2018 FORD EDGE Complaints

The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was idling, the vehicle struggled to remain running. The contact stated that the failure persisted, and the check engine warning light illuminated. The contact took the vehicle to a dealer where it was discovered that there was coolant on the spark plugs, with coolant intrusion into cylinder #2. Due to the failure, the contact was informed that the engine needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 50,000.

100,000 Miles ad 2 months out of warranty -- dealer indicated the check engine light code of P0302 is a collant intrusion and the entire engine needs to be replaced for $10,454. This appears to be a reoccuring problem with Ford Edge Ecoboost.

The contact owns a 2018 Ford Edge. The contact stated that upon starting the vehicle, the vehicle was shaking abnormally with the check engine warning light illuminated. The contact took the vehicle to an independent mechanic where an OBD Scanner retrieved code for a misfire. The contact then had the spark plugs and ignition coils replaced; however, the failure persisted. The vehicle was then taken to another independent mechanic where it was discovered that there was coolant intrusion into cylinder #2. Upon investigation, the contact discovered Technical Service Bulletin: 22-2229. The dealer and the manufacturer were notified of the failure and informed the contact that there was no recall on the VIN. The vehicle was not repaired. The failure mileage was approximately 61,000.

The contact owns a 2018 Ford Edge. The contact stated that the dashboard lights were abnormally dim. The contact stated that after the vehicle was parked, the vehicle failed to restart. After waiting for a while the contact was able to restart the vehicle with the Push to Start button. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the electrical wiring underneath the rear panel was damaged due to water leaking into the compartment. The rear panel was replaced to prevent further failure. The contact was unsure if the wiring had been replaced. The manufacturer was made aware of the failure and confirmed the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 119,000.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the engine misfired, and the check engine warning light illuminated. The contact also stated that the temperature gauge indicated that the engine was overheating. The contact checked the coolant level and discovered that the coolant level was low; however, the contact stated that there were no indications of a coolant leak. In addition, the contact stated that smoke was coming from the exhaust pipes. The vehicle was taken to an independent mechanic where the vehicle was diagnosed with a blown head gasket. The contact was informed that the head gasket needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,500.

The engine began having a misfire around 58k miles and low coolant levels. No coolant drips or leaks were detected on the exterior. After some research I found that the 2.0 Ecoboost used in these vehicles is prone to coolant intrusion due to a defective engine block. After a trip the car unexpectedly would not start, it would crank over but it would not start. After sending it to my dealer they confirmed coolant intrusion and explained the car needed a new engine. The car was bought certified used, every service was done on time at a Ford dealer. There was no way to avoid the defective engine in this car, no amount of preventative maintenance would stop this from happening. Ford has a bulletin out on these engines, so they know there's an issue. There's no reason for a low mileage well cared for vehicle to need a replacement engine at 60k miles.

Faulty engine design (thin wall between coolant chamber and cylinders) allows for coolant to enter the cylinders. This leads to an overheating engine (that can catch fire) and ultimately creates a blown head gasket. This is a common issue in the Ford EcoBoost engines. There is a TSB on the 1.5 liter engines, but not the 2.0 on this model. There is currently a large lawsuit happening for this reason. Vehicles with under 60k miles are getting blown engines for this problem, most people still owe several thousand dollars on their vehicle when this happens.

The contact owns a 2018 Ford Edge. The contact stated that on several occasions while driving at various speeds, the check engine warning light illuminated. The contact stated that on one occasion the "Engine Overheating" message was displayed. The contact stated that the vehicle lost motive power and failed to accelerate as intended. The vehicle was pulled over to the side of the road and turned off for several minutes. The contact stated that coolant was added to the coolant reservoir. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced due to a coolant leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 69,000.

While driving vehicle on [XXX] Ocala, FL engine spontaneously overheated, which caused an immediate loss of engine power and a temporary loss of directional control as the power steering no longer functioned. I had the vehicle first towed to my house, and then had it towed to Gary Yeomans Ford Ocala. Their diagnosis led them to insist that coolant is intruding into the cylinder through the block itself, and the recommended course of action (under a very well known TSB) is to replace the long-block assembly. Ford is refusing to acknowledge this is a serious manufacturing defect that impacts customer safety, exposing the driver and the driving public to the possibility of an engine fire due to overheating, an accident due to inability to maintain directional control of the vehicle in an overheat scenario, and myriad other potential life-safety issues. Ford is making zero effort to assist their customers - a long block and assembly is almost $8000 - I barely had the money to make the payments and this may very well send me into bankruptcy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Overheating: antifreeze leaked into engine caused a fire risk. Engine had to be replaced at a cost of over $7,300.