2016 FORD EDGE Complaints

Coolant is being leaked into the #2 cylinder causing the car to misfire. Coolant isn't a lubricant and it causes wear in the cylinder. Also causes a misfire like water in your gas. I have a car that 98% of that this type of car works correctly but the broken 2% will cost $8000 due to the block needing replaced. Ford knows that this is an issue that goes back 5 or 6 years, but yet has not made a recall nor gives any program to be fixed.

The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 55,000.

The contact owns a 2016 Ford Edge. The contact stated that while attempting to start the vehicle, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 22-2133 (Coolant intrusion in Cylinders, White Exhaust Smoke); however, the VIN was not included. The manufacturer was notified of the failure but offered no assistance and closed the case. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 68,163.

The contact owns a 2016 Ford Edge. The contact stated that while driving at a slower speed, the steering wheel became difficult to maneuver. The contact stated that several messages were displayed. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed that steering gear needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V632000 (STEERING); however, the VIN was not included in the recall. The manufacturer was notified of the failure and opened a case. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 105,985.

The engine block is leaking coolant into piston cylinder #4. This caused misfires resulting in reduced power when needed causing a few close call accidents. The loss of coolant could have also cause the engine to overheat and catch fire due to the loss of coolant. Yes, the check engine light came on in early March 2025 so I took it to Advanced auto and O'Reilly's for for diagnoses at first, both advised to replace spark plugs and wires. Since plugs and wires were new, I took my 2016 Ford Edge 2.0L ecoboost to my local dealership. Yes, the local ford dealership diagnosed the problem as coolant leaking into cylinder #4 with the fix as being an engine replacement.

The contact owns a 2016 Ford Edge. The contact stated that the check engine warning light was illuminated. The vehicle was taken to Homestead Auto, where it was diagnosed with coolant intrusion into the cylinders. The mechanic determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was towed to the dealer, who determined that coolant intrusion into cylinder #3 had resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 56,000.

While driving through a small town +-500 miles from my home the 2016 Edge lost power with no warning. I barely got to a gas station for help. No fluid leaks, no smoke, no check engine light prior to fail. Was running great until it didn’t run anymore. Police checked on me and noted my back end was sticking out into the street a bit, couldn’t move it. Had it towed, got a hotel room due to how far away from home this happened. All local mechanics were booked 2+ weeks out but this one ran diagnostics sooner and suggested engine replacement. Had it towed to closest Ford dealer for 2nd opinion. They suggested same. I had serious (couldn’t start completely dead several times, no prior warnings) and not so serious (radio, seat, door) electrical problems earlier in ownership where Ford engineer came across state to recalibrate. I don’t have documentation on this but I think it took him like 4 hours at Ford Seelye Kalamazoo but it should be in vehicle history. With these two MAJOR exceptions (and no warnings) my Edge ran great. I feel we took great care of it, has zero rust, just over 81k miles and bought it new just over 8 years ago (as of this writing). Just replaced tires, rims, brakes within this year. Filled my gas tank full just before fail. We were told it would cost $2400 to tow it back home. Called Ford road assist for suggestions and relief and they stated that since it’s over 8 years and 80,000 miles they offer nothing. Bought it new on 6/30/17 and engine failed on 6/18/25 (just under 2 weeks of 8 years) and 1,336 miles over of any responsibility on Ford Motor Company. There should be a Ford customer service case number.

The transfer case on my 2016 Ford Edge Titanium AWD cracked and failed at approximately 76,000 miles. For months prior, the vehicle showed warning signs including a strong burning smell inside the cabin, jerky movement while reversing, and rubbing or grinding noises during low-speed turns. I sought help multiple times, but the issue was not diagnosed despite repeated service visits. Eventually, the vehicle was taken to another repair facility where, during a test drive, the transfer case fully cracked while the mechanic was driving. According to the technician, the vehicle began smoking and was no longer safe to operate, and he immediately turned around to avoid further risk. The mechanic explicitly told me he was thankful it happened to him and not to me or my family, as it could have been much worse had it occurred on the road. The damaged part has since been replaced, but I have photographs of the failed transfer case attached to this complaint. Safety Risk: The failure made the vehicle inoperable and unsafe to drive, with serious risk of mechanical seizure or loss of control if it had occurred under different conditions (e.g., on the highway or in traffic). There were no dashboard alerts or warning lights—only progressive, difficult-to-pinpoint symptoms. Problem Prevalence and TSB History: Afterward, I discovered that transfer case failures are a known issue on Ford Edge models, and that the 2016 model year has an unusually high number of Technical Service Bulletins (TSBs) related to powertrain and drivability issues. These include: TSB 18-2057, related to strong cabin odors TSB 18-2255, related to transfer case leaks and driveability problems Given the number of complaints online and the pattern reflected in these TSBs, this points to a broader reliability and safety issue with this component in this model year. Inspection History: The vehicle was evaluated multiple times for these issues and was ultimately diagnosed by a certified repair technician af

This is the second time the driver seatbelt has locked itself and won't extend. The fix is to remove the seatbelt and send it in for repair. This seems serious as it forces me to drive without a seatbelt.