2005 CHEVROLET SUBURBAN 1500 Complaints

I NOTICED CORRODED AND WHAT I WOULD CALL CHARRED OR BURNT WIRING ON THE WIRING HARNESS FOR THE REAR LIFT GATE OF MY SUBURBAN. I NOTICED IT WHEN I OPENED THE LIFT GATE TO GAIN ACCESS TO THE REAR OF THE SUBURBAN. IT APPEARS THAT THE RUBBER GROMMET MATERIAL PROTECTING THE WIRING HARNESS, WAS BURNT OR MELTED AWAY. THE RUBBER HOSE THAT SUPPLIES WATER TO THE REAR WINDOW WASHER/WIPER HAD A HOLE IN IT, AND MAY HAVE BEEN LEAKING WINDSHIELD WASHER FLUID ONTO THE WIRES FOR A TIME. THE WIRES WERE BARE IN SOME SPOTS, SOME OF THE WIRE INSULATION LOOKED MELTED/BURNT AWAY, AND THEY LOOKED CORRODED/WITH A GREEN COLOR TO THEM. THE CONNECTOR THAT CONNECTS THE HARNESS, TO THE REST OF THE ELECTRICAL SYSTEM, LOOKED LIKE IT HAS SOME BLACK/ POSSIBLY BURNT RESIDUE ON IT. I CAN TAKE A GUESS AT BEST, THAT BECAUSE OF THE HOLE IN THE RUBBER HOSE, WATER MAY HAVE BEEN LEAKING ONTO THE ELECTRICAL WIRING/CONNECTIONS WHEN I USED THIS FEATURE TO CLEAR DIRT FROM THE LIFT GATE WINDOW, BUT I DON'T REALLY KNOW FOR SURE IF THAT IS HOW THE DAMAGE TO THE WIRING HARNESS HAS OCCURED! THANKS!

I HAD A RUSTED BRAKE LINE (DRIVER SIDE FRONT) FAIL JUNE 25TH, 2017. THIS TRUCK IS 12 YEARS OLD AND HAS LESS THAN 90,000 MILES. IMMEDIATELY ALL BRAKING WAS LOST AND THE PEDAL PUSHED TO THE FLOOR. REPEATED PRESSING THE BRAKE ONLY PUMPED OUT ALL THE BRAKE FLUID. THIS WAS A SUDDEN AND CATASTROPHIC LOSS OF BRAKING. THE WORST PART IS, BRAKING IS SUPPOSED TO BE SPLIT AND INDEPENDENT BETWEEN FRONT AND REAR BRAKES, SO IF YOU LOSE THE FRONT, THE REAR BRAKES STILL WORK, AND VICE VERSA. WELL I LOST ALL BRAKING, I HAD NO FRONT OR REAR BRAKING! THIS SHOULD BE A CLEAR SAFETY PROBLEM AND A MANDATORY RECALL! I CRASHED INTO THE CAR IN FRONT OF ME, BECAUSE OF COURSE MY EMERGENCY BRAKE DIDN'T WORK EITHER. DESPITE GM'S INSISTENCE THAT SOMEHOW THIS PREMATURE BRAKE LINE FAILURE IS NORMAL AND THE OWNER'S MAINTENANCE PROBLEM, IT SHOULD BE A VERY SIMPLE ISSUE FOR THE NHTSA TO SIMPLY OPEN A SINGLE BRAKE LINE AND TEST TO REALIZE THE AFFECTED VEHICLES DO IN FACT LOSE ALL BRAKING, NOT JUST FRONT OR REAR. I'VE ALREADY COMPLETELY LOST FAITH IN GM TO DO THE RIGHT THING, BUT I'D LIKE TO BELIEVE THE NHTSA WILL STILL DO THE RIGHT THING, AND NOT LET GM OFF WITH A CLEAR SAFETY PROBLEM WITH THEIR BRAKE DESIGN. THIS CRASH WAS PULLING UP TO THE STOPLIGHT IN PRESCOTT, WI, HEADING INTO TOWN ACROSS THE PRESCOTT BRIDGE. I WAS DRIVING MAYBE 30 MPH WHEN I REALIZED I HAD LOST ALL BRAKES.

FOR APPROXIMATELY THE LAST 4 YEARS THE AIRBAG LIGHT HAS BEEN ON INDICATING AN ISSUE WITH THE AIRBAG SYSTEM. GIVEN ALL THE AIRBAG PROBLEMS IN RECENT YEARS AND THE FACT THIS SEEMS TO BE A COMMON PROBLEM WITH 2005 GM SUVS AND GIVEN AIRBAGS ARE VITAL SAFETY EQUIPMENT GM NEEDS TO PROVIDE OWNERS WITH THESE PROBLEMS A FREE FIX OR BE FORCED TO RECALL THESE VEHICLES IMMEDIATELY FOR REPAIRS BEFORE ALOT OF PEOPLE GET HURT OR KILLED.

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

I TURNED MY 2005 SUBURBAN ON AND THE AIR BAG LIGHT CAME ON. I TOOK IT IN TO THE CHEVY/GM DEALER WHO SAID, "THE RIGHT, FRONT, AIR BAG SENSOR WAS THE CAUSE." IT WOULD COST $375 TO FIX IT. I DID NOT GET IT FIXED AT THAT TIME. IT IS DANGEROUS BECAUSE THE AIR BAGS ARE INOPERABLE. THE PROBLEM OCCURRED AT ABOUT 150,000 MILES. FROM WHAT I HAVE SEEN THIS IS A HUGE PROBLEM THAT NEEDS TO BE ADDRESS BY THE COMPANY.

FIRST INCIDENT EASTERN PA: 05/19/2014 APROX 119000 MILES: AFTER HITTING THE BRAKES HARD TO AVOID A VEHICLE THAT PULLED IN FRONT OF ME, THE BRAKES FAILED (BRAKE PEDAL WOULD GO TO THE FLOOR WITH LITTLE BRAKING ACTION). MANAGED TO SAFELY STOP. FOUND BURST BRAKE LINE IN THE REAR END OF VEHICLE. TWO REAR CORRODED REAR BRAKE LINES REPLACED BY LOCAL REPAIR SHOP. SECOND INCIDENT MILFORD MA: 09/17/2015 127336 MILES: HIT BRAKES GOING DOWN DRIVEWAY. BRAKES WERE SOFT AND SANK TO FLOOR. BRAKE LINE GOING TO FRONT PASSENGER WHEEL WAS BURST. ALL THE BRAKE FLUID DRAINED QUICKLY OUT OF THE MASTER CYLINDER ONTO THE DRIVEWAY. ORDERED ACDELCO 22932592 GM ORIGINAL EQUIPMENT HYDRAULIC BRAKE PIPE KIT AND AM IN THE PROCESS OF REPLACING ALL BRAKE LINES AS ALL OF THEM OTHER THAN THE TWO REPLACED IN PA ARE VERY CORRODED. THE REPLACEMENT LINES ARE NOT REALLY OEM AS THEY HAVE A NYLON COATING FOR BETTER CORROSION PROTECTION

THE SPEEDOMETER NEEDLE BEGAN "CATCHING," NOT MOVING SMOOTHLY. AFTER ABOUT 2 WEEKS IT WOULD NOT RESET TO 0 WHEN STOPPED THEN AFTER 1 MORE DAY IT QUIT REGISTERING COMPLETELY.

HAD SERVICED THE TRANSFER CASE AND HAD TAKEN IT BACK TWICE NOW BESIDES A NOISE LIKE THAT OF A POWER STEERING PUMP GOING BAD ( WHINING ) , HAD A TURNING CLUNK NOISE COMING AND AT A STOP LIGHT I SAW SMOKE COMING FROM PASSENGER SIDE, GOT TO PARK IT AND SMELLED LIKE SOMETHING IS BURNING .BRING IT BACK TO SEE IF THE MECHANIC WILL WORK ON IT SINCE IT HASN'T BEEN 30 DAYS. PLEASE NOTIFY ME OF ANYTHING DO TO THE TRANSFER CASE. *TR

FRONT BRAKE LINE FAILURE/BRAKE LINE RUPTURE. 6 MONTHS AGO IT WAS THE REAR BRAKE LINE FAILURE/RUPTURE. BRAKE FLUID CAUSED SMOKE AND SMALL FIRE ON THE EXHAUST HEADERS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE GEAR SHIFTED INTO NEUTRAL INDEPENDENTLY. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE RESUMED IN THE FOUR WHEEL DRIVE MODE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE WHERE THE SHIFT GEAR ACTUATOR WAS REPLACED. ON A SEPARATE OCCASION, THE PUSH BUTTON GEAR SELECTOR WAS ALSO REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.