2004 DODGE RAM 3500 Complaints

The contact owns a 2004 Dodge RAM. The contact received recall notifications, NHTSA Capaign Number: 16V352000 (Air Bags and NHTSA Campaign Number: 15V313000 (Air Bags) however the parts were unavailable. The dealer was contacted, however the contact was informed that the parts were in back order. In addition, the contact was informed that the parts were unavailable until October 2026. The manufacturer was contacted. The cotnact was informed that the parts were unavailalbel.

The contact owns a 2004 Dodge Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 13V528000 (Steering), 16V352000 (Air Bags), 15V313000 (Air Bags), and 05V462000 (Power Train); however, the parts to do the recall repairs were not yet available while the vehicle was in for service. The local dealer was made aware of the issue, and an appointment was scheduled to repair the vehicle. The vehicle remained with the dealer for a week before the contact was informed that parts for the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on several occasions, while the vehicle was in park(P), the vehicle unexpectedly rolled without warning. The brake pedal was depressed with extra force while shifting to park(P). The manufacturer was not made aware of the issue. The failure mileage was unknown.

upper control arm cracked which is a safety violation and should be a recall. TRW 52106776 Control arm is the cracked part in the picture My son replace both control arm and send it for alignment total cost was as below; Parts $280 + Alignment $192.59= $472.59 I like Dodge to refund me for $460

WHILE TRAVELING ON INTERSTATE 90 IN WASHINGTON STATE, TRAVELING AT ABOUT 60 MPH I NOTICED A HAZE BEHIND THE TRUCK THROUGH THE PASSENGER SIDE DOOR MIRROR. AT THE TIME, THERE WERE NO INDICATIONS BY INSTRUMENTS OR WARNING LIGHTS THAT ANYTHING WAS AMISS WITH THE TRUCK. WONDERING IF IT WAS COMING FROM THE TRUCK I PULLED TO THE SHOULDER TO CHECK. AS SOON AS I STOPPED I SMELLED HOT OIL, SO SHUT OFF THE ENGINE, RELEASED THE HOOD LATCH AND CHECKED THE ENGINE COMPARTMENT. UPON LIFTING THE HOOD OF THE ENGINE COMPARTMENT I IMMEDIATELY NOTICED FLAMES BETWEEN THE ENGINE AND FIRE WALL. I RETRIEVED A FIRE EXTINGUISHER FROM THE CAMPER THE TRUCK WAS HAULING AND ATTEMPTED TO EXTINGUISH THE FIRE. TWO MOTORISTS WITH FIRE EXTINGUISHERS STOPPED TO HELP AND THE COMBINED USE OF THREE DRY CHEMICAL FIRE EXTINGUISHERS WOULD NOT PUT THE FIRE OUT AND THE TRUCK AND CAMPER COMPLETELY BURNED. WHEN I REPORTED THIS TO MY INSURANCE COMPANY WE DISCOVERED AN ERROR IN THE VIN NUMBER ON MY INSURANCE POLICY. OUT OF CURIOSITY I RESEARCHED THAT VIN NUMBER AND WAS SURPRISED TO SEE THAT SAME STYLE TRUCK HAD ALSO BURNED. IT'S VIN IS 3D7MU48C84G269656 AND CAN BE SEEN IN THE 7TH PHOTO THAT IS UPLOADED TO THIS REPORT. BOTH WERE 2004 DODGE DIESEL TUCKS WITH LOW MILEAGE. IT SEEMS TOO MUCH OF A COINCIDENCE AND I WONDER IF THERE IS A DEFECT THAT CAUSED THIS AND HOW MANY OTHER OF THIS YEAR, MAKE AND MODEL HAVE BEEN DESTROYED BY FIRE.

STEERING BECAME LOOSE AND HAD 1-2INCHES OF SLACK BEFORE GUIDING THE VEHICLE PROPERLY. REPLACED WITH NEW STEERING UNIT. TRANSMISSION WOULD NOT SHIFT INTO LOW GEAR AT BUSY INTERSECTION ENTERING FREEWAY. *TR STARTED IN SECOND OR THIRD REQUIRED COSTLY REBUILD. FUEL GAUGE READS EMPTY REQUIRED NEW UNIT IN FUEL TANK.

HAVE TO USE FORCE TO ENGAGE CLUTCH TO START VEHICLE. THE VEHICLE WAS STATIONARY WITH A TRAILER ATTACHED. UNABLE TO TURN OFF VEHICLE WHEN FUELING DUE TO PROBABILITY THAT IT WOULD NOT START. TRIED JUMPER CABLES WITHOUT SUCCESS. AFTER STOMPING CLUTCH SEVERAL TIMES VEHICLE STARTED.

2004 DODGE RAM 3500. CONSUMER WRITES IN REGARDS TO NUMEROUS REPAIRS MADE TO VEHICLE. *LD THE CONSUMER STATED THE DEALER HAS HELD THE VEHICLE WITHOUT MAKING ANY REPAIRS, OR PREDICTIONS ON WHEN THE REPAIRS WOULD BE COMPLETED. *JS

PURCHASED USED 2004 DODGE 3500 AND WHILE DRIVING HOMEDOING 60 MPH I EXPERIENCED SUCH A VIOLENT SHACKING OF THE FRONT END I NEARLY LOSS CONTROL OF MY TRUCK AND STRUCK ANOTHER VEHICLE ON THE HIGHWAY. MY WIFE AND I COULD HAVE BEEN KILLED. I LATER LEARNED THAT THIS TRUCK SUFFERS FROM DEATH WOBBLE WHICH DODGE IS AWARE OF. AS A RETIRED POLICE OFFICER WITH 30 YEARS I WOULD HAVE TOWED THIS TRUCK AS UNSAFE UNTIL PROPER REPAIRS WERE MADE BASED ON THE VIOLENT SHAKING AND LOSS OF STEERING CONTROL THE DRIVER EXPERIENCES. VERY DANGEROUS SITUATION THAT NEEDS TO BE ADDRESSED.

I TOOK MY VEHICLE TO TIRE KINGDOM A REPUTABLE TIRE DEALER AND REPAIR FACILITY TO HAVE MY FRONT END CHECKED OUT, THEY INFORMED ME THAT THE LEFT TIE ROD END AND CENTER LINK NEEDED TO BE REPLACED, THE ALSO SAID THAT THIS MODEL TRUCK HAD A RECALL ON THESES PARTS MANUFACTURER RECALL NUMBER H46 NHTSA RECALL NUMBER 09E-001 AND MANUFACTURER RECALL NUMBER N62 NHTSA RECALL NUMBER 13V-528 I VERIFIED THAT THERE WAS A UNREPAIRED RECALL ON THE VEHICLE. SO I MADE AN APPOINTMENT WITH GREENWAY DODGE CHRYSLER JEEP RAM 9051 E COLONIAL DR, ORLANDO, FL 32817. I TOLD THEM AND SHOWED THEM THE ESTIMATE FROM TIRE KINGDOM STATING THE REPAIRS WERE NEEDED THEY HAD THE TRUCK ALL DAY OCT 5 2018 BUT DID NOTHING TO THE STEERING TIE RODS

"TAKATA RECALL" I HAVE ATTEMPTED TO GET MY AIRBAG REPLACED AND THE DEALERSHIP STATES THAT THEY CANNOT WORK ON THE VEHICLE BECAUSE IT HAS AFTERMARKET WIRING. THE WIRING IS NOT ATTACHED TO THE AIRBAG AND SHOULD HAVE NO IMPACT ON THE ABILITY OF A REPLACEMENT AIRBAG WORKING. THE CURRENT FIX THEY DESIRE IS FOR ME TO FIND A SHOP OF SOME KIND THAT REMOVES HEAD UNITS AND HAVE THEM REMOVE AT MY COST, AND THEN HAVE THE AIRBAG INSTALLED AND THEN HAVE THE HEAD UNIT RE-INSTALLED AT MY COST. I PURCHASED THE VEHICLE AS IS A LITTLE OVER A YEAR AGO. I JUST WANT MY TRUCK TO BE SAFE FOR MY FAMILY TO BE IN. MY CURRENT CASE NUMBER WITH DODGE CUSTOMER SERVICE IS 34528836. PLEASE HELP ME GET THIS FIXED.