2016 FORD EDGE Complaints

The contact owns a 2016 Ford Edge. The contact stated while starting the vehicle, there was white smoke coming from the exhaust pipe. The contact stated that the vehicle was vibrating and was idling roughly. The contact stated that the check engine warning was illuminated. Additionally, the contact stated that the coolant reservoir was refilled weekly. The contact had not taken the vehicle to a local dealer however, the dealer was contacted and informed the contact that the failure was probably caused due to coolant leaking into the engine block and that the engine needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin Number: 19-23246 - Coolant in Cylinders, White Exhaust Smoke And/or Illuminated MIL (Engine and Engine Cooling). The contact stated that the vehicle was no longer able to be driven and would not start. The manufacturer was informed of the failure. The failure mileage was approximately 72,000.

Rear window suddenly shattered while driving . No other vehicles around . Entire windshield shattered and pieces are now falling into back hatch area . There were no passengers with me at the time . This renders the car not safe to drive . I was pulling into my driveway but had I been out on the highway (In January) this would soon become an issue of exposure to below freezing temperatures. Ford claims they have never heard of this when I’m finding other reports of this happening online . Dealership is saying it’s replaced at all my cost also ? Seems like a manufacturing fault ? There is a FSA # [XXX] that Canadian owners have listed. My car originally was sold in North Dakota. Currently I’m in Nebraska . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Edge. The contact stated that the vehicle failed to start up after several attempts after refueling. Once the vehicle was started, the vehicle sometimes hesitated and occasionally stalled while driving at various speeds. The contact stated that the failure persisted and intermittently stalled during normal driving with the check engine warning light illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was informed that Evaporative Emission Control System (EVAP) solenoid valve was defective. The manufacturer was notified of the failure and provided the contact a case number. The contact was then referred to the NHTSA Hotline for additional assistance. The vehicle was not repaired. The failure mileage was approximately 30,000.

There is a continuous cylinder 1 misfire and rough idle at start. Have replaced spark plugs, replaced valve cover gasket and spark plug tube seals and coolant continue to drain quickly with cylinder 1 misfire check engine light popping up every week.

coolant leaked onto the cylinders of the engine causing engine failure. This has been confirmed from Ken Stoepel Ford service center and is a known issue. Vehicle check engine light came on and at the same time the vehicle started running rough which is when I took it to the dealership to be diagnosed. It’s a safety concern because this can cause overheating and a fire. On top of that the known defect has ruined my engine. This has been an ongoing issue for the ecoboost engine for many people but has yet to be recalled. Vehicle has not been driven since being diagnosed.

As identified by my VIN number, I have a 2016 Ecoboost Ford Edge. Since 2022 I've been dealing with a failing engine from constant leaking of coolant fluids into the internals of the engine. This leaking of coolant is causing excessive white smoke to push out of my vehicles exhaust system. I'm constantly putting additional coolant into the reserva. I've been periodically stranded stranded on the side of the roadway from the engine overheating. Until I discovered that there is a known issue with this vehicle, I have spend hundreds of dollar on repairs based on the check engine light codes. Then on Jun 17th, 2024 I took my vehicle to a Ford service center and after paying over three hundred dollars for an diagnostics test I was told I need a new engine.

Overheat/Power loss indication on 2016 Ford Edge with Ecoboost 2.0 resulting coolant leakage into #2 cylinder verified by dealer (failure per TSB [XXX]). Prior TSBs [XXX] have been issued for same problem, but Ford did not assign our VIN to those bulletins. Problem should have been identified when vehicle was under warranty if TSB application were complete. We had P302 code (cylinder 2 misfire), so plugs/coils were replaced. 3 days later ([XXX]) we were traveling home from dinner (approx. 35 MPH, about 3 miles from home) and got a "Overheat" indicator with an indicator stating something similar to "Engine Loss of Power" light. Parked car at home, topped off coolant the next morning and had white smoke from the exhaust upon start-up. Vehicle towed to Ford dealer (01/09/24)...vehicle had not been driven, awaiting dealer availability for diagnosis. Relevant Ford dealer notes on Repair Order are as follows: "PRESSURIZE COOLING SYSTEM AND LEFT OVERNIGHT, FOUND IN A.M. LOSS OF MOST OF PRESSURE. CHECK HISTORY FAULT CODES, FOUND P0302, P0217. REMOVE CYL 2 SPARKPLUG AND CHECK WITH BORESCOPE. FOUND EVIDENCE OF MINOR COOLANT INTRUSION, CLEAN PISTON AND SHINY SLIGHTLY WET. FAILED ENGINE TSB [XXX]. NEED REPLACE LONG BLOCK." There are multiple reports of engine fires and other issues resulting from this condition [XXX] ). This is my mother-in-law's vehicle and I'm advocating for her. I contacted Ford Customer Care, said that they couldn't do anything to help due to family not meeting standards for incentives...in other words since my mother-in-law doesn't buy cars annually, they won't help even though she has been a loyal ford customer. They referred me to NHTSA to request that the VIN be added to the TSB, then they may cover repairs. Contacted NHTSA who confirms that is solely Ford's decision. They stated that Ford routinely misstates NHTSA's role in this process. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle had repeated failures of the electrical steering system. While driving, the failure occurred making it nearly impossible to steer. On certain occasions, the car stalled. If turned off, the error might clear, work for some time, then fail again. One morning, it came up with the failure codes before starting (16 degrees) even after working the night before. Then work later in afternoon after temperature had warmed up.

The contact owns a 2016 Ford Edge. The contact stated while starting the vehicle, the vehicle was running rough with white smoke coming from the exhaust system. The contact stated that the check engine warning light was illuminated. The vehicle was driven to an Auto Parts store and diagnosed using a handheld scanner and it was determined that there was a coolant leak into cylinder #2. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact researched online related the failure to Technical Service Bulletin Number: 19-2346 Coolant Intrusion into Cylinders (Engine and Engine Cooling). The failure mileage was approximately 84,000.

The contacts own a 2016 Ford Edge. The contact stated that while reversing out of the garage, the contact attempted to turn the steering wheel, but the steering wheel failed to turn. The check engine warning light illuminated and stated that the "Hill Start Assist Not Available”, Steering Assist Fault Service Required, Service Advance-trac" message was displayed. The vehicle was towed to the Auto Service Center and was not repaired due to parts not being available. The vehicle was not included in NHTSA Campaign Number: 19V632000 (Steering). The manufacturer was made aware of the failure. The failure mileage was approximately 133,000.