1991 EAGLE TALON Complaints

TOOK MY 1991 EAGLE TALON TSI TO KLABEN CHRYSLER TO BE SERVICED BY THEM PER THE RECALL ON THE CAR. THEY CALLED AND SAID EVERYTHING CHECKED OK. BUT THE TRANSMISSION IS BURNED UP. THAT WEEK A FELLOW TECHNICIAN AND I PULLED THE TRANSMISSION AND TRANSFER CASE AS AN ASSEMBLY AND FOUND THE INSIDES OF THE TRANSFER CASE WERE POWDER AND BLOWN APART INSIDE. THE TRANSFER CASE WAS NOT LEAKING DUE TO NO OIL AT ALL IN THE TRANSFER CASE. I HAVE THE INVOICE ( #CHBS538463) THAT STATES EVERYTHING OK BUT A NOTE THAT SAYS THE TRANSMISSION IS BURNED UP. NINE MILES FROM THE TIME I PICKED UP THE CAR THE TRANSFER CASE LOCKED UP AND THE CAR WAS NOT MOVABLE. WE HAD TO JACK UP THE VEHICLE TO BRING IT INSIDE THE SHOP TO SEE WHAT THE PROBLEM WAS. THIS IS UNACCEPTABLE FOR A POTENTIAL CRASH TO HAPPEN AND THE JUST PUSHED IT OUT THE DOOR LIKE EVERYTHING IS PERFECTLY FINE. *JB

NHTSA RECALL 98V069002 CONCERNING TRANSFER CASE FAILURE.. LOCK UP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION. *AK

DEFECT STATED IN THE TRANSFER CASE RECALL 98 V 069 002 OCCURRED AFTER THE RECALL REPAIRS WERE PERFORMED. AS A RESULT, THE BUSHING IN THE EXTENSION HOUSING WORE OUT AND DEVELOPED A LEAK. DEALERSHIP WAS REFUSING TO REPAIR THE BUSHING.*AK

CONTACTED DEALER REGARDING RECALL 98V069002 REMEDY DUE TO TRANSFER CASE LOCKUP. DEALER INFORMED CUSTOMER THAT THEY DID NOT HAVE TO REPLACE TRANSFER CASE BECAUSE IT WAS NOT MANDATED UNDER RECALL CORRECTIVE ACTION.*AK

TIMING BELT TEETH BROKE AT THE CRANK. THIS ALLOWED PISTONS TO KEEP RUNNING, BUT THE CAM STOPPED. AS A RESULT OF THIS VEHICLE FAILED. REPAIRS WERE DONE IN APRIL 2002, WITH FAILURE REOCCURING IN AUG 2002. MILEAGE ACCUMULATION BETWEEN THE REPAIRS WAS 7,500 MILES. PLEASE DESCRIBE DETAILS. *AK

SNOW BUILDS UP AROUND HEADLIGHTS AND WILL NOT MELT,HEADLIGHT ILLUMINATION DIMINISHES IN BAD WEATHER CAUSING POOR VISBILITY. *MJ

I AM THE 2ND ONWER OF THE CAR. CAN I STILL GET A FREE REPLACEMENT OF THE PART? NO SAFETY DEFECT LISTED. *AK

CONTACED DEALERSHIP, WERE VERY DIFFICULT SAID NOT TRANSFER CASE SAID IT WAS CLUTCH, WAS REQUIRED TO PAY FOR CLUTCH, THEN CAR STILL DID NOT WORK, THEY THEN PUT ON NEW TRANSFER CASE EVEN THOUGH STATING IT WAS NOT THE CAUSE AND STILL THERE IS REAR WHEELS MAKING NOISE AS IF THERE IS SOMETHING INTHEM. RECALL SHOULD COVER CLUTCH TOO SINCE IT WAS TRF CASE CAUSING ALL THE DAMAGE.*AK

CAR HAD SEVERAL TIMES FELT LIKE IT WAS "CUTTING OUT" AND JERKING, ONCE GETTING OFF FREEWAY IT SMELT HEAVILY OF BRAKES AND COULD NOT DETERMINE WHY CAR WAS LAGGING VERY BADLY, CONTINUED TO DRIVE FOR SEVERAL WEEKS THEN WHILE DRIVING 40MPH CAR BEGAN CONVULSING AND JERKING. PULLED OVER BARELY MADE TO GAS STATION. CAR WAS HAVING HARD TIME SHIFTING GEARS AND CLUTCH WAS VERY HARD TO PUSH. WHEELS LOCKED UP AND WOULD NOT ROLL OR MOVE PUT IN GEAR AND ATTEMPTED TO MOVE CAR REVVED UP BUT WOULD NOT BUDGE. DISCONNECTED REAR DRIVELINE AND DROVE HOME AS "FRONT WHEEL DRIVE" VEHICLE.TOOK TO CHRYSLER AND HAVEBEEN FIGHTING TO GET RESOLVED.SAYS CLUTCH IS BLOWN OUT AND HAS NOTHING TO DO WITH TRANSFER CASE.*AK

VEHICLE WAS BEING REPAIRED. INDEPENDENT MECHANIC FOUND RECALL NOTICE 98V069002 REGARDINNG TRANSFER CASE FAILURE. ALSO, CAMSHAFT FAILED. INDEPENDENT MECHANIC REPLACED PARTS. LATER PROBLEM WITH CAMSHAFT BELT AND TRANSFER CASE REAPPEARED, CAUSING DAMAGE TO VEHICLE. MECHANIC CONTACTED MANUFACTURER , AND WAS INFORMED THAT MANUFACTURER WAS WILLING TO REPAIR TRANSFER CASE /CAMSHAFT BELT, BUT NOT OTHER DAMAGE DONE TO VEHICLE. INFORMATION FURNISHED BY MECHANIC WITH PERMISSION FROM OWNER. *AK