1995 FORD ECONOLINE Complaints

AUTOMATIC TRANSMISSION MALFUNCTIONS, IT WILL EITHER SHIFT HARD AND LATE OR WILL GO OUT OF GEAR. DEALERSHIP REBUILT THE TRANSMISSION, BUT THE PROBLEM STILL EXISTS.*AK

THE FACTORY INSTALLED CAGE HAD BOLTS THAT WERE FASTENED TO THE SIDE WALL OF THE VAN. THE BOLTS HAD BROKEN THROUGH THE METAL, WHICH WOULD ALLOW THE CAGE TO MOVE FOWARD IN A COLLISION. JG *JB

WHILE DRIVING WAS UNABLE TO SLOW DOWN, VEHICLE WAS STOPPED WHEN IT HIT A BARN. HAD NO BRAKES. JUST HAD BRAKES CHECKED AND EVERYTHING WAS FINE. CONTACTED DEALER.*AK

WHEN VEHICLE IS STARTED AND TANK IS FULL THERE WOULD BE AN EXCESSIVE AMOUNT OF GAS FUMES PRESENT. FORD SAYS VEHICLE WAS NOT INCLUDED IN A RECALL. MECHANIC HAS FIXED VEHICLE. *AK

CONSUMER STATES THAT THE HORN IS VERY SMALL, CONSUMER STATES IF YOU DON'T HAVE THE STEERING WHEEL IN THE CORRECT POSITION YOU WON'T BE ABLE TO BLOW THE HORN. CONSUMER FEELS THIS IS UNSAFE BECAUSE HE IS UNABLE TO WARN THE NEXT DRIVER. *JB *YH

DOT#MD11 520V 344; TIRE SIZE LT245/75R16 ONE OF FOUR TIRES FAILED WITH A SIGNIFICANT SIDEWALL BULDGE NOTICED BEFORE FINAL FAILURE. SEARS REPLACED TIRE PRO-RATED FOR WEAR, BUT REPAIR PERSON SEVERELY OVER-TORQUED LUG NUTS REQUIRING REPLACEMENT OF LUG BOLTS AND NUTS. NOT CONFIDENT OF REMAINING THREE TIRES; NOR THE SERVICE PEOPLE WHO MIGHT REPLACE THE WHEELS. NOT ENOUGH SPACES ON YOUR ONLINE FORM FOR TIRE SIZE AND DOT#. MFG #? 272892GRF66 A 15 PASSENGER VAN SHOULD HAVE GOOD TIRES. (DOT NUMBER: MD11520V34 TIRESIZE: LT24575R16)

ABS CONTROL UNIT FAILED 1996 AND REPLACED. FAILED AGAIN DEC 2001 AND REPLACED FOR $761. A MULTI-TON 15 PASSENGER VAN SHOULD HAVE WORKING ABS BRAKES. WITH THE REPAIR COST, I SUSPECT MANY OWNERS ARE NOT FIXING THE DEFECTS AND IT IS UNDER-REPORTED. APPARENT PART NUMBER CHANGE SUGGESTS POSSIBILITY FORD KNOWS OF A PROBLEM AND HAS NOT REPORTED IT. NARROWLY AVOIDED MAJOR COLLISION WHEN ABS WERE INOP. *AK

STALLED WHILE MOVING BECAUSE OF BLOWN 60 AMP FUSE. AUTO SERVICE HAD TO FIND WIRE THAT SHORTED (TOOK 6 HOURS) SPLICE THAT WIRE AND COVER IT. TOTAL COST WAS $585 INCLUDING TOW.*AK

WHILE DRIVING ON HIGHWAY AT A SPEED OF 65MPH VEHICLE BEGAN TO SURGE. I ATTEMPTED TO ACCELERATE WITH THE ACCELERATOR PEDAL COMPRESSED ALL THE WAY DOWN TO THE FLOOR, BUT ENGINE DID NOT RESPOND AND EVENTUALLY STALLED AS I PULLED OF ONTO THE EMERGENCY LANE. ATTEMPTED SEVERAL TIMES TO START ENGINE, IT WOULD RUN FOR APPROXIMATELY 10 SECONDS AND SHUT DOWN. WEATHER THAT DAY WAS SUNNY WITH TEMPERATURES AT THE TIME OF TRAVEL ABOUT 90 TO 95 DEGREES FAHRENHEIT. AT THE TIME OF THE INCIDENT, I HAD DRIVEN ONLY 250 MILES OF A 730 MILE TRIP. I HAD DRIVEN THIS SAME ROUTE JUST FOUR DAYS PRIOR. I WAS TOWED TO THE LOCAL FORD DEALERSHIP RIGHT AT CLOSING TIME FOR SERVICE DEPARTMENT SO MY VEHICLE WAS NOT CHECKED OUT UNTIL THE FOLLOWING MORNING. AFTER SEVERAL HOURS OF TROUBLESHOOTING, THE MECHANICS COULD FIND NOTHING WRONG. I PROCEEDED ON MY TRIP DURING THE EARLY EVENING HOURS WITHOUT ANY PROBLEMS. THE VEHICLE IS IN PERFECT OPERATING CONDITION WITH ALL REQUIRED PERIODICAL MAINTENANCE COMPLETED BY FORD SERVICE AND THE ONLY CORRECTIVE MAINTENANCE WAS FOR A LEAKING TRANSMISSION COOLING LINE IN ENGINE COMPARTMENT. AFTER DOING SOME RESEARCH ON THE AUTO SAFETY CENTER WEB SITE, I AM A BIT SUSPICIOUS OF A POTENTIAL HIDDEN PROBLEM. *AK

WHEN BRAKES ARE ENGAGED ONLY LEFT FRONT WORKS. HAVE REPLACED PROPORTIONING VALVE, REAR WHEEL CYLINDERS, ONLY GETTING 4,000 MILES ON FRONT PADS. CHECKED FUSES RELATING TO AREA-NO PROBLEMS.