2016 CHEVROLET SUBURBAN Complaints

While driving on the interstate in Nevada (speed limit of 80MPH) I had my 2016 Suburban throw a rod through the engine block as I was in the left lane passing a Uhual on an incline. The vehicle made a loud bang, lost all engine power and protruded smoke so thick I could not see cars behind me. I was thankfully able to coast to side of the road without being hit. I then exited vehicle and there was a fire in the engine bay which I put out with a gallon of water in the trunk. My mechanic confirmed the thrown rod and hole in the block and that the car needs a new engine now. I had a CEL a few minutes prior to throwing the rod for an engine knock.

Various times while I was driving my 5 kids have I had an issue with the brakes and having to over compensate to pump brakes to get them to stop in time or at all. Very scary

Loss of steering, jerks the week right out of your hand and then you are unable to turn the wheel. Engine stalls and you have to try to coast to the side of the road, put in park and try to restart the vehicle. Service Stabilitrak warning appears on display, Alarm Sounds, Radio beeps and display goes blank, navigation compass does not work. There is a current Technical Service Bulletin for these issues: #18-NA-161, document ID 5075841 that lists the years from 2014 to 2020. There were Product Safety Recalls issued: 17276 Loss of Steering Assist, Reference Number:N172085440 for vehicles listed in this TSB for 2014 and 2015 but no Recalls for later vehicles with the same problems.

The contact owns a 2016 Chevrolet Suburban. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard and made an abnormal humming sound. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the transmission was previously replaced 11/2021 and 11/2022. Additionally, the contact stated that there were only 3,000 miles within the two previous transmission replacements. The contact stated that the first transmission replacement was covered by the warranty company and the second transmission replacement was covered by the manufacturer. The contact stated that another replacement would be the third transmission replacement since 2021. The manufacturer was made aware of the failure and a case was filed. The contact was provided a Trade-In Offer. The failure mileage was 61,619.

The contact owns a 2016 Chevrolet Suburban LTZ. The contact stated that while driving on a neighborhood street at 25 MPH her transmission slipped into neutral. No warning lights were illuminated, and the contact proceeded to bring her vehicle to a complete stop, put the transmission into park, attempted to get into drive again however the vehicle remained in neutral and the RPM's shot up significantly. The vehicle was towed to a local dealer where the vehicle was diagnosed and the contact was advised that the transmission had failed and that it would need to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 80,000.

The contact owns a 2016 Chevrolet Suburban LTZ. The contact stated that while driving on a neighborhood street at 25 MPH, the steering wheel became increasingly stiff. She was able to continue driving until reaching her residence, where she parked the vehicle and attempted to restart it. Upon restarting, a message appeared on the instrument panel that read, "Service Power Steering." The local dealer was not contacted, so the vehicle was not diagnosed, and the manufacturer was not notified. The approximate failure mileage was 88,000.

Had the transmission replaced after 100,000 miles. Not even a year later the whole engine blew. With zero warnings lights or signs the engine gave 5 gallons of gas was in the engine along with other issues. We replace the engine and everything starts falling apart. Another $1,400 later it’s still throwing codes which come to find out the computer is now bad. Less the 300 miles have been put on the engine since it was replaced. Constant cam shaft sensors are going off causing the car to not run. $10,000 was put into it to have a running car and huge mechanical issues continue to happen with maybe 150,000 miles. Maintenance was done regularly. Zero issues prior to the transmission which thankfully was covered under warranty.

I replaced the shocks in Oct 2022 and paid for an alignment and now just over 2 years later the dealer said they needed replacing again. This front end has had constant problems, but now I see there was a recall on the 2016 Suburbans, but it is not listed under my VIN. I believe if they have had problems, possibly at another manufacturing, it should be considered that this is the problem. I have now paid for the repair of the upper control arm and both front shocks and a wheel alignment again. I paid more than double to have it repaired at the dealer because I believe my vehicle's VIN should be listed under NHTSA CAMPAIGN ID: 16V256000; REPORT DATE: APR 28, 2016.

On October 23, 2024, my 2016 Chevrolet Suburban was stopped in a line of traffic on a downhill. As traffic began to move forward, the brakes failed to hold, despite pressure on the brake pedal. This resulted in a low-speed collision with the vehicle in front, which then impacted another vehicle. Component/System: The braking system failed to engage despite pressure on the brake pedal. The vehicle is a total loss; however, documentation of the damage is available through my insurance company, New Jersey Manufacturers, claim number 2024-884575, and the police report from the accident scene. Safety Risk: This brake failure posed a significant safety risk to my family (who were occupants), and other drivers. The collision caused substantial vehicle damage. Confirmation: The vehicle has not been inspected by a dealer or independent service center due to it being a total loss. It has been inspected by my insurance company. Inspection: The vehicle has been inspected by police at the accident scene and by my insurance company. Warnings: There were no prior warning lamps, messages, or symptoms of brake problems. The vehicle has been consistently maintained by All American Chevrolet with all recommended services performed. This incident raises serious concerns about the vehicle's braking system integrity, especially given its consistent professional maintenance. I request an investigation into this matter.

The contact owns a 2016 Chevrolet Suburban. The contact stated while approaching a stop sign and driving at 5 MPH, the brake pedal was depressed and failed to respond. The brake service warning light illuminated after the failure. The contact was able to pull to the side, turn off the vehicle, wait a moment, and restart. The failure persisted and progressively worsened. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.