2016 FORD EDGE Complaints

I have issue with brake hoses rupture while driving and loose brake capability (as Ford did not include all VINs affected I had to paid for repair, now they issue Customer Satisfaction Program 22N02 and they do not want to refund). NHTSA must make sure Ford is responsible for their issues on a safety topic as they are clearly not being.

My 2016 Ford Edge Titanium had a blown brake line so I took it in for repairs which is where I discovered that there was a head gasket leak and that the coolant reservoir was empty, and the axil was leaking. There were no puddles or other obvious indicators that there was anything wrong with the head gasket. No engine lights/codes were showing up. The mechanic at the Ford Dealership quoted me $5k to fix the head gasket and $10k for all of the repairs to include the brake line and 4 new tires. I have owned this car for 4 years and have had it serviced regularly.

In September/October of 2022 my passenger side right real break line ruptured. Not even a month later my front right brake line ruptured. Today my left rear brake line ruptured. All 3 times my pedal went to the floor, making it dangerously difficult to actually stop my car endangering my life and the lives of those around me on the road. No light has come on to indicate there's a problem with my braking system, any of the 3 times that this has occurred.

A 3nd flexible brake line blew out and I lost my brakes for the 3nd time on this vehicle. The first two lines that blew out were both left and right front. This 3rd one was in the rear and as a result I instructed my mechanic to replace both rear lines. Again and luckily no one was injured or crash occurred as a result of this failure which put my wife and I at a great risk. We were able to slowly and carefully bring the car to our mechanic immediately thus no tow was required. No police or first responders were needed. There was no indication of failure until the brake pedal went immediately all the way to the floor. This is my third filing report and the story is the same for the prior cases of 11512958 and 11512963.

A 2nd flexible brake line blew out and I lost my brakes for the 2nd time within a couple months.

The contact owns a 2016 Ford Edge. The contact stated while driving approximately 30 MPH and turning into a parking lot, the contact depressed the brake pedal however, the vehicle failed to stop immediately. The contact applied an excessive amount of pressure to the brake pedal and the pedal went to the floorboard before the vehicle stopped. The contact continued driving to the residence. After parking the vehicle, the low brake fluid warning light illuminated. The contact attempted to add brake fluid and became aware that the fluid level was not low. The contact noticed that the brake was still malfunctioning. The contact took the vehicle to the dealer and noticed and became aware that there was brake fluid underneath the rear of the vehicle. The dealer diagnosed that the brake hose needed to be replaced. The vehicle had not been repaired. The dealer confirmed that the failure was like NHTSA Campaign Number: 20V469000 (Service Brakes, Service Brakes, Hydraulic). The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000.

The contact owns a 2016 Ford Edge. The contact stated while driving 55 MPH, the contact lost control of the vehicle. The contact attempted to regain control of the vehicle but was unable to cause to and the vehicle struck the guard rails. The contact was able to regain control of the vehicle and the vehicle started to operate normally. The vehicle was taken to the dealer but not diagnosed. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 63,115.

MY VEHICLE HAS 60,000 MILES ON IT PURCHASED NEW AND ALWAYS MAINTAINED AT A CERTIFIED FORD DEALER. WHILE DRIVING ON THE FREEWAY AN ERROR CODE CAME UP ON THE DASH ADAPTIVE STEERING FAULT. MY STEERING WHEEL WENT OFF CENTER TURNED TO THE LEFT. I HAVE LOOKED ON LINE AND THERE WAS A BULLETIN FROM FOR IN 2019 TO FIX THIS PROBLEM OWNERS WERE SUPPOSED TO BE NOTIFIED AND WE WERE NOT. DELAERS WERE SUPPOSED TO FIX THIS IF LETTERS WERE NOT RECEIVED WHEN SERVICE WAS PERFORMED. I AM DOING ALOT OF READING AND DELAER SAYS COMPUTER MODULE NEEDS TO BE REPLACED 2600.00. ON LINE FORUMS SAY STEERING WHEEL REPLACEMENT. VERY FRUSTRATING TO HAVE A CAR WITH LOW MILES WITH A DANGEROUS UNSAFE SITUATION AND DELAER SAYS REPAIR THROUGH FORD IS NO LONGER AVAILABLE THAT THE PROGRAM EXPIRED.

The contact owns a 2016 Ford Edge. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer and the dealer stated the engine was misfiring. The contact stated cylinder #3 coil and spark plug was replaced; however, the failure recurred. The vehicle was taken to the dealer, and the dealer stated that coolant was leaking into the engine, and that the engine needed to be replaced. The vehicle was not replaced. The manufacturer was contacted, and the manufacturer stated that they are aware of the failure and that there was no recall associated with the failure. The failure mileage was 79,274. The contact stated that the engine was replaced and Ford covered a portion of the repair costs.

The contact owns a 2016 Ford Edge. The contact stated while attempting to start the vehicle, the vehicle failed to start. The contact had the vehicle jump started. The vehicle was taken to the dealer and the dealer stated that the gear shift sensor needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and the manufacturer stated that the vehicle was out of warranty. The failure mileage was 44,000. The contact stated that due to the failure, the vehicle required a third battery install. The contact took the vehicle to another dealer and was informed that the gear shift sensor needed to be replaced, that this failure was common in other Ford models. The battery was being drained despite being in park. The contact has had no further issues since the repair.