2001 FORD E-150 Complaints

I CURRENTLY OWN A METICULOUSLY MAINTAINED 2001 FORD E150 VAN WITH A 4.6 LITER MOTOR. I HAVE APPROX 78000 MILES ON VEHICLE, AND RECENTLY STARTED HAVING SPARK PLUG ISSUES. TO MAKE A LONG STORY SHORT CHANGING THE SPARK PLUGS WITH ALUMINUM HEADS CAN POSSIBLY RUIN MY VAN DUE TO THE PLUGS BLOWING OUT OF THE HEADS. AT THIS TIME I'M NOT IN A POSITION TO BY A NEW VEHICLE DUE TO SOMETHING AS SIMPLE AND BASIC AS A SPARK PLUG. DUE TO THE LOCATION OF MOTOR IN VAN THE REPAIR IS COSTLY AND TIME CONSUMING. THE MORE RESEARCH I DO WITH THIS ISSUE I FEEL THIS IS A HUGE DESIGN FLAW. *TR

TL*THE CONTACT OWNS A 2001 FORD E150. THE CONTACT HEARD A LOUD KNOCKING NOISE AND NOTICED STEAM COMING FROM THE TAILPIPE ONCE THE VEHICLE WAS STARTED. THE FAILURE WAS DIAGNOSED AS A RISK PIN IN THE ENGINE. THE MANUFACTURER STATED THAT THERE WAS NO REMEDY FOR THIS TYPE OF ENGINE FAILURE. THE FAILURE MILEAGE WAS 68,900.

THE OUTER COVERS OF ALL THE SEATBELTS IN THE 3RD ROW HAVE ALL FRACTURED RESULTING IN THE INABILITY TO LATCH ANY OF THE SEATBELTS. . THIS SOUNDS VERY SIMILAR TO THE FORD ESCAPE RECALL 03V507000. WHEN THE REAR OF CASING FRACTURED, THE INNER PART OF THE SEATBELT MOVED WITHIN THE CASING RESULTING IN THE INABILITY TO LATCH THE SEATBELT. ATTEMPTS AT REPAIR WERE UNSUCCESSFUL. *TR

TL*THE CONTACT OWNS A 2001 FORD E150. THE CONTACT RECEIVED FORD RECALL NOTICE NUMBER 05S28 IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL. HE FEELS THAT THE MANUFACTURER IS NOT WORKING HARD TO PROVIDE THE PARTS TO THE DEALER. THERE HAD BEEN NO FAILURE TO DATE. THE DEALER INFORMATION WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 67,000. UPDATED 03-19-08 *BF UPDATED 03/19/08 *TR

AQRE: FORD MOTOR COMPANY RECALL 05S28 FOR SPEED CONTROL DEACTIVATION SWITCH (SCDS). I RECEIVED A RECALL NOTICE IN AUGUST OF 2007 STATING THAT MY SCDS MAY BE DEFECTIVE AND CAUSE A FIRE WHETHER OR NOT THE VEHICLE WAS BEING OPERATED. THE SCDS NEEDED TO BE REPLACED. TO DATE ALL FORD MOTOR COMPANY HAS DONE IS TO HAVE VARSITY FORD REMOVE THE SCDS...THEY HAVE NOT SUPPLIED THE DEALER WITH ANY NEW PARTS TO REPLACE THE DEFECTIVE ONES. THE DEALER SERVICE REP HAS TOLD ME HE HAS NO IDEA WHEN OR IF REPLACMENT PARTS WILL BE PROVIDED. *CN

TL*THE CONTACT OWNS A 2001 FORD E-150. THE CONTACT STATED THAT THE ELECTRONIC IGNITION COIL HAD TO BE REPLACED ON SEVERAL OCCASIONS. THE COIL SLOWLY BECOMES DEFECTIVE. THE DEALER STATED THAT THE IGNITION COIL WAS BURNING OUT AND NEEDED TO BE REPLACED. THE REPAIR COSTS $300 EACH TIME. THE CONTACT HAD TO PAY $900 BECAUSE THE COIL WAS REPLACED THREE TIMES. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE COIL FAILURE. THE FAILURE OCCURS WHILE DRIVING UPHILL AND ON LEVEL GROUND AND THE VEHICLE ALSO LOSES POWER. THE CURRENT AND FAILURE MILEAGES WERE 41,000. UPDATED 12/31/07 *BF THE CONSUMER COMPLAINED ON SEVERAL OCCASIONS, THAT THE ENGINE LIGHT WAS ON. UPDATED *JB

I PURCHASED A USED 2001 FORD PICKUP ON 10/26/06. ON JANUARY 10,2007 IT CAUGHT FIRE WHILE BEING PARK OVER NIGHT. I REPORTED THE FIRE TO FORD AND THEIR RESPONSE IS THAT THE DAMAGE WAS TOO SEVER TO VERIFY ANY MFG DEFECT. I RECEIVED THE RECALL NOTICE THE FOLLOWING WEEK. FORD SHOULD NOTIFY BUYER'S SOONER! *JB

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, THE HORN BEGAN HONKING WITHOUT WARNING, AND WITH NO DISCERNIBLE CAUSE. WHEN THE VEHICLE WAS EXAMINED, THE INSIDE OF THE VAN WAS FILLED WITH SMOKE. THIS WAS ACCOMPANIED BY SMOLDERING WIRES IN THE RADIO PANEL BEHIND THE DRIVER SEAT. THERE WERE NO VISIBLE FLAMES, AND THE SMOLDERING WIRES WERE EXTINGUISHED. THE VEHICLE WAS NOT SEEN BY A DEALER.

HAVE HAD THE VEHICLE SINCE LATE 2001 WITHIN 5 MONTHS HAD TO BE TAKEN IN FOR BRAKE PROBLEMS DUE TO VIBRATION WHEN STOPPING. SINCE THEN THE VAN HAS HAD THE ROTORS REPLACED ONCE A YEAR WITH THEM BEING TURNED TWICE. BRAKE PADS ARE NEEDING TO BE REPLACED EVERY 5 TO 6 MONTHS. I HAVE CALLED FORD EACH TIME AS WELL AS THE DEALER. BOTH HAVE SAID THAT THIS IS A COMMON PROBLEM THEY HAVE WITH THESE VEHICLES. I DON'T PULL ANYTHING WITH MY VAN AND I AM NOT HARD ON THE BRAKES. THEY TOLD ME IT WAS BECAUSE THE FRONT END IS HEAVY. *JB

I WAS REAR ENDED. SEAT BELT DID NOT WORK AS IT SHOULD HAVE,CAUSING ME TO END UP WITH A BAD WHIPLASH. THE SEAT BELT DOES NOT RETRACT MOST OF THE TIME. I WAS NEVER NOTIFIED OF THES DEFECTS.*AK