THREE TIMES), the cooling fan (twice), the MAF sensor (twice), and much more. All of this has been done over the course of 18months. This has easily been the most expensive car we have ever owned due to the constant repairs, all of which has been because of Failing Parts and overheating.