2018 FORD EDGE Complaints

The contact owns a 2018 Ford Edge. The contact stated that upon starting the vehicle, the engine was misfiring, and there was white smoke coming out of the exhaust pipe. The vehicle was taken to AutoZone, then to an independent mechanic, where it was diagnosed and determined that there was a misfire in cylinder #1. The mechanic replaced the spark plugs and ignition coils; however, the failure recurred. The check engine warning light was illuminated. The vehicle was taken back to the independent mechanic, where two temperature sensors were replaced; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion in cylinder #1. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The contact related to the failure to TSB Number: 19-2346. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 64,000.

We had stopped to get a soda and when we came back out and started the vehicle the steering wheel turned 90 degrees so the straight position was now 12 and 6 vs 3 and 9, I tried to shut the vehicle off and restart it and no change in steering wheel position. There was also an adaptive steering error on the dash. Another issue with this was that you could no longer see the speedometer as the steering spoke was covering it, we drove to the closest Ford dealer from where we were and we were told they didn’t have time to look at it on that day. I confirmed with the cashier that they were sending us away with a vehicle with a steering issue and the cashier once again just said they could not look at it on that day which I was not asking them to do I just wanted to leave it and go off in a loaner that I was able to get under the extended warranty. We went to the second ford dealer that was closer to our home and they took the vehicle in and 2 different service writers stated they had never seen anything like this before. they had the vehicle for a total of 3 weeks to diagnosis and replace the steering wheel and try to get the wheel back into alignment which took 2 trips. The second visit we met with the master tech at Ford country who went for a drive with us and could see that the Ford emblem in the center of the wheel was not straight and it took them 2 or 3 attempts to get it straight and the master tech with 35 years of experience stated they had only seen this 1 other time in all their years of working on vehicles. I just do not have confidence in the vehicle any longer and just keep thinking about what if this happened while we were driving and not just in a parking lot. I no longer feel safe in the vehicle

Ford’s 2.0L EcoBoost engine failed on our on a 2018 Edge. The vehicle and engine are available for inspection. The engine suffered a catastrophic failure and must be replaced per Technical Service Bulletin (TSB) 19-2346. Ford issued TSB 19-2346 on coolant loss/need for engine replacement in 2019. They had a class action lawsuit in 2012 on EcoBoost engines allowing coolant in cylinders. Ford had a chronic problem with these engines for years but kept selling them. There is a recall for some 2015-2018 Edges and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engines. I’m not sure why my 2018 Edge is not part of the recall, since the engine has failed per TSB 19-2346. The problem was diagnosed by a certified mechanic, diagnosis attached. I filed a case (#[XXX]) with Ford Customer Service, who denied any responsibility because my extended powertrain warranty (which I believe lasted until 100,000 miles) expired 3 months before the engine failure was diagnosed. I also wrote a letter (attached) to Ford Consumer Affairs, which remains unanswered. A check engine light appeared just days after Ford performed a routine 60,000 mile service. Ford reported no problems and did not indicate that our vehicle was at risk under of TSB 19-2346, even though this TSB and problems with the 2018 Ford Edge have been known about by Ford since at least 2019 when the TSB was issued. In addition to the check engine light, we started losing/and replacing small amounts of coolant, which we attributed to a hose leak. A few months later, a certified mechanic then diagnosed the problem as TSB 19-2346. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated while driving 55MPH, the check engine warning light illuminated. The message "Engine Hot" was displayed. The contact pulled over to the right side of the roadway, turned off the vehicle, and after three hours, the contact added coolant to the coolant reservoir and restarted the vehicle. A dealer was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The contact was referred to the NHTSA Hotline for assistance. The contact related the failure to TECHNICAL SERVICE BULLETIN: 22-2229 (Eco boost 2.0L Engine Failures), and the contact related the failure to the TSB. The failure mileage was 69,897.

The contact owns a 2018 Ford Edge. The contact stated that upon starting the vehicle, the engine was idling rough. The check engine warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that there was coolant intrusion into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 67,432.

2.0 ecoboost engine has a known flaw that causes the engine block to crack & introduce coolant into the cylinders. This is known to typically occur between 60 & 70,000 miles. It at the very least causes a misfire; at the most extreme it allows coolant into the oil & can cause engine lockup. Ford knows this is an issue & redesigned the engine in 2020. Our car developed this issue at 65k miles & Ford left us with a $9500 bill 1 month after warranty expired for a new engine

I have had my vehicle in for regular service since I purchased it. It has had two transmissions, one to repair a prior repair and now I am told that the engine needs to be replaced. Ford has a TSB for this issue, as it is a known fault with the engine. According to the dealer this is TECHNICAL SERVICE BULLETIN 2.0L EcoBoost - Coolant In Cylinders, White Exhaust Smoke And/Or Illuminated MIL 22-2229 This affects the following vehicles 2015-2018 Ford Edge 2017-2019 Ford Escape Built on or before 16-May-2019 2017-2019 Ford Fusion Built on or before 8-Apr-2019 2017-2019 Lincoln MKC Built on or before 18-Apr-2019 2017-2019 Lincoln MKZ Built on or before 8-Apr-2019 This repair is estimated at $8,800. This after a $5,000 dollar repair on the Transmission and five weeks of being out of service. When one purchases a vehicle it should not lose two transmissions and an engine in less than 100,000 miles of service

The contact owns a 2018 Ford Edge. The contact stated that the vehicle was taken to a local dealer to have the air conditioning inspected, and the contact was informed that the coolant reservoir was cracked and needed to be replaced. The coolant reservoir was replaced. The contact stated that several days later, while attempting to start the vehicle, there was an abnormal amount of black smoke coming from the vehicle with the check engine warning light illuminated. The vehicle was taken back to the dealer to be diagnosed, and the contact was informed that, due to coolant intrusion into the engine, the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 110,411.

The contact's wife owns a 2018 Ford Edge. The contact stated that while the vehicle was idling, there was smoke coming out of the exhaust pipe. The contact stated that while driving, the engine overheated and the vehicle failed to exceed 15 MPH. The contact stated that the check engine warning light was illuminated. The contact stated that while driving on several occasions, the vehicle lurched forward. Additionally, the contact stated that the vehicle had failed to start-up for a week. The vehicle was taken to an independent mechanic, where it was diagnosed with coolant intrusion in the engine. The vehicle was then taken to the dealer, where the same assessment was made, and the dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 69,000.

I am filing a formal complaint regarding a potential failed or insufficient recall repair related to NHTSA Recall 22V413 / Ford Recall 22S43 on my 2018 Ford Edge (VIN: [XXX] ). Ford replaced the shift cable bushing in Sept 2022. Within months, I experienced symptoms consistent with the original defect, including gear engagement issues, especially on inclines. One day, after shifting into reverse in a parking lot, the car rolled forward. I had to slam the brakes to avoid hitting another vehicle and feather the gas to reverse. These issues continued. Despite multiple service visits and reporting concerns, the dealership failed to document the problem. In Sept and Nov 2024, I again contacted the dealer. On Dec 18, 2024, they finally provided a loaner and inspected the vehicle. A full teardown revealed internal damage: metal debris in the solenoid body, worn sun gears, and failed clutch components—consistent with long-term gear misalignment. Ford has offered partial financial help but refuses to cover the full cost, leaving me with over $1,300 out-of-pocket despite raising concerns during the warranty window. As of June 16, 2025, the vehicle is still disassembled and remains in the dealership’s service bay with no firm repair date. I have been without my personal vehicle for six months. I respectfully request NHTSA to: Investigate whether recall 22V413 repairs are failing prematurely or inadequately prevent long-term damage. Assess whether further manufacturer responsibility is warranted for failures linked to this recall. Encourage Ford to fully cover repair costs under an extended remedy. Consider requiring a recall performance audit or extended warranty for affected vehicles. Thank you for reviewing this safety matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)