2004 DODGE CARAVAN Complaints

THE VEHICLE WAS STATIONARY. I WAS LEAVING WORK, WHEN I SAT IN THE DRIVER'S SEAT THE SEAT BROKE AND FELL BACK. THE BROKEN PART IS ACTUALLY THE FRAME OF THE SEAT, NOT THE TILT MECHANISM. THE TUBULATION THAT COMPRISED THE SEAT FRAME CATASTROPHICALLY BROKE ADJACENT TO THE WELDMENT. THIS PART SHOULD NEVER FAIL.

ENGINE OFTEN HESITATES AFTER YOU HAVE DRIVEN A FEW BLOCKS AFTER REFUELING. THIS FORM ASKS FOR A SINGLE SPECIFIC DATE BUT THIS PROBLEM HAS HAPPENED EVERY FEW WEEKS FOR THE LAST YEAR OR SO. DEPENDING UPON THE TRAFFIC SITUATION WHEN THE HESITATION OCCURS, AND ACCIDENT COULD EASILY OCCUR. MY MECHANIC SAYS THAT THE LIQUID/VAPOR SEPARATOR VALVE ON THE GAS TANK IS NOT OPERATING PROPERLY. THIS VALVE IS A PART OF THE TANK AND CANNOT BE REPLACED AS A SEPARATE ITEM, SO THE COST OF THE REPAIR IS SUBSTANTIAL. A BRIEF SEARCH ON THE INTERNET INDICATES THAT MANY OTHER OWNERS OF DODGE CARAVANS MANUFACTURED BETWEEN ABOUT 2004 AND 2007 ARE REPORTING THIS SAME PROBLEM.

2004 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO FUEL TANK EXTENDED WARRANTY COVERAGE THAT APPLIES TO VEHICLE STALLING AFTER REFUELING. *SMD THE CONSUMER STATED THE VEHICLE BEGAN STALLING SHORTLY AFTER IT WAS PURCHASED AND HAS SINCE CONTINUED. THE STALLING OCCURRED AT HIGHWAY SPEEDS AND WHILE MAKING LEFT TURNS. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER REPLACED THE EGR SENSOR.*JB

INTERMITTENT HORN TURNING ON. CLOCKSPRING WAS REPLACED ALONG WITH FRONT CONTROL MODULE. THEY THINK HORNPAD IS AT FAULT AND WILL FURTHER SHORT CLOCKSPRING AND FRONT CONTROL MODULE

THE AIRBAG WARNING LIGHT IS ILLUMINATED DUE TO A MALFUNCTIONING CLOCKSPRING. THIS DISABLES THE AIRBAG SYSTEM. THIS WAS RECALLED ON EARLIER MODEL CARAVANS BUT HAS NOT BEEN COMPLETED ON 2001 AND NEWER MODELS WHICH HAVE THE SAME ISSUE. THE LIGHT HAS BEEN ILLUMINATED SINCE VEHICLE PURCHASE AND HAS HAD INACTIVE AIRBAGS. RECENTLY, WHILE TURNING THE STEERING WHEEL HARD DURING A POWER STEERING RESERVOIR REPLACEMENT, THE AIR BAG LIGHT BEGAN TO TURN ON AND OFF CLEARLY DUE TO SHORTED WIRING AT THE CLOCKSPRING TERMINALS.

AS I WENT TO STOP THE FRONT WHEELS SLID LIKE THEY WERE ON ICE. I WAS ON A PUBLIC RD. [BLACK TOP] I HIT THE CAR IN FRONT OF ME.

I PURCHASED MY VEHICLE IN THE FALL OF 2013 AND AM STARTING TO COME TO THE CONCLUSION THAT EVERY TIME I FILL MY GAS TANK UP MY VEHICLE SHUTS OFF! TODAY I FILLED UP MY GAS TANK. MY CHILDREN WERE IN THE BACK SEAT AND WHEN I PULLED OUT INTO THE HIGHWAY THE VAN SHUT OFF AND THE STEERING WHEEL LOCKED UP! I HAD NO CONTROL OVER THE VEHICLE. THIS SEEMS TO BE A COMMON PROBLEM WITH THESE VANS AND SOMETHING NEEDS TO BE DONE BEFORE SOMEONE GETS HURT! I CAN'T FILL MY GAS TANK UP BECAUSE OF THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2004 DODGE CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS A LEAK IN THE FUEL PUMP DUE TO CORROSION. AS A RESULT, THE FUEL PUMP ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,755.

WHEN I CHANGED MY VEHICLE BATTERY TO A NEW ONE THE GAS ONLY DROPS TO A HALF A TANK ITS WILL NOT GO DOWN TO EMPTY BUT MY LOW FUEL LIGHT WORKS STILL MY GAS GAUGE DOES NOT. HOW DO I FIX IT OR RESET IT. *TR

EVERY TIME VEHICLE IS FUELED UP, THE VEHICLE PUTTERS AND SHUTS OFF, CAUSING ALL POWER STEERING TO LOCK UP WHILE DRIVING. OCCURS THE FIRST COUPLE MILES. *TR