1998 FLEETWOOD BOUNDER Complaints

THERE WAS A QUARTER OF AN INCH GAP IN WINDSHIELD. TOOK VEHICLE TO DEALER STATED THAT VEHICLE WAS OUT OF WARRANTY. PROBLEM STILL EXISTS. *AK CONSUMER STATED THAT THE WINDSHIELD POPPED OUT AT BOTTOM DUE TO FLAW AT FACTORY. 5/8 INCH OF FIVER GLASS WAS NEEDED TO CLOSE THE GAP BETWEEN THE RUBBER SEAL AND THE BODY. *YH

FRONT LEFT TIRE WAS WEARING UNEVENLY. AFTER INSPECTION AT DEALERSHIP CONSUMER WAS INFORMED THAT BOLT HOLDING TIE ROD IN PLACE WAS LOOSE AND READY TO SNAP.*AK CONSUMER STATES THAT THE LEFT AND FRONT RIGHT TIRES WERE WORN ON THE INNER SIDE DUE TO THE 4 BOLTS HOLDING THE TIE ROD ASSEMBLY WERE LOOSE AND READY TO SNAP. *SLC

MANY FLEETWOOD OWNERS REPORT THEIR HEADLIGHT LENSES CLOUD OVER (BECOME MILKY) AND THEREFORE THE LIGHT OUTPUT IS DRASTICALLY REDUCED. THIS DEFECT APPEARS ON THE OUTSIDE OF THE LENSE. FLEETWOOD HAS FIXED THE PROBLEM WHEN A MOTORHOME IS UNDER WARRANTY. BUT, IF IT NOT...THEY REFUSE TO DO ANYTHING. THEY HAVE BEEN AWARE OF THIS PROBLEM FOR MANY YEARS!!!!

PARKING BRAKE MOUNTED ON DRIVESHAFT. HAD PUT ON PARKING BRAKE, AND VEHICLE STARTED TO ROLL AWAY. PARKING BRAKE HAD BURNED UP. WOULD NEED TO PUT DOWN ELECTRIC JACK TO PREVENT MOTOR HOME FROM ROLLING AWAY. *AK

THE AIR CONDITIONER SHROUD NEARLY SEPERATED FROM THE VEHICLE DUE TO STRESS CRACKS AROUND THE MOUNTING BOLTS. I HAD TO REMOVE THE COVER TO CONTINUE MY TRIP. *AK

MY VEHICLE IS A 35 FT MOTOR HOME BUILT BY FLEETWOOD ENTERPRISES, INC., RIVERSIDE, CA, THE COACH WAS CONSTRUCTED ON A FORD F-SUPER DUTY CLASS A MOTOR HOME CHASSIS WITHA 228 " WHEEL BASE. FORD RATES THE MAX GVWR AT 17,000 LBS WITHA 6000 LB FRONT AXLE CAPACITY. THE LOAD ON THE FRONT AXLE HAS BEEN MEASURED BY THE MANUFACTURER AT 5710 LBS. TOTALLY EMPTY . THIS WILL NOT ALLOW A DRIVER AND PASSENGER TO BE IN THE VEHICLE WITHOUT OVERLOADING THE FRONT AXLE. *AK

THE SLIDEOUT ROOM IS NOT ALIGNED PROPERLY WITH THE BODY AND ALLOWS CARBON MONOXIDE TO LEAK IN WHEN WE RUN THE GENERATOR. THE RUBBER SEALS DON'T SEAL BECAUSE THE SLIDEOUT IS TWISTED. THE MOTORHOME WAS RETURNED TO THE FACTORY ONCE TO REPAIR THE SLIDEOUT. MY DEALER HAS TESTED AND VERIFIED CO LEAKAGE AND HAS COME UP WITH SEVERAL THEORIES AND REASONS FOR THE LEAKAGE, BUT NO REMEDY. THE LAST TIME WE USED THE GENERATOR, THE CO DETECTOR WENT OFF IN SEVEN MINUTES WITH THE WINDOW THAT IS FARTHEST FROM THE GENERATOR OPEN AND THE CEILING FAN ON. WE CAN'T USE THE GENERATOR. WE HAVE THREE PHONE NUMBERS -- LAND LINE (425) 290-7109 AND TWO CELL PHONES, (425) 478-3698 AND 478-3691. THANK YOU. *AK

THE GENERATOR EXHAUST OUR 1998 BOUNDER 32K SEEPS BACK INTO THE MOTOHOME AND RAISES THE CO2 LEVELS TO UNSAFE LEVELS. THIS RESULTS IN THE CO2 DETECTOR BEING SET OFF. THIS HAS HAPPENED EVERY TIME WE HAVE USED OUR MOTORHOME.

MODEL 32H - REAR OF VEHICLE WITHIN 500 LBS MAXIMUM AXLE RATING WITH NO WATER, NO GEAR, AND 3/4 TANK FUEL. 100 GALLON (800 LBS) WATER TANK AND ALMOST ALL AVAILABLE STORAGE BEHIND REAR AXLE. VEHICLE WILL ALMOST ALWAYS BE OVER RATED REAR AXLE WEIGHT WHEN IN OPERATION. PROBLEM CORRECTED IN 1999 MODEL WITH LONGER WHEELBASE AND HIGHER RATED REAR AXLE. RECALL ACTIVATED FOR SLIDEOUT MODELS, BUT NOT STANDARD MODELS LIKE MINE. FLEETWOOD AND FORD NOTIFIED A YEAR AGO WITH NO ACTION TAKEN. NO FAILURE YET (YOUR FORM WILL NOT ACCEPT ZERO FAILURES), BUT AM CONCERNED ABOUT THE FUTURE.

IF DOME LIGHT SWITCH IS TURNED ON, BOTH HEADLIGHTS INSTANTLY BURN OUT. FUSE LEFT IN BY MISTAKE AT FORD. ALL FORD F-53 CHASSIS (1999) IT ALSO DRAINS BATTERY WHEN STORED. FIX--REMOVE FUSE THAT ENABLES DOME LIGHT SWITCH. DOMELIGHT SWITCH IS PART OF DASH DIMMER SWITCH.