1994 DODGE GRAND CARAVAN Complaints

WHEN I WAS TRYING TO TURN THE WHEEL TO GET OUT OF THE DRIVEWAY, MY STEERING WHEEL CAME OFF. I WAS ABOUT TO BACK UP AND IF I DID I WOULD HAVE LOST CONTROL AND CRASHED.

TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 00V305000 (STEERING), 99V213000 (STRUCTURE), 99V113000 (AIR BAGS), AND 95I00100 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SERPENTINE BELT WOULD DETACH FROM THE VEHICLE WHEN IT WOULD RAIN OR WHEN THE VEHICLE WAS DRIVEN THROUGH A PUDDLE OF WATER. THE FAILURE WOULD CAUSE THE VEHICLE TO LOOSE POWER AND OVERHEAT. THE VEHICLE WAS REPAIRED SEVERAL TIMES AND THE PULLEYS WERE REPLACED, BUT THE FAILURE CONTINUED TO RECUR. THE DEALER AND SEVERAL MECHANICS WERE UNABLE TO DETERMINE WHAT CAUSED THE CONSISTENT FAILURE. THE FAILURE MILEAGE WAS 230,426 AND THE CURRENT MILEAGE WAS 241,625.

AIR BAGS DEPLOYED ON 1994 DODGE GRAND CARAVAN WITH BRAUN HANDICAPPED MODIFICATIONS WHILE IDLING IN THE DRIVEWAY DURING LOADING OF HANDICAPPED WOMAN. ATTENDANT WAS INJURED DUE TO PROXIMITY OF HEAD TO PASSENGER SIDE AIRBAG. *TR

TL* - THE CONTACT OWNS A 1994 DODGE CHRYSLER GRAND CARAVAN. WHILE DRIVING AROUND A MOUNTAIN THE STEERING LOCKED AND LOST POWER STEERING. THE CONTACT LET THE VEHICLE SIT FOR APPROXIMATELY 1/2 HOUR AND THE VEHICLE WAS DRIVABLE. THERE WERE NO WARNING INDICATORS. THE FAILURE MILEAGE WAS 66,000. THE DEALER DIDN'T TRY TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 165,000.*AK THE CONSUMER STATED THAT HE REPLACED THE BELT IN 1996, BUT THE MECHANIC STATED THE BELT LOOKED FINE. UPDATE 05/10/07*TR

TL* -THE CONTACT STATED THAT THE 1994 DODGE GRAND CARAVAN WITH 150000 FAILURE MILEAGE WAS LEAKING GAS ON THE MANIFOLD. THE CONTACT A MECHANIC DISCOVERED THAT THERE WAS A FUEL LEAK. THERE WAS A RECALL # 00268000 ON THE 1996-2000 DODGE GRAND CARAVANS. THE VEHICLE WAS NOT DRIVABLE , AND THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 150,000. *AK THE FUEL RAIL WAS LEAKING FUEL AT THE END OF THE RAIL WHERE A PIPE JOINED THE 2 RAILS TOGETHER, FUEL LEAKED ON THE MANIFOLD AND A SMALL FIRE WAS IGNITED. UPDATED 04/30/07. *JB

VEHICLE STALLS WHILE DRIVING, USUALLY WHEN WEATHER IS VERY WARM. NO INDICATION OF OVERHEATING. LET SET FOR 10-15 MINUTES AND VEHICLE STARTS AND RUNS FINE UNTIL NEXT TIME. HAS HAPPENED 6 TIMES IN THE LAST 3 YEARS, USUALLY ON THE INTERSTATE CAUSING A POTENTIALLY VERY DANGEROUS SITUATION. HAVE NOT HAD TO A DEALER TO CHECK OUT BUT HAVE SEEN OTHER COMPLAINTS ON THIS SITE BY PEOPLE WHO HAVE THIS SAME PROBLEM WHO HAVE TAKEN TO DEALER AND DEALER WAS NOT ABLE TO LOCATE THE SOURCE OF THE STALLING.

1994 DODGE GRAND CARAVAN, DRIVERS SIDE SEAT BACK BROKEN AT THE FIRST WELD ON THE VERTICAL PORTION OF THE SEAT BACK. CAR WAS BEING DRIVEN NORMALLY, NO ACCIDENT OR INCIDENT OCCURRED. THERE WAS NO WARNING, THE SEAT JUST WENT TO A RECLINED POSITION WHILE DRIVING. FURTHER INVESTIGATION REVEALED THAT IN ADDITION TO THE VERTICAL FRAME WELD FAILURE, A CASTING FAILURE OCCURRED ON THE HORIZONTAL PORTION OF THE SEAT FRAME IN THE VICINITY OF RECLINE LEVER. THE FRAME CASTING WAS COMPLETING SEVERED AND WOULD NOT HAVE RETAINED THE SEAT IN THE EVENT OF A SUDDEN DECELERATION. THE SEAT WAS UNSAFE BUT DID NOT REVEAL ITSELF UNTIL THE BACK FRAME WELD FAILURE. MY STATE OF RESIDENCE IS WISCONSIN, YOUR PROGRAM DID NOT ALLOW ME TO ENTER THIS STATE SO I CHOOSE ONE AT RANDOM. *NM

CONSUMER STATED THE SLIDING DOOR FELL OFF TRACK . THE PART HAD BEEN REPAIRED THREE TIMES, HOWEVER THE PROBLEM RECURRED. *AK THE CONSUMER STATED THAT THE PARTS SEEM TO WEAR TO EASY AND RUST WHEN THEY SHOULD NOT. *TC

(1) NO WARNING OF FAILURE.(2) SERPENTINE BELT TENSIONER BOLT FAILED CAUSING LOSS OF POWER STEERING DURING A TURN. NO CONSEQUENCES RESULTED FROM THIS PARTICULAR FAILURE BECAUSE THE FAILURE OCCURRED IN A PARKING LOT AT 5MPH. UNDER DIFFERENT CIRCUMSTANCES (DOWNHILL ON TIGHT CURVE) THE FAILURE WOULD HAVE BEEN EXTREMELY DANGEROUS AND PROBABLY RESULT IN TOTAL LOSS OF CONTROL.(3) ANTICIPATE REPLACING THE TENSIONER AND RETURNING VEHICLE TO SERVICE.*AK