2005 CHEVROLET SUBURBAN Complaints

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 2500. THE CONTACT INSPECTED THE VEHICLE AND DETECTED A SHORTAGE WITHIN THE CIRCUITS UNDER THE DRIVER'S SIDE DASHBOARD, WHICH RESULTED IN THE WIRES BECOMING MELTED. THE MANUFACTURER WAS NOTIFIED AND RECOMMENDED THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

MY VEHICLE WAS MANUFACTURED WITH A DEFECTIVE FUEL PUMP. I HAVE HAD NOTHING BUT PROBLEMS WITH THE FUEL GAUGE AND DELAYED STARTS. I CHANGED THE PUMP AND NOTICED THE ORIGINAL PUMP WAS MISSING A SPRING ON ONE OF THE PUSH RODS. THE WEAR AND TEAR MADE THE PUMP HANG. I HAVE THE PUMP AND PHOTOS TO DELIVER. THIS PUMP IS A FLEX FUEL PUMP. THERE ARE SO MANY POSTS ON THIS DELAYED START ISSUE. I HAVE RECENTLY POSTED THE CAUSE OF MY ISSUE. I NOTICED THE DEFECT IMMEDIATELY BECAUSE I PERFORMED THE REPAIR AND NOT THE DEALER. THEY WERE QUICK TO OFFER ME A QUOTE FOR OVER A THOUSAND DOLLARS TO REPLACE A DEFECTIVE PART. *TR

WENT TO MOVE VEHICLE TO ATTACH LANDSCAPE TRAILER. BRAKES WENT DOWN TO THE FLOOR. UPON INVESTIGATION, FOUND BRAKE FLUID ON GROUND FROM DRIVER SIDE RIGHT FRONT. HAD VEHICLE TOWED TO REPAIR STATION AND ASKED MECHANIC TO REPLACE BRAKE LINE AND CHECK ALL OTHER BRAKE LINES. MECHANIC ENDED UP REPLACING 80% OF LINES DUE TO CORROSION. THIS COULD HAVE ENDED UP RESULTING IN AN ACCIDENT IF THE VEHICLE WAS MOVING WITH THE TRAILER ATTACHED CARRYING ATV'S. IN ADDITION, THE CABLE HOLDING THE SPARE TIRE HAD TO BE CUT IN ORDER TO GET ACCESS TO REAR BRAKE LINES. THE CABLE WAS RUSTED MEANING THAT A TIRE COULD NOT BE CHANGED IN THE EVENT OF A FLAT. *TR

EXHAUST MANIFOLD BOLTS BROKEN, TWO AT BACK LEFT, DRIVER'S SIDE CLOSEST TO FIREWALL. CAUSING AUDIBLE EXHAUST LEAK. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE SOCKET AND WIRES FOR THE REAR BRAKE LIGHT WERE MELTED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT NOTIFIED A PARTS STORE AND THEY STATED THAT THE PART WAS ON BACK ORDER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS AND ADVISED THE CONTACT TO CONTINUE LOOKING FOR THE PART. THE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE LIFTGATE FAILED. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO OPEN THE LIFTGATE FROM THE INSIDE OR THE OUTSIDE OF THE VEHICLE SINCE IT DID NOT HAVE A KEY ENTRY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.

SMELLED GAS IN GARAGE AND MOVED VEHICLE OUTSIDE GARAGE TO INVESTIGATE. FOUND PUDDLE OF GAS ON GARAGE FLOOR WHERE VEHICLE HAD BEEN PARKED. CRAWLED UNDER VEHICLE AND FOUND TWO BRAIDED FUEL LINES CROSSING EACH OTHER AND RESTING ON ONE ANOTHER. THEY HAD WORN A HOLE IN THE BRAIDED FUEL LINE AND WAS LEAKING A SUBSTANTIAL AMOUNT OF FUEL. TOOK TO LOCAL REPAIR SHOP FOR REPAIR. MECHANIC HAD TO CUSTOM REBUILD FUEL LINE TO AVOID CRISS-CROSS ROUTE ORIGINALLY INSTALLED. MECHANIC VERY CONCERNED WITH EXISTING DESIGN - PRESSURIZED BRAIDED FUEL LINE WAS SPEWING FUEL BENEATH VEHICLE. THIS APPEARS TO BE A COMMON PROBLEM AS A QUICK SEARCH ON HTTP://WWW.ABOUTAUTOMOBILE.COM/ UNDER "CONSUMER COMPLAINTS" FINDS QUITE A FEW RELATED INSTANCES WITH BOTH THE 2005 AVALANCHES AND SUBURBANS. REFERENCE COMPLAINT NUMBERS: 10465537, 10402272, 10384217, 10275857, 10417685, 10373464, 10401501. I DIDN'T SEARCH OTHER MODEL YEARS. *TR

HEATING, VENTILATION, AND AIR CONDITIONING BLOWER NOT FULLY FUNCTIONAL ON ALL BLOWER SPEEDS, RUNS CONTINUOUSLY WITH THE IGNITION OFF. DISCHARGES BATTERY WITH IGNITION KEYS REMOVED, AND HAS A BURNING SMELL. *TR

A/C SYSTEM WOULD RANDOMLY BLOW HOT AIR; THEN FAN WOULD RUN WITH IGNITION OFF; THEN FAN SPEEDS WOULD QUIT WORKING; FINALLY BLOWER QUIT ALTOGETHER. GM HAS 2 SERVICE BULLETINS OUT WITH EXACT PROBLEM DESCRIPTION, BUT THEY CLAIM MY VEHICLE NOT COVERED. *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE CRASHED INTO THE REAR OF A TRASH TRUCK. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM AND LEFT LEG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DEEMED THE VEHICLE AS BEING DESTROYED. THE MANUFACTURER WAS CONTACTED AND AFTER DIAGNOSING THE VEHICLE, THEY ADVISED HER THAT THE VEHICLE WAS NOT TRAVELING FAST ENOUGH AT THE TIME OF IMPACT FOR THE AIRBAGS TO DEPLOY. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.