2003 CHEVROLET TAHOE Complaints

GETTING ON AN INTERSTATE RAMP I APPLIED MY BRAKES TO REDUCE MY SPEED. AS I APPLIED MY BRAKES IN A NORMAL MANNER TO SLOW DOWN, MY BRAKE PEDAL SANK ALL THE WAY DOWN TO THE FLOOR. THE TRUCK WOULDN'T SLOW DOWN OR STOP. I BROUGHT THE TRUCK TO A STOP MY DROPPING DOWN IN GEAR AND APPLYING THE PARKING BRAKE. I PULLED THE TRUCK OVER TO THE LEFT SHOULDER (ONLY SHOULDER AVAILABLE ON THIS RAMP) AND STOPPED. I OPENED THE HOOD AND LOOKED IN THE ENGINE COMPARTMENT AND CHECKED MY BRAKE FLUID. DIDN'T SEE ANY PROBLEMS FROM THAT ANGLE. I CHECKED AROUND THE TRUCK AND NOTICED LEAKAGE OF WHAT APPEARED TO BE BRAKE FLUID COMING OUT FROM THE FRONT, PASSENGER SIDE. I CALLED FOR A TOW TO MY PREFERRED SERVICE SHOP. AFTER A DAY MY MECHANIC CALLED AND SAID THAT ONE OF MY BRAKE LINES WAS FULLY RUSTED, HAD BUSTED AND WAS LEAKING. HE SAID THAT UPON INSPECTION OF THE REST OF MY BRAKE LINES, THEY WERE ALL VERY RUSTED AND IN DANGER OF ALSO BUSTING OPEN. HE RECOMMENDED IMMEDIATE REPLACEMENT OF ALL BRAKE LINES AT A COST OF MORE THAN $2,200.00. THIS VEHICLE IS LESS THAN 11 YEARS OLD. IN ALL MY YEARS OF DRIVING, NEARLY 40 YEARS, I'VE NEVER SEEN A VEHICLE WITH RUSTED THROUGH BRAKE LINES AT THE 11 YEAR MARK. I BELIEVE THE DESIGN IS FLAWED AND THAT USING STEEL (CORROSIVE) VERSUS A NON-CORROSIVE MATERIAL SUCH AS STAINLESS STEEL IS A "CUTTING CORNERS" TECHNIQUE WHICH PUT DRIVERS AT RISK AND INTO LIFE THREATENING SITUATIONS TO THEMSELVES ON ONTO OTHERS. I'D LIKE TO REQUEST THAT GM BE REQUIRED TO ISSUE A RECALL ON THIS ISSUE AND THAT OWNERS OF THESE VEHICLES ARE EITHER OFFERED A NO COST REPAIR FOR THE ENTIRE BRAKE SYSTEM OR FULL REIMBURSEMENT FOR REPAIRS MADE TO THEIR VEHICLES TO CORRECT THIS CLEARLY DANGEROUS FLAW. *JS

BACK SEAT BEHIND THE DRIVER WILL NOT RELEASE TO LAY FLAT. WE HAVE HAD MECHANICS LOOK AT AND ONLY ONE WAS ABLE TO GET IT TO RELEASE. AS LONG AS THE SEAT IS PUT GENTLY BACK INTO UPRIGHT POSITION IT WILL WORK. HOWEVER, IF IT IS NOT, IT WON'T BUDGE. AT THIS POINT IT WILL NOT RELEASE. THE OTHER SEAT WORKS OKAY FOR NOW BUT WE ARE CONCERNED IT MAY DO THE SAME. WE BELIEVE THIS IS A SAFETY ISSUE. IN AN EMERGENCY WE WOULDN'T BE ABLE TO GET PEOPLE OUT OF THE THIRD SEAT. HAS THERE BEEN A RECALL TO FIX THE PROBLEM? WHAT CAN BE DONE ABOUT THIS? THANK YOU FOR WHATEVER HELP YOU MAY HAVE. *TR

AS I APPROACHED A TRAFFIC LIGHT IN TOWN AND PREPARED TO STOP, THE BRAKE PEDAL SUDDENLY AND WITHOUT WARNING, WENT TO THE FLOOR. I MANAGED TO USE THE PARKING BRAKE TO STOP THE VEHICLE WITHIN INCHES OF THE CAR STOPPED IN FRONT OF ME. THE WARNING LIGHT ON THE DASH ILLUMINATED INDICATING A BRAKE SYSTEM FAILURE. IT HAD NEVER COME ON BEFORE. ONE OF THE STEEL BRAKE LINES RUNNING ALONG THE FRAME, APPROXIMATELY UNDER THE DRIVERS DOOR, HAS RUSTED THROUGH AND BURST. IT WAS A MIRACLE THIS DID NOT RESULT IN A CRASH. HAD THIS HAPPENED AT A HIGHER SPEED OR EXITING A FREEWAY RAMP, I FEAR THE OUTCOME WOULD HAVE BEEN VERY BAD. *TR

THE DRIVER SIDE MIRROR HAS STARTED DISTORTING AND LEAKING A BROWN LIQUID SUBSTANCE. IT HAS DISCOLORED THE PAINT ON THE SIDE OF THE VEHICLE AND THE STEP BAR. OBJECTS APPEAR DISTORTED/DOUBLED AND MIRROR HAS A HAZE TO IT. *TR

BRAKE LINES ARE COMPLETELY RUSTED OUT, AND FUEL LINES, WHOLE UNDERCARRIAGE IS BAD, BRAKE LINES FAIL WITH NO WARNING, BRAKE PAD GOES TO FLOOR. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED WHILE DRIVING 35 MPH AND ATTEMPTING TO STOP THE VEHICLE BY APPLYING THE BRAKE PEDAL THE BRAKE LINE BROKE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THERE WAS EROSION ON THE BRAKE LINES AND THEY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000. THE CURRENT MILEAGE WAS 143,050.

I WAS SITTING AT A DRIVE THROUGH WAITING FOR FOOD. SUDDENLY WITH MY FOOT ON THE BRAKE PEDAL, IT STARTED GETTING A MUSHY FEELING AND THE PEDAL SANK TO THE FLOOR. WHEN I GOT IT HOME, I FOUND THERE WAS A LEAK IN ONE OF THE FRONT BRAKE LINES WHICH WERE RUSTED PRETTY BADLY. THE NEXT MORNING, I TOOK THE TRUCK IN TO GET THE FRONT BRAKE LINES REPLACED FOR JUST OVER $300. THE REAR ARE RUSTED PRETTY BAD BUT MY AUTOMOTIVE SHOP SAID THEY USUALLY DON'T REPLACE THEM IF THEY AREN'T LEAKING. I WAS VERY FORTUNATE TO NOT BE DEAD OR INJURED (ALONG WITH ANYONE ELSE) AS I WAS ON THE HIGH WAY EARLIER THAT NIGHT AND DRIVING AROUND QUITE A BIT. I HEARD THERE WAS AN OPEN INVESTIGATION ON THIS ISSUE, SO I WANTED TO OFFER MY EXPERIENCE AND INQUIRE ON WHY THE INVESTIGATION IS STILL OPEN AND NO RECALL HAS BEEN ISSUED? IT SEEMS LIKE SOMETHING SO CRUCIAL TO SAFETY SHOULD BE EITHER MORE PROTECTED OR BE LESS PRONE TO RUST, EVEN IN THE SNOW BELT WITH ALL THE CORROSIVE SALT ON THE ROADS. THIS IS SOMETHING THE CAR MANUFACTURERS MUST ACCOUNT FOR. *TR

THE 2003 CHEVROLET TAHOE WAS DRIVEN ON U.S. HIGHWAY 10, IN MINNESOTA, FOR APPROXIMATELY FIFTEEN MINUTES ON THE INCIDENT DATE. THE TAHOE WAS TAKEN HOME AND, AS IT WAS PARKED, THE BRAKE LINE TO THE PASSENGER SIDE FRONT BRAKE ASSEMBLY RUPTURED. IT'S INTERESTING THAT THE TAHOE BODY AND DRIVETRAIN IS IN GOOD CONDITION, NOT MUCH BODY RUST FOR IT'S AGE, BUT ON FURTHER INSPECTION IT WAS DISCOVERED THAT EVERY BRAKE LINE HAS HEAVY RUST ON IT. I DON'T KNOW THAT I WILL BE ABLE TO AFFORD THE REPAIR OF THIS TAHOE. IT IS UNFORTUNATE THAT CHEVROLET USED INFERIOR MATERIALS IN THE PRODUCTION OF THE TAHOE'S BRAKE SYSTEM...THE MOST IMPORTANT SAFETY SYSTEM ON THE VEHICLE. BUT, ALSO, IT'S A SHAME THAT NHTSA HAS TAKEN SIX YEARS TO "STUDY" THIS PROBLEM AND HAS NOT DRAWN A CONCLUSION OR FORCED GM TO DO A RECALL? IT'S GOVERNMENT BUREAUCRACY AT ITS BEST...WHAT A SHAM. *TR

VEHICLE PARKED IN MY DRIVEWAY, ATTEMPTED TO PULL OUT OF DRIVEWAY AND HAD NO BRAKING ABILITY (7/12/12) ALL FRONT BRAKE LINES REPLACED DUE TO RUST. THEN ON 2/11/14, HAD LEFT UM HOSPITAL WITH WIFE, NOTED SOMETHING WAS NOT FUNCTIONING PROPERLY WITH BRAKES BUT CONTINUED TO A RESTAURANT. WHEN I GOT OUT OF RESTAURANT, ATTEMPTED TO PULL OUT FROM CURB AND HAD NO BRAKES. ALL REAR BRAKE LINES HAD TO BE REPLACED DUE TO RUST. BOTH OCCASIONS REQUIRED A FLATBED TOW TRUCK FROM AAA. TOTAL COST FOR REPAIRS WAS $2050.74. *TR

I OWN A 2003 CHEVY TAHOE! MY SPEEDOMETER JUST STOP WORKING ONE DAY WHEN DRIVING. IT WILL STICK ON A 120 OR 35 OR SOMETIMES IT WONT MOVE AT ALL. I DO HAVE A PICTURE OF BEING PARKED AND TAHOE SHUT OFF AND ITS SHOWING 120. SOMETHING NEEDS TO BE DONE..PEOPLE CAN'T AFFORD TICKETS FOR GOING OVER AND UNDER SND I ALSO HAVE THE TOW PKG AND OWN A POP UP AND REALLY SCARED TO TRAVEL WITH IT. CANT AFFORD THE 600 THEY IT WILL COST..CANT GET INTO A NON CHEVY. THIS IS MY FIRST CHEVY I BOUGHT AND THINK IT WILL BE MY LAST. .GM STEP UP AND GET THIS RECALLED. *TT