CHEVROLET Complaints

While I driving in the past week, a warning that "propulsion power reduced" appeared on my dashboard several times. The last time that I had driven the car, the heater would not turn off, and the smell of burnt rubber filled the car and then dissipated soon after. The car would only run in it's gas engine mode, and not switch over to electric mode, as it usually would. The next morning, the car would not start. The dash board would light up as if the car started, but when I shifted into drive, a warning appeared on the dash, "Shift to park", as it would when the car is not running. I could not start the vehicle. After plugging the vehicle in, a warning appeared on the console stating that "Charging is not available". The car was towed to the dealership. Their diagnosis showed that the Battery Energy Control Module had failed and must be replaced. They later confirmed that an electric cable needed to be replaced that was "corroded", but they could not confirm the cause of the corrosion because the cable was disposed of already. After researching online, I found that GM issued a Special Coverage bulletin: N232432680, citing a common malfunction of the Battery Energy Control module in 2016 to 2018 Chevy Volts that "causes a reduced power mode, a no start condition, or a no charge condition." The Special Coverage was to extend the warranty to 15 years or 150,000 miles. After inquiring the dealer about the Special Coverage, they claimed that our car is not covered under the warranty. After calling customer service, they claimed the coverage comes from NHTSA, and GM only issues orders by VIN, and therefore cannot cover the issue. After calling NHTSA, I was told the special coverage is not a national recall, and is internal to GM. The GM dealership still claims that the control module on our car is not covered under the warranty, and have denied the request for a manager inspection or investigation.

For the third time, my windshield wipers quit working in the middle of a rain/snow storm. Have taken the vehicle into GM service under warranty twice, the first time they updated the software but that repair only lasted a few months. Second time they replaced the windshield sensor, that lasted a few months. Now today, driving home in the snow my wipers quit working altogether. The sprayer worked, the rear wiper on the same handle works, but nothing else I could do gets the wipers to work. This is a big safety concern as it has happened all while driving in I climate weather.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle unexpectedly sputtered. There were no warning lights illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 73,000.

My vehicle experienced a brake system failure that rendered it unsafe to drive and required it to be towed to the dealership. I have been informed by the dealer that the issue involves a failure of the left rear brake caliper. The vehicle is currently out of service at the dealership. Because this issue affects the braking system, it is a significant safety concern.

We have a water leak that was coming in both windows and onto the floor. Since reported it the car will slow down while driving because of codes issues about the doors are not closed and it is. I feel it's due to the water leak that is coming into the car. Took the car to a Chevrolet Dealer in Columbia South Carolina and they said it was coming from the roof weather stripping. They said it wasn't a recall for the 2020 C8 Corvette corvette yet. Also called GM Customer care to see if I can get some help to get it fixed. No luck.

Brake pedal bolt came loose and fell off. Brake pedal was difficult to use. There was a recall for this issue on 2015-2016 2500 and 3500 series trucks but not 1500 series. I have a video of the brake pedal condition but it will not let me upload it.

I just purchased the vehicle there was an open recall that was never taken care of. I took it to the dealership and the front exhaust pipe is cracked and leaking which was the original recall

Engine is running low on oil all the time. took it to dealer they said, there is sludge build up. Found oil fouling on CYL 3 and and found Spark plugs with excessive oil no external leaks found recommend new engine

The contact's father owns a 2024 Chevrolet Trax. The contact stated that while driving at an undisclosed speed and making a left, she observed a noise emanating from under the vehicle that sounded like loose gravel, and she observed smoke outside of the "turn off ignition" message displayed. The contact stated that she observed white/grey smoke coming through the vents in the cabin of the vehicle. The vehicle was turned off, and when the contact exited the vehicle, she observed fire under the engine compartment, and the fire spread rapidly. The fire department distinguished the fire. The police reported the incident, but there was no report taken. The vehicle was towed to an independent mechanic, where it was deemed inoperable. The manufacturer was notified of the failure. The failure was 7,696.

Battery Energy Control Module Malfunction. It is a known issue with this system failing on the chevy volt. There is a service bulletin on this problem. 18-NA-261 is the service bulletin. The car will not start and when it does start it has loss of power while driving. Chevy is only fixing certain VIN numbers even thou it pulls up the same codes in their bulletin. Chevy only gave extended warranties to certain VIN numbers also. Extra warranty bulletin N232432680. This is a major component for the high voltage battery which drives the vehicle. The dealership wants $5000.00 to repair this.