2006 DODGE CHARGER Complaints

MY 2006 DODGE CHARGER STALLS AFTER I FILL UP THE GAS TANK. THE CHECK OIL LIGHT WILL COME ON AND THE CAR SHUTS OFF. THIS HAPPENS AFTER I COME TO A STOP AFTER THE FILL-UP. EVENTUALLY IT STOPS STALLING. *TR

VEHICLE STALLED AGAIN TODAY (OCTOBER 19TH, 2013) WITH NO WARNING WHILE MAKING A LEFT-HAND TURN AT A MAJOR INTERSECTION. FILLED UP EARLIER TODAY WITH NO TOP OFF. HAS HAPPENED MULTIPLE TIMES PRIOR SINCE (MAY 2013). DEALER CAN NOT DIAGNOSE. NORMALLY HAPPENS AFTER FUEL FILL UP. AFTER COMPLAINING MULTIPLE TIMES TO THE DEALER, REPLACED ALL SPARK PLUGS AND PERFORMED A TRANSMISSION FLUSH AND RE FLASHED THE PCM AT MY EXPENSE, DESPITE HAVING WARRANTY COVERAGE THROUGH 2015 120K MILES BECAUSE THEY COULD NOT REPEAT THE PROBLEM ON A 5 MINUTE TEST DRIVE. THE VEHICLE STALLED AGAIN TWO DAYS LATER. AFTER MORE VISITS NO SOLUTION HAS BEEN MET AND THIS CAR IS EXTREMELY UNSAFE. *TR

AFTER FILLING UP WITH GAS WAS TURNING ONTO A MAIN ROAD WHEN CAR SUDDENLY STALLED. DODGE DEALER COULD NOT FIND PROBLEM. HAPPENED SEVERAL MORE TIME OVER THE NEXT COUPLE OF MONTH AFTER FILLING GAS TANK. REPLACED FUEL PUMPS PER DEALER RECOMMENDATION. A COUPLE OF MONTHS LATER IT HAPPENED AGAIN AFTER FILLING TANK. DID A SEARCH AND FOUND SAME PROBLEM WITH GAS TANK ON THIS SAME MODEL. IN MAY 2013 REPLACED GAS TANK. ON SEVERAL OF THESE INSTANCES OF CAR STALLING I WAS LEAVING GAS STATION AND TURNING INTO TRAFFIC WHEN THE VEHICLE STALLED CAUSING NEAR ACCIDENTS. THIS IS GOING TO CAUSE A FATALITY IF IT HASN'T ALREADY. *TR

AFTER FUELING UP, I PULLED OUT OF THE GAS STATION AND ONTO A MAIN ROAD. ABOUT 300YARDS FROM THE GAS STATION. I ACCELERATED TO APPROXIMATELY 40MPH, IN THE MIDDLE OF THE INTERSECTION MY CAR "DINGED" THE OIL LIGHT CAME ON AND MY ENGINE SHUT DOWN. I LOST ALL ABILITY TO TURN, OR BREAK. THIS IS A VERY DANGEROUS SITUATION. I FEARED FOR MY LIFE. I ORIGINALLY THOUGHT IT WAS BECAUSE I LET THE FUEL LEVELS GET TOO LOW, AFTER, I REALIZED IF I FILL UP ALL THE WAY, THIS ALWAYS OCCURS. GOD FORBID IF I WERE TO BE ENTERING ON TO A FREEWAY AT A HIGHER RATE OF SPEED. SINCE THIS HAS HAPPENED TO ME 3+ TIMES, I AM VERY SCARED AND NERVOUS TO DRIVE MY CAR. SOMETHING AS TO BE DONE. PLEASE, BEFORE SOMEONE GETS KILLED BECAUSE THE GAS TANK AND EVAP CANISTER ARE SCREWY! I. ANT GET ANY DEALERSHIP OR MECHANIC TO FIX IT WITHOUT REPLACING THE WHOLE TANK,($$$$$$$). *TR

THIS ISSUE STARTED APPROX 3 WEEKS AGO. THE HEAD LIGHTS WILL NOT STAY ON THEY FLICKER OFF AND ON AS IF I WAS FLASHING MY LIGHTS TO ALERT ANOTHER DRIVER, WHEN THEY ARE ACTUALLY DOING THIS ON ITS ON. THIS IS NOT ONLY A SAFETY ISSUE, BUT I'M AFRAID I WILL GET PULLED OVER BY LAW OFFICIALS. AND MY JOB REQUIRES ME TO HAVE TO BE AT WORK AT NIGHT. THIS IS VERY DISTURBING WHEN THIS HAPPENS AND THEY STAY OFF AT TIMES FOR 30 TO 40 SECONDS AT A TIME AND I'M HAVING TO HOLD THE BRIGHT LIGHT ARM TO HAVE LIGHTS. THE PASSENGER AIRBAG LIGHT COMES ON FROM TIME TO TIME SAYING IT IS NOT ON, AND THERE ARE BRAKE ISSUES AS WELL. *TR

THIS IS A BRAND NEW ENGINE PUT IN BY DODGE AND HAS ONLY 3000 MILES SINCE IT WAS REPLACED 4 MONTHS AGO. I FILLED UP THE GAS TANK TODAY AND WITHIN A MINUTE OF PULLING AWAY FROM GAS STATION AS I WAS MAKING A LEFT TURN, THE ENGINE CEASES AND STOPS. I TRIED TO RE START IT DIDN'T START RIGHT AWAY. AFTER 2 TRIES IT STARTED AND ABOUT A MINUTE LATER AS I PRESSED ON THE BRAKES TO TURN LEFT THE CAR STALLS OUT AGAIN. *TR

TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THE PISTON HAD FAILED CAUSING THE ENGINE HEAD TO FRACTURE. THE MECHANIC STATED THE ENGINE WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

EVERY TIME YOU FILL UP THE GAS TANK THE CAR WANTS TO STALL. I'M TOLD THERE IS A SOLENOID IN THE GAS TANK THAT FAILS AND IT LETS RAW FUEL GO TO THE EVAP CANISTER CAUSING A STALL CONDITION. THIS SOLENOID VALVE IS MOLDED INTO THE GAS TANK AND THE ONLY WAY TO FIX IT IS TO REPLACE THE GAS TANK. THIS STALL CAN HAPPEN WHILE YOUR SITTING AT A STOP LIGHT OR JUST PULLING OUT INTO AN INTERSECTION. THE INTERSECTION SITUATION IS VERY DANGEROUS. *TR

ENGINE STALLED OUT WHILE DRIVING ON FREEWAY AFTER FILLING UP WITH GAS. THREE DIFFERENT OCCASIONS DROPPED VALVE SEATS, 8/2011 AND 9/2013. *TR

2006 DODGE CHARGER R/T. THIS HAS BEEN GOING ON FOR YEARS, I READ ABOUT OTHERS HAVING SIMILAR ISSUES AND DECIDED TO CONTRIBUTE MINE AS WELL AS IT HAPPENED AGAIN THE OTHER DAY WHEN I ACCIDENTALLY REFILLED ALL THE WAY. WHEN YOU FILL THE TANK ALL THE WAY, THE VEHICLE STALLS IMMEDIATELY AND WILL CONTINUE STALLING UNTIL THE GAS TANK IS NO LONGER "COMPLETELY FULL." THE ONLY EASY WAY TO FIX WITHOUT TAKING SOMETHING APART IS TO REPEATEDLY RESTART THE CAR UNTIL ENOUGH GAS BURNS OFF. EVEN WITH TAKING CARE TO NOT FILL THE TANK ALL THE WAY, GOING UP CERTAIN HILLS SEEM TO CAUSE THE STALL AS WELL. NO CHECK ENGINE LIGHT, JUST POWER CUTS OFF. ONE SINGLE CHIME FROM THE CAR AS THE OIL LIGHT TURNS ON. YOU CAN RESTART IT BUT OBVIOUSLY THIS IS BAD WHEN IT HAPPENS IN TRAFFIC. SEEMS TO STALL MOST AT STOPLIGHTS AND OTHER IDLE CONDITIONS BUT CAN ALSO STALL IN LOW SPEED SCENARIOS. NEVER GOT FAST ENOUGH TO TELL IF IT WOULD HAPPEN THERE TOO. ACCORDING TO BOTH INDEPENDENT MECHANIC AND DEALER, THIS IS A VALVE INSIDE THE FUEL TANK WHICH WOULD REQUIRE AN EXPENSIVE FUEL TANK REPLACEMENT TO FIX - THE MECHANIC SAID THEY HAD SEEN A LOT OF THEM, BUT THERE WAS NO RECALL SO IT WOULD BE AT MY EXPENSE TO FIX. *TR