2009 DODGE RAM 1500 Complaints

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT THE BOLTS ON THE EXHAUST MANIFOLD FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE FRONT WINDSHIELD DEFROSTER BECAME INOPERABLE WITHOUT WARNING. THE CONTACT HAD TO PULL OVER TO WIPE THE WINDOWS DOWN AND CONTINUED DRIVING WITH THE WINDOWS DOWN FOR BETTER VISIBILITY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V158000 (EQUIPMENT). THE APPROXIMATE FAILURE MILEAGE WAS 34,900.

WHILE GOING DOWN INTERSTATE MY ABS, SERVICE 4WD, ESP TRACTION CONTROL AND BRAKE LIGHT ALL CAME ON AT SAME TIME. WHEN IT HAPPENED IT HAPPENED IT KNOCKED MY CRUISE OFF AND SLOWING DOWN. I GOT BACK ON THE GAS AND STARTED TO SPEED UP THEN ALL OF A SUDDEN MY GAS BECAME MY BRAKE IT LOCKED ALL 4 TIRES UP AT HIGH SPEED. I WAS VERY LUCKY NO ONE WAS REAL CLOSE TO ME. I MADE IT TO SAFE PLACE TO PULL OVER AND CHECK IT OUT AND NO MATTER WHAT I DID I COULDN'T GET IT BACK GOING CORRECTLY. AT FIRST IT WOULD DO RIGHT AND GET UP TO 30MPH AND EASE ON GAS LITTLE BIT AND IT WOULD START BREAKING WHEN TOUCHING GAS. HAS TO HAVE IT TOWED. IT WAS VERY DANGEROUS AND I WAS REAL LUCKY NOT TO WRECK. I HOME THIS PROBLEM CAN GET RESOLVED. *TR

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE OPERATING THE VEHICLE AT NIGHT WITH THE LOW BEAM HEADLIGHTS ACTIVATED, THE LIGHTS WOULD NOT ILLUMINATE BRIGHT ENOUGH FOR THE DRIVER TO SEE THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER MULTIPLE TIMES AND THE LIGHT BULBS WERE REPLACED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 57,000.

DEFROSTER DOES NOT WORK, BLOWER EMITS AIR (COLD) BUT ONLY TO FLOOR. LOUD POPPING NOISE FROM AIR BOX, FOUND ACTUATORS WERE MALFUNCTIONING. NEARLY CAUSED COLLISION WITH ONCOMING TRAFFIC. CONTACTED CHRYSLER FOR RECALL STATUS AND THEY CLAIMED TRUCK WAS UNDER THIS RECALL, HOWEVER TRUCK HAD BEEN INSPECTED AND FOUND TO HAVE NO PROBLEMS WITH REGARDS TO AIR BOX ACTUATORS. I SUBSEQUENTLY FOUND OUT FROM A NAMELESS DODGE TECHNICIAN THAT THEY WERE INSTRUCTED TO ENGAGE AIR SYSTEMS FOR THE INSPECTION AND IF NO APPARENT MALFUNCTION IS FOUND THEY WERE TO PASS THE RECALL AND WRITE IT OFF. I AM OUTRAGED THAT YET ANOTHER CORPORATE ENTITY IS PREYING ON AMERICAN CONSUMERS AND GETTING BY WITH IT, WHILE CLAIMING TO STAND BEHIND THEIR PRODUCT AND IT'S ENGINEERING. I ASKED CHRYSLER WHAT REPAIR WAS NEEDED. THEY REPLIED" AIR BOX CIRCULATION DOORS BAD. WOULD NEED BOX REMOVED AND REPLACE 5 ACTUATORS AND DOORS. COST WOULD BE $800 TO $1000 DOLLARS. THIS IS A SAFETY ISSUE 3/4 OF THE YEAR. I NOW HAVE BEEN NOTIFIED BY DODGE OF ANOTHER RECALL FOR MY TRUCK REGARDING THE AXLE PINION NUT. I BELIEVE THIS RECALL WILL RECEIVE THE SAME ATTENTION THEY GAVE TO MY AIR BOX ISSUE AND THEREFORE AM ATTEMPTING TO TAKE ACTION WITH THIS COMPLAINT. WILL SOMEONE PLEASE MAKE THESE CORPORATE PENNY PINCHING SOBS STAND UP AND TAKE RESPONSIBILITY FOR THEIR POOR ENGINEERING!!!! *TR

SYSTEM WARNING WENT OFF THAT WE WERE LOOSING AIR IN THE TIRE. WITHIN SECONDS, WE PULLED OVER AND THE TIRE WAS FLAT. RECEIVED ROADSIDE ASSISTANCE SO WE COULD DRIVE THE TRUCK HOME. STOPPED AT A GAS STATION TO CHECK THE AIR IN ALL THE TIRES. COULDN'T PUT AIR IN ONE OF THE TIRES BECAUSE THE NUT HOLDING THE TIRE SENSOR ROTTED OFF. WHILE TRYING TO PUT THE AIR IN, THE STEM WAS GETTING PUSHED INTO THE TIRE. THE MECHANIC TOLD US THAT'S WHAT HAPPENED TO THE FIRST TIRE (THE NUT ROTTED OFF). HAD WE BEEN TRAVELING AT A HIGHER SPEED, THIS COULD HAVE CAUSED A SERIOUS ACCIDENT. WE FEEL THIS IS A DANGEROUS PROBLEM AND SHOULD BE LOOKED IN TO. *TR

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 30 MPH, A BOUNCING TYPE NOISE WAS HEARD UNDER THE VEHICLE. WHEN DEPRESSING THE ACCELERATOR PEDAL, THE NOISE WOULD GET LOUDER, BUT THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STOPPED THE VEHICLE AND DISCOVERED THAT THE DRIVESHAFT WAS DETACHED FROM THE TRANSMISSION AND LYING ON THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 69,000.

ON 3/30/15 MY RAM TRUCK EXHIBITED THE CONDITION DESCRIBED IN THE K17 (REPROGRAM HVAC CONTROL HEAD AND INSPECT/REPLACE ACTUATORS) RECALL. THIS RECALL WAS CREATED TO ELIMINATE THE POSSIBLE MALFUNCTION OF THE HVAC SYSTEM TO PROPERLY DEFROST/DEFOG THE WINDSHIELD. IT INVOLVES UPDATING SOFTWARE AND REPLACING MODE DOOR ACTUATORS. THE PLASTIC ACTUATOR GEARS CAN EASILY BE BROKEN WHEN THE CONTROL HEAD SENDS THE WRONG SIGNALS TO OPEN AND CLOSE THE MODE DOORS. AT THE MOMENT, MY DEFROSTER/HEATER IS NOT WORKING AND WHEN I FIRST START THE VEHICLE, THERE IS A SERIES OF KNOCKING SOUNDS FOR SEVERAL MINUTES AS THE MALFUNCTIONING SYSTEM GOES THROUGH ITS PROGRESSIONS. I TOOK IT IN TO MY LOCAL DODGE DEALER (GURNEE) HOPING THAT THE RECALL WOULD ELIMINATE THE CONDITION. THE MECHANIC REPLACED THE ACTUATORS BUT COULD NOT GET THE SYSTEM WORKING PROPERLY. HE SAID THE CONTROL HEAD IS NOT WORKING PROPERLY BUT THE RECALL ONLY COVERS THE SOFTWARE UPDATE AND NOT THE REPLACEMENT. FROM MY RESEARCH I HAVE NOTICED THAT OTHER RAM OWNERS HAVE ENCOUNTERED THIS POTENTIALLY DANGEROUS CONDITION. IF IT WAS JUST A MATTER OF THE CONTROL HEAD WEARING OUT AND NOT WORKING, I WOULD BE OKAY WITH REPLACING IT AT MY OWN EXPENSE. IN MY OPINION THOUGH, IT IS NOT A CASE OF 'WEAR AND TEAR' BUT INSTEAD I BELIEVE IT IS A DEFECTIVE COMPONENT. THE FAULTY CONTROL HEAD CAUSES THE BREAKAGE OF THE ACTUATORS AND MODE DOORS. PEOPLE WHO ENCOUNTER THIS PROBLEM IN THE WINTER ARE AT RISK OF AN ACCIDENT DUE TO THE INABILITY TO CLEAR THEIR WINDSHIELD. DRIVERS MAY EVEN NEED TO GET THEIR VEHICLES TOWED. I BELIEVE THAT DODGE SHOULD BE RESPONSIBLE FOR REPAIRING THE SYSTEM TO ITS NORMAL CAPABILITIES. THAT IS WHAT A RECALL IS DESIGNED TO DO. THIS IS SIMPLY A CASE OF A PREVIOUSLY RECALLED VEHICLE REMEDY NOT WORKING AS DESIGNED. I CALLED DODGE CUSTOMER SUPPORT ON 4/10 AND TALKED TO A REP THAT SAID THE REPAIRS WOULD BE MY RESPONSIBILITY. *TR

RAM BOX LIDS SEEM TO BE RELEASING FIBERGLASS LIKE FIBERS INTO CLOTHES OR SKIN WHEN TOUCHED. CAUSES SEVERE ITCHING AND DISCOMFORT LIKE YOU HAVE FIBERGLASS SLIVERS IN YOUR SKIN. TAKES DAYS OF SCRUBBING BEFORE IT SEEMS TO GO AWAY. HAVE SINCE HEARD ABOUT MULTIPLE OWNERS EXPERIENCING THIS. *TR

THERE IS A BANGING NOISE THAT SEEMS TO BE COMING FROM BEHIND THE GLOVE BOX. I RESEARCHED IT ONLINE AND THINK IT'S A HEAT BLEND DOOR ACTUATOR THAT WENT OUT. I WAS QUOTED OVER $500 FOR THE REPAIR DUE TO THE COMPLEXITY OF GETTING TO THE ISSUE THROUGH THE DASHBAORD. A WHILE BACK THERE WAS A RECALL ON SOME PART OF THE AC/HEATING BUT I CANNOT REMEMBER WHAT IS WAS FOR. I CALLED THEIR HOTLINE AND WAS ADVISED THAT RECALLS ARE ACTIVE FOR 10 YEARS FROM THE MANUFACTURE DATE, SO IN MY CASE, THROUGH 2019. I SEARCHED WWW.SAFERCAR.GOV AND THERE WASN'T ANY RECALLS LISTED UNVER THIS VIN. I READ THAT OTHERS ARE HAVING THIS SAME ISSUE AND I FEEL THIS IS A DEFECTIVE PART THAT SHOULD BE RECALLED AS AT ONE POINT IT DISABLED THE BLOWER. THE BLOWER OPERATED INTERMITTENTLY WHICH WAS EXTREMELY HAZARDOUS DURING WINTER. *TR