1993 EAGLE VISION Complaints

THE ENGINE CUTS OFF FOR A FEW SECONDS WHILE DRIVING AT HIGH SPEEDS (60 MPH). THE VEHICLE LURCHES AS A RESULT. LUCKILY, THE ENGINE STARTS UP AGAIN WITHOUT NEEDING TO CRANK AND THE VEHICLE PROCEEDS. ON ONE OCCASION, WHEN DRIVING AT SLOWER SPEED (25 MPH), THE VEHICLE STALLED. I LOST THE POWER STEERING, AND HAD TO STOP AND RESTART THE IGNITION USING THE KEY. *JB

DT: CONSUMER OWNS A 1993 EAGLE VISION. CONSUMER RECEIVED RECALL 99V215000 ABOUT A YEAR AGO CONCERNING LOWER CONTROL ARM. HE TOOK VEHICLE TO DEALER TO GET REPAIRS DONE . DEALER DID NOT DO ANYTHING TO VEHICLE AND CHARGED HIM $1020 FOR REPAIRS. HE TOOK VEHICLE TO ANOTHER DEALER ON AUGUST 3, 2005 BECAUSE IT STARTED SHAKING AGAIN. THEY DID NOT DO ANY REPAIRS. HE CONTACTED THE MANUFACTURER, AND WAS TOLD TO TAKE VEHICLE BACK TO DEALER. *AK *JB

CAMPAIGNS 98V184000 AND 98V130000 CONCERN FUEL LEAKAGE ON THE 1993 EAGLE VISION. ON MAY 13, 1999 THE O RINGS WERE REPLACED ON MY EAGLE BY THE PREVIOUS OWNER. ON MARCH 31, 2000, AFTER PURCHASING THE CAR I HAD TO TAKE MY CARE IN TO A GARAGE DUE TO THE STRONG SMELL OF GASOLINE. THE REPAIR SHOP FOUND A GAS LEAK. THEY REPLACED THE FUEL RAIL GASKET WHICH COST A TOTAL OF $214.02. I BELIEVE THE CAUSE OF THIS PROBLEM WAS CAUSED BY THE LEAKAGE OF THE O RINGS. THE REPLACEMENT OF THE FUEL RAIL GASKET SHOULD BE COVERED UNDER CAMPAIGN NO. 98V130000. I AM REQUESTING REIMBURSEMENT FOR THE $214.02. ALSO, I WOULD LIKE TO KNOW IF THERE IS ANYTHING ALSE I SHOULD DO TO MAKE THE CAR SAFER SUCH AS HAVING THE ENGINE FUEL RAIL REPLACED, WHICH IT APPEARS WASN'T DONE WHEN THE O RINGS WERE REPLACED BY THE PREVIOUS OWNER.

THE DRIVER'S SIDE FRONT SEAT BACK WOULDN'T STAY IN THE UPRIGHT POSITION. IT KEPT FALLING BACK DOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. *PH *TC

THE CONSUMER HAD AN ON GOING CONCERN THAT EVERY YEAR WHEN ROTATING THE FRONT TIRES, A BROKEN STUD HAS TO BE REPLACED. DEALER WAS CONTACTED. *JB ...NOT JUST WHEN ROTATIN GTIRES. NEARLY EVERY TIME THAT FRON TTIRES ARE REMOVED, A STUD BREAKS OFF. I M SURE TO INFORM THE SERVIC EPROVIDER NOT TO USE AN AIR WRENCH AND TO HAND TORQUE THE LUG NUTS. *AK

AMENDMENT TO NHTSA ODI COMPLAINT NUMBER 10066149. FUEL RAIL/INJECTION SYSTEM FUEL LINE O-RING LEAK. REFERENCE NHTSA 98V184000/CHRYSLER RECALL 790. 1) 1 INCIDENT OF RECALL NOTICE AND ATTEMPTED RECALL SERVICE. AFTER RECALL SERVICE PERFORMED ON MARCH 18 1999 THERE WERE 2 INCIDENTS OF FUEL RAIL/O-RING LEAK CONFIRMED AS FOLLOWS: 2) RIGHT (PASSENGER) SIDE FUEL RAIL CRACKED AND LEAKED (OCTOBER 17 2002) 3) LEFT (DRIVER) SIDE FUEL INLET LINE O-RING FAILED AND LEAKED (APRIL 13 2004). CUSTOMER WAS MADE TO PAY FOR REPAIRS OF 3RD INCIDENT FOR $583.00 TO REPLACE ENTIRE FUEL RAIL ASSEMBLY CHRYSLER PART NUMBER 5015231AA. INSPECTION OF PARTS RETURNED TO CUSTOMER SHOW THAT FUEL INLET O-RING IS DEFECTIVE (HARDENED AND SHRUNKEN) AND IS BLACK IN COLOR (RECALL REPLACEMENT O-RING IS SUPPOSED TO BE BLUE IN COLOR). IT HAS BEEN CONFIRMED THAT 2ND INCIDENT OF FUEL LEAK WAS DUE TO RECALL SERVICE REPAIR OF MARCH 18 1999 NOT PROPERLY PERFORMED AS FUEL INLET O-RING WAS NEVER REPLACED (VILLAGE MOTORS CHELSEA MI-MECHANIC MISTAKE). IT SHOULD ALSO BE NOTED THAT RECALL SERVICE PROCEDURE TO "REINFORCE RIGHT (PASSENGER) SIDE FUEL RAIL DID NOT PREVENT FUEL LEAK INCIDENT OF OCTOBER 17 2002. CUSTOMER IS SEEKING REIMBURSEMENT FOR $583.00 FROM CHRYSLER DUE TO IMPROPER RECALL SERVICE OF DEFECTIVE O-RING. NHTSA ASSISTANCE WOULD BE APPRECIATED.

FUEL WAS LEAKING FROM THE FUEL RAIL. CONSUMER HAD VEHICLE TOWED TO THE DEALERSHIP. VEHICLE CAUGHT ON FIRE WHILE BEING TOWED TO THE DEALERSHIP, AND DEALERSHIP REFUSED TO HONOR THE FUEL LEAKAGE RECALL 98V184000 BECAUSE OF THE FIRE. VEHICLE HAD BEEN AT THE DEALERSHIP FOR A MONTH. *AK

FUEL RAIL/INJECTION SYSTEM LEAK. REFERENCE NHTSA 98V184000 AND CHRYSLER RECALL NUMBER 790. 3 INCIDENTS OF FUEL SYSTEM LEAK DUE TO DEFECTIVE FUEL RAIL SYSTEM LEAK. NHTSA 98V184000/CHRYSLER RECALL 790 IS FOR SUPPOSEDLY FIXING RIGHT (PASSENGER) SIDE INJECTION RAIL BUT FAILS TO ACKNOWLEDGE AND ADDRESS FIXING LEFT (DRIVER) SIDE FUEL INJECTION RAIL WHICH HAS SAME PROBLEM. NOTE: ROOT CAUSE OF FUEL LEAK IS THAT THE FUEL INJECTION RAIL IS MADE OF A PLASTIC WHICH EVENTUALLY SHRINKS OR CRACKS.

AIR BAG FAILURE IN 1993 EAGLE VISION TSI. AFTER FULL FRONTAL IMPACT WITH GUARDRAIL THAT PROBABLY SHOULD HAVE DEPLOYED AIRBAGS, THE AIRBAG WARNING LIGHT WAS ON BUT AIRBAGS HAD FAILED TO DEPLOY. OCCUPANT WAS BRUISED BY SEATBELT BUT OTHERWISE UNINJURED. *AK

THE BODY AND FRAME PROBLEM IS THAT WHEN IT SNOWS, SNOW IS FOUND INSIDE MY VEHICLE ON THE FRONT PASSENGER SIDE. THIS VEHICLE HAS NOT BEEN IN ANY ACCIDENTS. WHAT CAN I DO BESIDES GOING TO A BODY AND FRAME SHOP? THE SECOND PROBLEM IS THAT THE CLEAR COAT ON THE VEHICLE IS COMING OFF. I HAVE GONE TO 3 PAINT SHOPS. ALL THREE HAVE TOLD ME IT IS CAUSED BY A DEFECT IN THE CLEAR COAT AND HAVE TOLD ME I SHOULD CONTACT THE MANUFACTURE. WHO DO I CONTACT SINCE EAGLE WAS BOUGHT OUT IN REGARDS TO THIS PROBLEM.