2018 FORD EDGE Complaints

The contact owns a 2018 Ford Edge. The contact stated while driving at approximately 50 MPH, the check engine warning light illuminated. The contact attempted to activate the heater however, only cold air was blowing out of the vents. The vehicle was taken to a local dealer who diagnosed that there was coolant intrusion into the engine block. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 98,000.

The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was parked, the vehicle was started, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 105,000.

The contact owns a 2018 Ford Edge. The contact stated that while having a routine inspection at the local dealer, the vehicle was diagnosed, and it was determined that there was an oil leak to the oil pan gasket that needed to be replaced. There were no warning lights illuminated. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 48,000.

Coolant entering the cylinder Wouldn't allow us to drive car home Convinced us to purchase a new vehicle.

The issue is Coolant intrusion in the #2 cylinder. Rough idle when starting and white smoke. Ford bulletin 22-2229 The issue was confirmed by the dealer Capital Ford of Wilmington Dec of 2024. Yes, the problem stated prior to engine light coming on. It starting getting worse.

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no difference. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Ford finally agreed to cover part of the repair costs but still left me with a $3,000 bill. Car is now repaired but I'm hoping to recoup some of my expenses now.

Fly wheel and flex plate broke causing the car to lose power. The car then stopped having use of the transmission so was unable to move the car.

A manufacturing defect has caused coolant to leak into the engine which can lead to an engine fire. Many other people with he same engine have reported the same issue.

Vehicle began to rough idle, and then while driving the vehicle MIL came on, as well as a "Engine overheat throttle limited" error. Pulled over and vehicle would not move. Tried to power cycle the vehicle and would not start back up. Had it towed to dealer and was told this was the long block coolant intrusion problem that leader to my engine completely failing. I was made aware of Ford TSB 19-2346, and told the repairs would be $9200. After googling around, this is a common problem on these 2018 ford ecoboost engines and Ford obviously knows there is a problem that could cause accidents or engine fires. Luckily my kids were not in the car, otherwise this could have been catastrophic due to the loss of power while driving. I called Ford support and they told me that Ford has no programs to help affected customers. There should be a Recall and Ford should be forced to replace or repair affected engines as this will get someone killed if they lose power or have an engine fire while driving.

Coolant leaking into engine cylinders. Had an independent service center state we need a new engine. The labor cost to replace the gasket would add up to the cost of a new engine. Told us Ford had corrected the engineering problem that caused the leak. Said it was common problem with the Ford Edge vehicle.