2007 FLEETWOOD TIOGA Complaints

TL* THE CONTACT OWNS A 2007 FLEETWOOD TIOGA. WHILE DRIVING 55 MPH, THE SEAT BELT FOR THE PASSENGER SEAT FRACTURED AND FAILED TO LATCH. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 15,750. UPDATED 08/02/16*LJ

NO UNUSUAL CIRCUMSTANCES. CLEAR DRY PAVEMENT. NY THRUWAY. SUDDEN COMPLETE TREAD SEPARATION ON RIGHT INSIDE DUAL TIRE. SIGNIFICANT DAMAGE TO CARGO COMPARTMENT BEHIND THE WHEEL WELL. DESTROYED TAILPIPE HANGER BRACKET. DENTED BOTTOM OF CARGO BIN DOOR.REPLACED TAILPIPE HANGER BRACKET. REPLACED BOTH DUAL TIRES THREE WEEKS LATER NEAR RAPID CITY SD A 2 FOOT PIECE OF TREAD ON THE LEFT INSIDE DUAL SEPARATED WITH MINOR DAMAGE TO THE CARGO BIN AND DAMAGED THE BODY TRIM AROUND THE WHEEL WELL OPENING. BOTH TIRES WERE REPLACED REPAIRS PENDING. OLD TIRES NOT AVAILABLE BUT HAVE PHOTOS. MICHELIN 225/R75/16 MS 06 YEAR. . 2007 FLEETWOOD TIOGA SL27000 MILES BEFORE FIRST FAILURE 29,000 AT SECOND FAILURE. RV WAS UNDER GVWR NEVER DRIVEN A SINGLE DAY IN 3 YEARS WITHOUT CHECKING TIRE PRESSURE. DRIVEN REGULARLY WEEKLY IN THE ENTIRE LIFE OF THE RV WHICH I PURCHASED NEW IN 2007. *TR

WE WERE DRIVING OUR RV AND SMELLED BURNING PLASTIC, WE STOPPED AND THE SMELL SEEMED TO GO AWAY. WE WENT ON AND LATER STOPPED AND LOOKED IN OUR COMPARTMENT, THE EXHAUST PIPE HAD BURNED A HOLE IN THE BOTTOM OF THE COMPARTMENT AND BURNED THROUGH THE BOTTOM OF THE PLASTIC CONTAINER, LUCKILY IT DID NOT BURN INTO THE FOUR BOTTLES OF BUTANE IN OUR COMPARTMENT, WE WOULD HAVE DIED. WE ARE TRYING TO CONTACT THE DEALER FOR CORRECTION. THE WARRANTY IS UP SO THE NEARBY PLACES WILL NOT HANDLE IT. IT IS A 2007 TIOGA MADE BY FLEETWOOD. THIS SEEMS TO BE A MANUFACTURE DEFECT, SINCE WE HAVE LESS THAN 3000 MILES ON IT AND HAVEN'T DONE ANYTHING TO IT. AFTER THIS WE EMPTIED THE COMPARTMENT AND PUT A METAL PLATE IN IT OURSELVES, TRYING TO GET SOME ASSISTANCE FROM FLEETWOOD. *TR

ON NOVEMBER 24, 2007 WE SENT A SIX PAGE LETTER TO FLEETWOOD AND DAN GAMEL'S CAMP AMERICA FOR SELLING US AN UNSAFE RV. THE BODY OF THE RV WAS NOT PROPERLY ATTACHED TO THE FRAME. WE PURCHASED THE RV ON OCTOBER 14, 2006. IT WAS ALWAYS DIFFICULT TO HANDLE. WE REQUESTED DAN GAMEL TO CHECK IT NUMEROUS TIMES. FINALLY, THEY SENT US TO A FRAME SHOP. THE RV HAD LESS THAN 4000 MILES ON IT. IT REQUIRED NEW REAR SPRINGS, REPAIR TO THE PLATE, U-BOLT, CENTER BOLT, CLIP ALIGNMENT CAM 1/2 DEGREE, BODY PLUGS AND AN ALIGNMENT. THEY DID NOT HONOR THEIR WARRANTY. THE REPAIR SHOP SAID THAT THE CONDITION IS NOT UNUSUAL ONCE THE RV STARTS TO SETTLE. THE DAMAGE COULD HAVE BEEN MINIMIZED IF THE BODY WOULD HAVE BEEN PROPERLY SECURED AT THE PRE-DELIVERY INSPECTION. THERE MAY BE OTHER RVS ON THE ROAD IN THE SAME CONDITION, THAT ARE HARD TO CONTROL DUE TO THE LOOSE BODY ON THE FRAME. WE ARE NOVICES TO CAMPING. WE WERE TOLD IT WAS A "LEARNING CURVE". WE ARE BOTH AVIATION MECHANICS AND WE CLEARLY COULD SEE THAT THE RV WAS UNSAFE. REQUEST THAT A REQUIRED INSPECTION BE ACCOMPLISHED AT THE PRE-DELIVERY INSPECTION OF ALL RVS TO ASSURE PROPER ASSEMBLY. *TR