2016 DUCATI XDIAVEL Complaints

AFTER 6 MONTHS OF PURCHASE MY MOTORCYCLE REAR BRAKE WAS UNUSABLE. THIS HAPPENED 3 MORE TIMES. THE LAST TIME IT WAS SITTING IN MY GARAGE FOR A MONTH AND THE REAR BRAKE WENT COMPLETELY AWAY. FINALLY THEY REPLACED THE REAR BRAKE CYLINDER. WEBSITE HAS A MULTITUDE OF SIMILAR PROBLEMS. ALSO FRONT FORKS LEAKS PREMATURELY WHAT CAN CAUSE STEERING SAFETY HAZARD. ALSO A PREVAILING PROBLEM WITH DUCATI MOTORCYLES DESPITE THEIR CLAIM THEY USE PREMIER COMPONENTS. (MY BMW BIKES DON'T HAVE THESE PROBLEMS.) ALL RELEVANT INFORMATION IS AVAILABLE AT DUCATI UNDER THE VIN.

THE DRIVE BELT DEVELOPED A DEEP GROOVE TO THE POINT OF NEARLY TEARING THROUGH ALONG THE ENTIRE LENGTH OF THE BELT DUE TO A ROCK BECOMING WEDGED BETWEEN THE FRONT PULLEY AND THE ENGINE CASE. THIS PROBLEM IS BEING REPORTED IN VERY HIGH NUMBERS ON FORUMS DEVOTED TO THIS MODEL MOTORCYCLE. ON ONE PARTICULAR FORUM, A POLL SHOWED THAT 29% OF OWNERS HAVE HAD TO REPLACE THEIR DRIVE BELT BECAUSE OF ROCK DAMAGE. TYPICALLY, MOTORCYCLE BELTS SHOULD LAST 50,000-100,000 MILES, MY BELT HAD TO BE REPLACED AFTER 7500 MILES. AN EXAMINATION OF THE BELT GUARD WILL DEMONSTRATE THAT THE BELT IS INSUFFICIENTLY PROTECTED FROM ROAD DEBRIS DURING OPERATION.

TL* THE CONTACT OWNS A 2016 DUCATI XDIAVEL. WHILE THE VEHICLE WAS AT A STOP, THE CONTACT NOTICED THAT THE BOLT THAT HELD THE SPRING TO THE SIDE STAND DETACHED AND CAUSED THE ENGINE TO STALL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V812000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 4,700.

I PURCHASED A PUIG AFTERMARKET WINDSCREEN FOR MY XDIAVEL. IT CAME TO ME WITH BOLTS TO REPLACE THE OEM BOLTS THAT HOLD THE HANDLEBARS ON TO THE BIKE. THE BOLTS THAT PUIG SUPPLIES WITH THEIR WINDSCREEN ARE FAR TOO SHORT TO BE SAFE. I NOTIFIED THE SELLER, THEY REFERRED ME TO PUIG HI-TECH OF USA. PUIG TOLD ME TO GO BACK TO THE RESELLER, WHO REFUSES TO SEND BOLTS, AND I DON'T BLAME THEM. THEY HAVE NOT BEEN TESTED, APPROVED, AND THE RESELLER IS NOT AN ENGINEER TO KNOW WHICH BOLTS ARE SAFE. THESE ARE THE BOLTS THAT FASTEN THE HANDLEBARS TO THE MOTORCYCLE! IF THEY FAIL, THE RIDER LOSES ALL STEERING, THROTTLE, BRAKING, EVEN THE ON/OFF CAPABILITY OF THE MOTORCYCLE. THIS COULD EASILY RESULT IN SEVERE INJURY OR DEATH. FORTUNATELY, I AM AN ENGIINEER, AND SAW RIGHT AWAY THAT THE BOLTS WERE VERY UNSAFE, AND I DID NOT ATTEMPT TO OPERATE THE VEHICLE. I REMOVED THE AFTERMARKET WINDSCREEN AND REINSTALLED THE OEM BOLTS.