2001 CHEVROLET SUBURBAN 2500 Complaints

THE PASSENGER SIDE REAR DOOR WINDOW BREAKS WHEN THE WINDOW IS DOWN FOR NO REASON. I HAVE HAD TO REPLACE IT 4 TIMES IN THE LAST 60 DAYS. THERE APPEARS TO BE NO DAMMAGE TO ANY OF THE INSIDE OF WINDOW OR THE WINDOW REGULATOR. THE VEHICLE WAS STATIONARY AND MY DAUGHTER OPENED THE DOOR AND THE WINDOW BROKE.

DRIVING APPROX 50 MPH ON 4 LANE HIGHWAY. WHEN SLOWING FOR RED LIGHT AHEAD, NOTICED BRAKE PEDAL GOING CLOSER TO FLOOR THAN NORMAL. VEHICLE WAS NOT SLOWING AS NORMAL, AND BRAKE PEDAL WAS STAYING CLOSE TO THE FLOOR. GOT STOPPED AND PULLED TO SIDE OF ROAD. CHECK OF MASTER CYLINDER REVEALED BRAKE FLUID LEVEL TO BE APPROX. HALF FULL. UPON CHECKING UNDER VEHICLE, I SAW BRAKE FLUID POURING OUT FROM THE GAS TANK SHIELD. *TR

COMING TO A STOP LIGHT THE BRAKE PEDAL WENT TO THE FLOOR. ONLY WAY I COULD STOP WAS BY USING THE ELECTRIC BRAKES ON MY TRAILER TO STOP THE COMBINED VEHICLE. EXAMINATION REVEALED A RUSTED BRAKE LINE COMING FROM THE BRAKE MASTER CYLINDER TO THE ABS MODULE AT THE ABS MODULE UNDER THE VEHICLE. FURTHER EXAMINATION REVEALED THAT THE 4 BRAKE LINES FROM THE ABS MODULE TO THE WHEELS WERE ALL RUSTED/PITTED AND ABOUT READY TO RUST THROUGH. *TR

I HAVE OWNED MY 2001 CHEVY SUBURBAN SINCE JANUARY OF 2008. I HAVE REPLACED THE FUEL PUMP 3 TIMES AND TODAY WILL BE MY 4TH. I HAVE SPENT THOUSANDS OF DOLLARS ON THE SAME PART OVER AND OVER. THE LAST TIME IT WAS REPLACED MY MECHANIC ADVISED US TO KEEP AT LEAST 1/4 TANK OF GAS IN THE TANK WHICH I HAVE TRIED TO DO. BUT EVEN DOING THIS THE FUEL PUMP SEEMS TO GO ABOUT EVERY 15 MONTHS, JUST OUTSIDE THE WARRANTY. ITS RIDICULOUS, THERE IS NO WAY I SHOULD BE REPLACING FUEL PUMPS AT THIS RATE. *TR

BRAKE PEDAL WENT TO FLOOR. WAS ABLE TO STOP WITH EMERG BRAKE. DEALER SAYS ALL BRAKE LINES ARE RUSTED OUT AND MUST BE REPLACED $2000. *TR

WIFE WAS DRIVING ON THE FREEWAY IN OUR SUBURBAN AND THE ENGINE SHUT OFF WITHOUT WARNING. SHE HAD TO COAST OVER 5 LANES OF TRAFFIC AND GET INTO THE EMERGENCY LANE. TRUCK STARTED AFTER 4 ATTEMPTS AND WORKED FINE FOR 2 MORE DAYS. IT THEN DIED 2 MORE TIMES IN ONE DAY WITHOUT WARNING. IT AGAIN STARTED FINE AFTER 4 TO 5 ATTEMPTS. THE CRANKSHAFT POSITION SENSOR IS DEFECTIVE AND THERE WAS A RECALL OF OTHER 2001 MODELS WITH THE 8.1L BUT IT DID NOT INCLUDE MY SEQUENCE. THIS PART IS FAULTY AND PUT MY WIFE'S LIFE IN DANGER. THEY SHOULD RECALL ALL 8.1L CRANKSHAFT SENSORS. THIS IS A ISSUE AND THERE ARE TONS OF THREADS ON MESSAGE BOARDS ABOUT THIS ISSUE. *TR

MY SON WAS DRIVING MY 2001 SUBURBAN AT 45 MPH. A CAR RAN THE RED LIGHT AND CLIPPED THE FRONT DRIVERS SIDE OF MY SUBURBAN CAUSING MY TRUCK TO FLIP, SKID A 1/2 MILE ON IT'S SIDE DOWN THE STREET AND THEN HIT A ELECTRIC POLE BEFORE IT CAME TO REST. NONE OF MY AIR BAGS DEPLOYED!!! *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE OCCURRED THREE DIFFERENT TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS, WHERE THE TECHNICIANS STATED THAT THE CRANKSHAFT POSITION SENSOR NEEDED TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. UPDATED 11/17/11 *BF UPDATED 11/23/11. *JB

WHILE TOWING MY TRAVEL TRAILER BACK FROM A TRAILER INSPECTION I NOTICED THE BRAKE ON MY 2001 CHEVY 2500 SUBURBAN FOR UNCOMFORTABLY CLOSE TO THE FLOOR. UPON ARRIVAL AFTER SLOWLY LIMPING HOME USING MOSTLY THE TRAILER BRAKES I FOUND THAT A REAR BRAKE LINE HAD RUPTURED AND THE REAR MASTER CYLINDER TANK WAS EMPTY. A LOCAL AUTO SHOP CUT THE LINE AND ADDED A NEW SECTION. PER THE MECHANIC THE RUPTURED LINE IS RUSTED ALONG WITH THE ADJACENT LINES. THE CUT OUT SECTION WAS THROWN OUT BEFORE I COULD SAVE IT. *TR

WIPER MOTOR FAIL. 2001 SUBURBAN 6.0L V8. WIPER MOTOR FAIL. THE WIPER MOTOR IN MY TRUCK ALWAYS FAILS. THE LAST TIME IT FAILED WAS SEPTEMBER 27TH 2010 DURING A HEAVY RAIN STORM. TO MAKE A LONG STORY SHORT I ALMOST RAN OVER A PEDESTRIAN, AND ENDED UP ON THE SIDEWALK. (TECHNICALLY THAT IS A CRASH) THE WIPER MOTOR JUST STOPPED WHILE IT WAS RAINING. LAST YEAR DURING HEAVY SNOW THE MOTOR FAILED AGAIN. I HAD TO PULL OVER FOR AN HOUR UNTIL THE STORM WAS OVER. NOT TO MENTION NUMEROUS OTHER TIMES AS WELL. THIS MOTOR FAILS A LOT I LOST COUNT. THE EVENTS THAT LEAD UP TO THE FAILED WIPER MOTOR ARE RAIN , SNOW, SLEET, SOMETIME THE MOTOR FAILS DURING A SUNNY DAY AND NO MOISTURE IN THE AIR OR FAILED JUST TO CLEAN YOUR WINDOW. NOTHING HAS BEEN DONE TO CORRECT THE WIPER MOTOR FAILURE BECAUSE IT'S TOO EXPENSIVE FOR ME; GENERAL MOTORS SHOULD FIX THIS SERIOUS PROBLEM BEFORE SOMEONE GET KILLED. *TR