2016 FORD EDGE Complaints

The contact owns a 2016 Ford Edge. The contact stated while driving approximately 25 MPH, while depressing the brake pedal, the brake pedal went to the floor and did not reset which resulted in loss of braking. The contact stated no warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the brake hoses replaced. The vehicle was repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V469000 (Service Brakes, Service Brakes, Hydraulic) however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included. The failure mileage was approximately 80,341.

Had a check engine light come on saying misfire in cylinder 4, had the spark plug replace, check engine light came back on a week later. Took it to a Ford dealership & said the long engine block needed replaced due to coolant leaking into the cylinder.

My engine coolant got in one of engine coils causing engine to need to be replaced. There is a class action suit against Ford for this issue in the Edge.

I was driving from Phoenix Arizona to Tucson Arizona, about 1: 45 min drive, October 23rd, 2021, and all of the sudden the check engine lights turns on, and its getting hot, and the engine shuts down, I lose all power to the Steering , and brakes, now, i am going about 45 in a 75 lane, but people going 80 plus. and we are about 20 miles from home. WE finally able to pull over and check it out. I added water and let it cool down for about 30 mins, We took the frontage road driving around 30-35 miles per hour.. the light was on still but not over heating, till we got to the house when we saw the temperature going up, we shut it down,,, The next day i drove to a Mechanic close to the house, they ran the tests, and was advise that the engine had water in the motor, due to the engine being defective, they did tell us, that they have seen these a lot, in the edge and Escape, coming to their shop, took it to another mechanic (Ford Certified) and told us the same thing, no Good and you need to replace the engine at a cost of $6000- up to $8000.00, it only has 94k on the engine. they are seeing this across the USA. Its very dangerous, because when going 75 plus and your calls stalls out and slows down fast and cars and trucks had to go around us, some fish tailed almost out of control, we could have caused a MAJOR Pile up had not the car started for us to get to the side . God was with us, please look into this, We have the car parked, because we cant afford a new enginge. and still making payments on a CAR that done run thanks for your time rda

Broken Flywheel. 5 year/60,000 miles Warranty ended by date 4 months prior to diagnosis. Car currently has 57,000 miles. Took to dealer for engine rattle diagnostics exam. Was told it was the flywheel. Ford Technician stated it’s a common mechanical problem for this kind of vehicle. Ford is refusing to cover the repair. No prior warnings or messages presented to driver before or while engine rattle occurred. Was told to trade in the car as the flywheel can damage the engine thus totaling the vehicle.

The contact owns a 2016 Ford Edge. The contact stated that while the vehicle was running and closing or opening the door, the horn honked twice. There were no warning lights were illuminated. The contact called the local dealer who informed the contact about diagnostic fees. The vehicle was not diagnosed or repaired. The manufacturer was notified however, no further assistance was provided. The contact was concerned about the unauthorized use of the horn. The approximate failure mileage was 30,000.

IN novermber 2019 heard ratteling noise for engine took to dealer . they found a crack flex plate. they replaced the short block and transmission pump per the service bulletin this was at 56,000 miles. now at 86.000 same noise came back.to back to dealer same problem crack flex plate.the dealer and ford have both refused to cover this repair because it is now out of warrant.this is clearly a defective part that ford should have fixed and recall all cars with this engine. case#cas-34043931

Flexplate and Torque Converter caused the car to shake and lose power. It was confirmed by Ford Dealership and repairs through Ford Dealership. There were no warning lights, just a rattling sound from motor. The flexplate was replaced once already before this incident when the car was under warranty at 60,000 miles. It was replaced again this time at 98,000 miles.

A check engine light came on, I called Ford, told them what it was and took the earliest appointment was over a week away which they said was fine since it was just the regular check light. I Five days before the appointment, I started my car (push button), it didn't start, so I took my foot off the brake, waited a minute, put my foot back on the brake and tried starting it again, the car started but smoke started pouring out of the back of the car and the engine died. I had it towed to Ford and they said that coolant got into the fourth cylinder which ruined the engine, requiring an entirely new engine ($7000) on a six year old car Safety was put at risk because if this happened while I was driving instead of parked this could have caused a serious accident. This is a common problem among this model of car (and some other, similar models from Ford).

Vehicle engine light came on and car made loud noise when started. Brought to dealership. 2 issues with car. Coolant leaked into the engine which could cause a fire. Needed a new engine. Flex plate was cracked which could cause the vehicle to stop moving abruptly causing a crash. Flexplate and parts needed to be replaced. Flexplate issue has been recalled in the 2017 Ford Edge. Issues on-line show that this is common in 2015-2018 Ford Edges.