2018 FORD EDGE Complaints

Coolant intrusion into engine cylinder. Requires long block +engine build. Issue reported at around 75000 miles.

Check engine light came on and I checked the code with a reader. The code came up to a cylinder 2 misfire. Made an appointment with local dealership for diagnostic of the issue. Before the appointment was able to happen the check engine light went off. Appointment cancelled and 2 days later the check engine light came back on so made a new appointment. Continued to drive car with no issues. Brought car in for service and received a report back that cylinder 2 & 3 misfire and was advised coolant leaking into the engine and recommended repair is a new engine. After a quick google search found that this is a widespread issue with this engine.

In September 2024 (just over 68k miles) my check engine light came on in my 2018 Ford Edge, car overheated, smoke from tailpipe and would no longer run. I had it towed to the dealership where it was determined that it needed a whole new engine. This is the same engine that is recalled or warranty extended for the Escape but not the Edge! 2 weeks later, I paid thousands of dollars to have the engine replaced. Today, less than 3 months later and only a few hundred miles after a new engine- the check engine light is flashing and the vehicle is sputtering. This vehicle is used to transport our children and get us to/from work. This is completely unacceptable and unsafe. The vehicle is, once again, unable to be driven. I have contacted Ford Customer Service who has advised we make another dealership appointment and they are not open currently. Something needs to be done about this vehicle!

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no different. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Safety concern is the engine started to overheat. Fortuantely we stopped before anything serious happened, but found several reports online of this causing engine fire and destroying the car.

The contact owns a 2018 Ford Edge. The contact stated that the heater was not working properly. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that coolant was leaking into the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 19-2208 and 22-2229. The manufacturer was notified of the failure. The approximate failure mileage was 44,900.

The contact owns a 2018 Ford Edge. The contact stated while accelerating from a complete stop, the vehicle hesitated while responding. The contact stated that the failure progressively worsened. The contact also noticed that the vehicle was experiencing excessive coolant consumption. The check engine warning light was illuminated. The contact stated that upon starting the vehicle, the vehicle experienced a rough start and was shuddering temporarily. Additionally, the contact stated while attempting to drive from a complete stop onto the road, the message "Caution - Coolant Temperature Overheat" was displayed, and the check engine warning light was illuminated. The vehicle went into LIMP Mode. The contact stated that upon depressing the accelerator pedal again the vehicle was sputtering and was significantly sluggish. The contact stated that the vehicle was able to accelerate to 30 MPH after driving for 1 mile. The vehicle was driven to the residence. The vehicle was towed to the dealer, where it was diagnosed with coolant intrusion in the cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and offered to partially cover the repair. The failure mileage was approximately 52,000.

I took my vehicle in for a check engine light to the dealership. It has been diagnosed with coolant intrusion. There is a current recall but I’ve been told my vehicle isn’t in it even though this is what is wrong with my vehicle

Symptoms: Coolent level would go low; White smoke from exhaust; Vehicle would run rough; Coolent was in cylinder; and Check engine light would indicate. I took vehicle to my local Ford dealer. I was told this is a known issue with my vehicle and that the engine needed replaced. See previous Complaint # 11558954

When refueling and the engine is on the revolutions (rpm) go up and down and then engine will turn off by itself. It then takes 2 to 5 minutes to restart engine and then you have to raise the rpm’s until it’s drivable. During this process you can also smell fuel from gas tank area.

I am told my torque converter clutch is slipping, and I am recommended to replace my torque converter and pump despite the vehicle having only 64,000 miles driven. Transmission parts are failing despite having a relatively young car. The vehicle was inspected at a Ford dealership and a diagnostic was performed to find this defect. I have investigated if there is an open recall for my VIN and none appear, although the torque converter on 2018 Ford Edge Titanium vehicles have recalls on them. Prior to the failure, a wrench icon as well as the check engine light were turning on and off between uses of the vehicle. These icons both turned off prior to bringing my vehicle to the dealership, indicating to me that there was no longer an issue present, though the dealership stated through their diagnostic that there indeed was still an issue with the transmission.