2012 DODGE RAM 1500 Complaints

While operating the vehicle at highway speed the vehicle shut off causing total loss of power. This happened on a road with speeds at 55 mph. It also occured while pulling into my driveway at a low speed, and i have had 3 occurences of the vehicle power "surging" at varied speeds. I had the fuel pump replaced, which did not remedy the problem. After hearing my fuel pump running with the vehicle shut off, i did some further research and found that the TIPM (toatally integrated power module) is the culprit and has been found to cause several other electrical system issues. Loss of power in a low speed scenario, such as turning left from one roadway to an intersecting road can cause the vehicle to be stranded in the middle of the road and place the stranded vehicle in the line of incoming traffic posing a serious risk for injury or death from a "T-Bone" motor vehicle crash.

The fuel tank strap frame T -slot bracket corroded and the fuel tank fell upon the ground while traveling on roadway . there is a recall for this but it doesn't look like my vehicle was included .

Failure of fuel pump relay on above listed 2012 Ram 1500 at 69,999 miles. Current repair requires replacement of entire TIPM module (at a cost of $1,000 to 2,000) as this relay is soldered to the circuit board deep inside the module, making it nearly impossible to cost effectively replace this critical $10.00 part. Of note, the TIPM installed in this vehicle has 10 slots (9 relays installed and 1 open slots) for "replaceable" relays under the cover. Of these replaceable relays at least 2 (blower motor and park lamp) are less critical with one empty slot available. Further a safety recall was issued in December of 2014 (Safety Recall P54/14V530 Fuel Pump Relay) for 2011 models of the Dodge Durango and Jeep Grand Cherokee, but no other models despite that the same or very similar designed TIPM's are used in virtually all Chrysler, Dodge, Ram and Jeep vehicles along with many VW models. If this was a SAFETY ISSUE for select 2011 models, why not the other vehicles using the same or similar TIPM's. Further experience has shown that the Chrysler fix tends to have a high failure rate also. Suggestion: Recall all vehicles with TIPM's which have soldered in Relays, for replacement with a re-designed part which allows for all the relays that can be readily replaced. Further consideration in the design of a new part should include the minimization or elimination of multiple points of failure (is a relay really necessary on a circuit?).

The frame rusted at the attachment point for one of the fuel tank support straps. The fuel tank sagged as it was being supported by only one strap.

The contact owns a 2012 Ram 1500. The contact stated that the fuel tank had detached from the vehicle and was left hanging approximately 6 inches from the ground. The contact had taken the vehicle to the dealer who stated that the fuel tank straps needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 67,000.

While driving the Vehicle at 9:30pm on 7/22/22 the vehicle suddenly accelerated on its own at a very fast rate after I sped up to yield over into another lane coming off the highway. There was luckily no vehicles ahead of me and I was on a straight away or else I would’ve hit someone. I pressed the brakes down but they wouldn’t bring the vehicle to a stop. I placed the transmission in neutral and it slowed down but soon as I put it back in drive it accelerated again. I went through this cycle 4 times then finally I gained control of the vehicle again. I have read online the dealer says it’s user error or floor mats. That was not the case at all. My floor mats are stock and have taps keeping them secure. This situation was very dangerous and if it happens again it could cause serious injury to me or someone else.

My 2012 Dodge Ram 1500 has 67,700 miles and about 30 days ago developed a "tick" coming from the engine. After doing a google research, it appears that 2012 Dodge Ram's with the 5.7 HEMI can develop a "tick" ranging from failed manifold bolts to camshaft failure. My Ram has always been very well cared for and is a low mile vehicle for its age. I found no factory recall on this issue, so I will take it into a local Dodge dealer for diagnosis and repair.

I believe there should be a recall by Dodge on their Dodge 1500 Laramie Longhorn with the 5.7 Hemi engines. It's really the Hemi exhaust manifold that is the problem. I have this ticking noise which hundreds if not thousands of others also have. Copied from the Internet ** (Broken or loose exhaust manifold bolts (this is the most common answer). I've had my truck diagnosed and this is what they say is bad. They will not fix it for no charge. The fix is close to and/or over $1,000. Good reason for the to not admit it's their problem. There should definitely be a Class Action Lawsuit against Dodge. This is a very common problem and because hundreds if not thousands of engines have this issue it should be a RECALL issue. I would hope your organization could do something about this. I don't think it's fair that their mechanical problems they caused are my costly problems. I'll pay for wear and tear and things I've done to my car but they should stand up and take responsibility of their manufactures defects. Please help. [XXX] P.s. Not sure of the date this started but it had about 40,000 miles. Now has 69,000. I've been driving it this way for sometime now but would like to get it fixed. Dodge is denying my request to have them pay for it. We hope you have some clout to get this issue resolved not only for me but for hundreds of others. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2012 Ram 1500. The contact stated while driving approximately 15 MPH, there was a fuel strap failure. There were no warning lights. The vehicle was taken to the local dealer who confirmed the failure with the fuel strap. The vehicle was repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number 18V160000 (Fuel System, Gasoline). The approximate failure mileage was 135,000.

Engine ticking heavily and diminishes some when engine warms up. Vehicle dies randomly while driving and loss of power steering and assisted breaking. Almost had an accident while turning a corner and vehicle died.